Golf IV R32 :: Cranks But Won't Start / No Spark And Fuel Pump Not Making Any Noise
Was driving normal and my 2004 r32 died. It felt just like it ran out of gas. Fuel pump was not making any noise. I replaced fuel pump relay and now i can here the fuel pump making noise. Pulled the fuel pump line off and fuel is coming out the line. So now i checked for spark and have none. I have 12 volts at the coils. I ohmed out the crank sensor and have .777 k ohms. I also checked codes with generic snap-on scanner and found no codes.
View 2 RepliesGolf IV / Jetta IV :: 01 - Car Only Cranks, Won't Start
About a month ago I went to start my car and it started up and died and now it won't start at all. All it does is crank and crank and crank. My vagcom say j271 relay open circuit . so I replaced the 428 relay and it still doesn't start. I'm also not getting any epc or cel light with the key in the on position which is strange to me. But if I swap the 428 relay with the 100 relay right next to it I get all the dash lights like I'm suppose to but as soon as I try to start it the two lights go out and won't come back on until I pull the relay out and put it back in. I hate obd2 so much sometimes.
View 2 RepliesGolf IV / Jetta IV :: 2000 - Oil On Spark Plugs?
I have a 2000 Jetta 2.8 VR6 (the 6-cyl) with 128k miles and I have oil on my spark plugs, only on one bank of the motor (the bank closest to the bumper, if that makes any difference). I am aware that it is most likely a leaking or worn out valve cover gasket, and I have a replacement and am prepared to replace it. What I need to know, and I can't find this exact part anywhere, is do I also need to replace the spark plug tube seals??? The gasket I ordered did not come with any tube seals, I can't find this part on any auto parts website at all, nor have I been able to locate anything useful on this, or any other, website. I know the 1.8 has plug tube seals, and they come with the gasket, but does the 2.8 also require tube seals? I imagine it would, but I just don't know.
View 2 RepliesGolf IV / Jetta IV :: No Spark - ECU Error Occurring
So driving on the highway my car died. It would crank but not start. Got it towed. This is what I have done to troubleshoot.
1. Swap ECUs. The car should start for a second and shut off because the car doesnt match with the ECU. Still just crank and no start.
2. Fuel pump still primes when I open the door. I also hear a weird air leaking noise when I reconnect the battery, but I think it comes from the fuel pressure regulator (which I think is normal).
3. Checked for current at the ecu wires, wasn't sure what to look for but it was getting numbers.
4. Battery had 12.1 volts running through it (Haynes said 12.5 but is that really much of a difference?
5. Checked spark plugs for spark. Pretty sure we did it right, but there was still no spark. We tried multiple times.
6. Scan car, get code P01314 twice (ECM error).
7. Try to clear codes, says Comm error.
Why am I not getting spark? and why is the ECU error occurring, because we tested with a new ecu, and there was still no start, not even for a second like there should be.
Golf IV / Jetta IV :: 2.0L Cranks But Doesn't Start
I've got a Mk4 Golf 2.0L with 136k on the clock. Hasn't really given me any problems in the past year of ownership till now. I recently picked her up from the shop for a rear axle beam replacement. When I picked her up she drove fine. I headed to class for the day and she sat in a parking lot for 6 hours or so. I hop in and try to fire her up and nothing. Had to have her towed back to my apartments. I've checked fuses, spark plugs were recently replaced but I am getting no spark. When I crank it I do hear the fuel pump and I can smell gas when I crank it. The rpms go up just a bit, 100-200 range. Going to check out the crankshaft sensor later on. maybe it could be the coil pack as well? I don't know a huge amount about these cars, only some info. And I sadly have no access to a scanner to check for codes.
View 2 RepliesGolf IV / Jetta IV :: 2001 VR6 GLX Cranks But Will Not Fire
To start I was driving home the other night, car just stalled out and would not start back up, at all. Just cranks over and over. Things I have checked
- I am getting a spark from the plugs
- Fuel pump primes when key is turned on
- Fuel comes out of lines, even more so when key is switched over so pressure should be ok, I have not checked exact pressure due to not having a gauge.
- I have checked all relays under the steering wheel (just visual) some had brownish on the connectors and I cleaned all that off.
- All fuses are good and not blown (voltage meter also showed power coming to a few key fuses I checked.
I am down to a few things that I have read could be possible causes
- Camshaft Position Sensor
- Crankshaft Position Sensor
- Not sure what else to really check
Golf IV / Jetta IV :: Engine Cranks Over But Does Not Start
So I bought a project golf vr6, but the head and some of the components were off, I have all the parts but I just cannot figure out why it is not wanting to start, it cranks over but does not start...
View 1 RepliesGolf IV / Jetta IV :: 2003 - Cranks But Won't Start
I am having a problem starting my VW Golf 2.0 since yesterday. When i turn on the ignition the car cranks up but does not start. I did a computer odb check and it gave me out some error codes.
here are a few things that i noticed sometime back:
While driving once or twice suddenly the car wasn't accelerating when i pressed the accelerator. This happened to me twice but then it was OK. Didn't have an issue again.
Sometimes the car gear doesn't shift gear i have to shutdown the car and start it again, then it shifts gear properly. I feel like the car is consuming a bit extra fuel. How I can fix this and what the issue is?
Golf IV / Jetta IV :: 2001 - No Spark When Engine Turned Over
2001 Jetta GL, 2.0L, 170k miles.... It won't start and it's not likely the fuel pump. After the car has sat for a while, I hear the fuel pump spin up when I open the door. It turns over just fine. I pulled a spark plug, attached it back to the wire, held it close to the head, and when the engine turned over, no spark. Is that still a valid test for spark? I haven't had to diagnose a spark issue for so many years, I don't know whether that has changed.
View 18 RepliesGolf IV / Jetta IV :: Cranks Up Fine But Sputters To A Start
My 03 GTI 1.8 is having start issues. It cranks up fine, but it sputters to a start. It doesn't idle high and fall down to the 850 mark like normal, it just lugs itself into low idle. I have to then throttle it until it stops sputtering and I have a smooth rev. Then after that, the car runs fine. I can stop it and start it up again fine when it's warmed up. I have checked multiple things already.
-The Ignition coils are in excellent condition
-Spark plugs are normal, but not exactly perfect
-Fuel pump works fine
-Battery was tested and is clean and good
-Throttle Body is clean (at least to the eye, Im cleaning it next)
-Oil was changed when I changed the sensor along with filter.
I should mention I changed the crankshaft position sensor a month ago. The block at least from under the car is filthy, but I don't know if that affects anything.
I had a check engine light, so I got its codes read (I'm out rn, but when I get home I can show you) and decided to just take it to a shop. When I took it, the light went away, decided to start as normal, and the shop just charged a huge fee for the diagnostic and nothing was fixed. I really need to know what to do with this, I daily it every day and its starting to bother me a lot now.
Golf IV / Jetta IV :: Stalled While Driving, Restarts After Many Cranks Later With EPC On
Its done this twice to me, once last week, once this morning. Drive a short distance after cold startup and it dies. Cranks strong but doesn't turn over. I waited a few minutes (took longer today than last week) and it restarts with a larger than normal puff of smoke, perhaps due to the multiple cranks, and the epc light comes on. Last week, I finished my errands with it on, it even went off after a restart. Today I didn't bother driving it because I was late for work. 137,xxx miles
Fuel pump and filter were replaced recently, relay was not because I could hear it and a new one didn't fix my fuel pump issue. One day I didn't hear the pump prime so naturally it didn't start but after opening and closing the door and waiting some time, it did prime and start.
Golf IV / Jetta IV :: 2000 - Blinking CEL / Misfire / Oil On Spark Plug
2000 Jetta AEG ... An intermittent CEL light turned into a blinking CEL after a few months. Checked codes and it threw a P0303 (misfire on Cyl 3).
Pulled the plugs and found this:
There was oil dripping off of the plug from Cyl 3.
I last changed the plugs in July 2014 and only drove around 10k miles this past year.
When I changed them back then though Cly 3 looked like this:
Before I changed them back then I had an oil cooler gasket fail on the freeway and oil shot everywhere under my hood. Obviously oil is in there and it is causing problems.
I have read online and most of what I have read says that it's likely an issue with the VCG (Valve Cover Gasket) or the PCV (Pressure Control Valve) that is allowing oil to get to that part of the spark plug tube. I've also seen some non VW stuff talking about replacing the spark plug tubes.
Also it does appear that there is a little bit of oil around the threads of the other plugs but nothing getting to the all the way to the tip around the electrode.
I have pulled the plugs, wires and the ignition coil as well ... I'm ready for whatever. I am by no means a mechanic but I am capable of following instructions and doing what is needed. My problem is generally finding out what is needed to be fixed.
Golf IV / Jetta IV :: For Valve Cover Replacement Spark Plug Should Be Taken Off?
In order to replace the valve cover do the spark plugs have to be taken off ?
View 12 RepliesGolf IV / Jetta IV :: Just Did Spark Plugs Now Check Engine Light On
I just did the plugs and now the check engine light is on?
View 6 RepliesGolf IV / Jetta IV :: On Every 4th Or 5th Start It Cranks And Then Finally Starts / Sometimes Stalls
Recently my 01 Jetta 1.8T has started to not start like it should. Say every 4th or 5th start it cranks and cranks, I see the tach eventually flick a couple of times and then it finally fires up. It's also stalled while I'm driving, say when I stop at a light but will usually start up again ok.
After the not so good start I get the impression the car is kind of surging while driving - like a fuel supply issue although maybe the fuel pump has nothing to do with supply after starting?
So anyway my thought is perhaps fuel pump issue? I decided to try and search for my issue or fuel pump issues but it talks about things that happen when you open the drivers door which in my case isn't working properly (i.e., I believe it is a DLM as my windows sometimes all go down and I don't get any chime or door light when the door opens).
So just wondering if based on what I'm experiencing if fuel pump sounds likely and perhaps what further tests I should run. My battery is new and the engine does crank pretty good if that eliminate it. I guess I should be thinking fuel filter perhaps also.
Golf IV / Jetta IV :: Engine Cranks But Doesn't Start - Code P0322
My 01 Jetta 2.0 started having issues a few days ago. The engine would crank, but wouldn't start. Wait a few minutes and it would start right up. I go to start it the next day and it would crank, but not start at all. I pulled the P0322 code and replaced the crankshaft sensor along with a new fuel pump, and spark plugs just to be safe.
Next, I checked for fuel and spark, which I have both. The car still won't start and seems to lose a charge on the battery pretty quick. At this point, there are no codes showing up. Could the engine be flooded from trying to start it so much?
Golf IV / Jetta IV :: Pump Won't Prime After Cleaning MAF Sensor / Car Cranks But Not Starting
I'm having a situation here. Yesterday I decided to clean the MAF in my 01 VW Jetta 2.0, so without disconnecting the battery I unplugged and took the MAF sensor out and sprayed it using "CRC MAF sensor cleaner", let it dry for about 30 to 40 minutes and then re installed it. When I tried to start the car, I opened the ignition (ON position) and didn't hear the pump priming, still tried to start the car, it when on for about 2 seconds at rough-800rpm idle then rpms dropped and car stopped running. Then, I tried to started it again a couple of times more and I still don't hear the fuel pump priming and the car will crank but not start.
Did I ruin/blew the fuel pump or something in the system? I don't understand what could have possibly gone wrong. I already tried searching for it but did't find the exact same situation and though details might be important.
Golf IV / Jetta IV :: 2005 1.8t AWP Cranks But No Start - Cannot Hear Fuel Pump Priming
2005 1.8t gti wont start. The other day I was driving on the highway when a thin plastic type wrapping got caught in my serpentine belt. The car immediately died and I hit the gas and nothing and with no power steering i pulled over to the side.
Timing belt was done with water pump and tensioners
Spark plugs and coils are brand new
What fuel line to disconnect to test if the fuel pump works? Like I said in the title I cant hear the fuel pump priming. The engine was running 100% before this 2 techs saw it and the vw dealer i workrd at looked it over.
Golf IV / Jetta IV :: 2005 - Starts Really Hard / Takes Couple Of Cranks To Start?
So I have a 2005 GTI 1.8t and I just recently had a new fuel filter/fuel pump installed.. Now ever morning when I go to start it it starts really hard.. once it's starts it runs fine it just takes me a couple cranks to get it started....
View 6 Replies