GTI 337/20th Anniversary :: Exhaust Rattling Against The Heat Shield
I have a 42 DD tb exhaust. And so far I've used a 3" exhaust clamp over the last hanger (after the muffler) which raised the exhaust all the way up against the heatshield, eliminating the rattle over the rear axle beam. But the exhaust was rattling against the heatshield.
So I bought 15 ft of exhaust wrap and wrapped the section that comes in contact with the heatshield. It worked a bit but it still rattles a little! I hate this rattling! How to get rid of the rattling? Should I just use more exhaust wrap?
GTI 337/20th Anniversary :: Rattle That Sounds Like A Shield In Low Revs
On my gti when in low revs, theres a rattle that sounds like a shield but I've check the one around that cat and the one under the turbo. but it still rattles. What this could be?
View 3 RepliesGolf IV R32 :: Catalytic Converter - Heat Shield Rattle
The catalytic converter shield is tack welded on the front end but free on the rear end. There was originally some braided wire packing at the rear to keep the shield from rattling against the pipes. Mine was deteriorated and had been damaged, I think, when I sustained some oil pan damage last summer -- big jolt to the system when running over a muffler on the highway.
The fix is simple. Bought a foot of 3/16" braided stainless steel cable. I used about 8 inches and layed in the lower bead line on the catalytic converter shield (see picture below). You can see a bit of the cable thru the gap in the upper/lower shield on the left side. (1/4" cable would be a better fit, but this will work for a long time.) Cost: $1.84
The local VW parts man dug out an exploded drawing of the system but it showed NO parts or packing for this problem.
Golf IV R32 :: Heat Shield Rattle Noise In 4th Gear
I am very mechanically inclined and up until now I can usually hear a noise and know exactly what the problem is, given enough time to listen..
The best I can describe the noise I am hearing, sounds like a cross between heat shield rattle or a syncro somehow stretched out and is loosely spinning around once in gear.. Hard to explain, but all gears shift perfectly..clutch was replaced at 102K and I am currently at 130K. Also I might be crazy but it sounds like I am starting to hear the noise in 3rd as well. I would post a sound clip, but its so faint it doesn't show up on my iphone..
The reason I am throwing it out there, is because half of the seriously trusted mechanics I know say it sounds like a bearing in the tranny going out, the other half, (3 of 6) can't even hear what I am talking about but its there.
GTI 337/20th Anniversary :: Rattle Coming From The Button On Hand Brake
I've got an AE edition GTI which has developed a very annoying rattle coming from the button on the hand brake. I'm trying to disassemble it to get to the chrome covered button which is rattling, but can't seem to get the leather wrapped plastic cover off. I've already pulled the center console out and have tried squeezing, pulling, etc every which way (on the leather wrapped cover).
View 12 RepliesGTI 337/20th Anniversary :: Rattle Coming From Front Right Side Of Hood?
The front of the hood on the right towards the headlight is rattling pretty bad, but stops whenever I place pressure on the hood on the right side. The hoods shut all the way so I'm not sure whatsup. Not a big deal just pretty annoying.
View 1 RepliesLexus GX 2004-09 :: Loose Heat Shield Like Rattle When Hitting Bumps
Hearing a loose heat shield like rattle when hitting bumps...checked everything underneath , can't find anything loose..? 09 GX-470 56K miles
View 11 RepliesPassat (B5) :: Loose Heat Shield / Minor Rattle Occurring At 1200 - 1400 Rpm
I have a 2001 Passat GLS 1.8T Tip 34500 miles... Loose heat shields. Well, I couldn't find anything to fix, so I brought it to the dealer. They said that this was common on 2001 Passats with about 30k miles. All stock.
These were the symptoms that the car was exhibiting: At first it was a minor rattle that occurred at 1200-1400 rpm.......only when the engine was warm, and only when I was in drive. (I could not reproduce it in neutral)...
A few weeks later, it the engine rattled upon startup for half a second. I assumed that this was just the heat shield issue getting worse. Dealer says that I have a bad cam tensioner, and that they will replace it under warranty. However, I had to reschedule the repair for this week because they couldn't fit the 5 hour job in on Saturday.
He said that there is a spring backup for the hydraulic tensioner, but to get it fixed soon. Obviously I was going to have it fixed ASAP. What this cam tensioner does? Isn't there a chain that connects timing belt to cam shaft? Why does this need a tensioner? Does it change in tension?
GTI 337/20th Anniversary :: Annoying Dash Noise While Driving Over Rough Surfaces
I am after a annoying dash noise that I get when driving over any rough surfaces. I have removed all centre console and glove box and everything else around that area and I still have the noise, its like the dash is loose some where else, I have looked around for a complete dash removal instruction thread, but can not find anything??
It looks like I will have to remove the whole dash but really could do with some instructions on how to do this as I don't want to break anything!
Ford F-150 (2009-2014) :: Rattle Under Slow Movement / Sounds Like A Heat Shield Shaking
I have a 2010 F150 FX4 with the 5.4L, and lately under slow movement (less that 20km/h it is sounding like there is a rattle. I can try to get a video of the sound later, now I'm wondering if the universal bearings in the driveshaft would be making this noise or if it could be the 4wd actuators failing? Would either of these make a loud rattle? (Sounds like a heat shield shaking but all are tight). Had a Ranger up until last year so just learning the ins and outs of F150 life.
View 5 RepliesGolf IV / Jetta IV :: Exhaust Heat Shield - Slight Creaking Noise That Sounds Similar To The Rattle
I've noticed that potentially my heat shield or whatever guard that is 1 step toward the front of the car from where the inlet pipe connects to the exhaust system may be the reason for my rattle at 2k and 3k rpms. i think its a heat shield but I am not sure. the thing is it seems properly mounted, nothing is cracked/broken/or loose. But when I do try and wiggle it it does make a slight creaking noise that sounds similar to the rattle I get. So I could foresee this as being my issue.
But, is there anyway to fix this rattle w/out just taking off the part? i figure its there for a reason and it looks like its held on in 2 places. But they're not nuts they almost look like spot welds or something. 1 on each side. What to do?
Something to get you all in here:
Ford Super Duty (1999-2016) :: 2003 F250 V10 - Heat Shield Rattle That Sounds Like Exhaust Leak During Loaded Acceleration
I recently purchased this truck and have towed a couple of times with it. It has 98,000 miles and I do not know if the automatic transmission fluid has been changed. Should I have it flushed or drop the pan and change it? I have a lift so doing the change is no problem, although it might be worth it to pay a transmission shop to do it.
Also, I hear what appears to be like a heat shield rattle or something that sounds kinda like an exhaust leak during loaded acceleration. What to look for to locate the noise? One last question, the air bag light is on sometimes then off sometimes. Any known air bag light issues? I love the truck, hate the gas mileage!
Golf/GTI VI :: 2011 - Heat Shield Rattling Sound Coming From The Underside
So, I have discovered my first rattle in my GTI (8500 miles). Seems to be from the underside, sounds like a heat shield rattling, certainly sounds metallic. Did some spirited driving yesterday and hear the rattle today. Any target areas to check when I take a look under it?
View 6 RepliesGTI 337/20th Anniversary :: Heat / AC Lighting Went Out?
I was driving the other night and I went to turn on my AC and the lights lighting up the controls to the AC/heat went out...
View 4 RepliesGTI 337/20th Anniversary :: Heat Not Working While Topping And Start Up?
The heat in my newly purchased GTI 20th AE doesn't seem to be functioning as well as my previous 2005 gti. The heat only seems to really work when I'm driving around with the engine turning atleast 2500 rpms. If I start the car up in the morning, the heat gets slightly warm, but nothing like it should. If I'm driving around town and come to a stop at a light, I can feel the heat cool down. The engine temp is perfect though. Stays at a consistant 190 degrees. I did a search and found a few relating complaints, but for different cars. Is there a valve on one of the heater hoses to the heater core that might not be functioning properly? blocked heater core?
View 6 RepliesGTI 337/20th Anniversary :: Rattle Noise Going Into 1st And Low RPM In 2nd Gear?
Sounds like maybe from exhaust, I could be wrong but what that is? Just started today...
View 10 RepliesGTI 337/20th Anniversary :: Downpipe Installed / Car Started Rattle
I just installed a brand new 42DD downpipe in my car about two weeks back. About a week later, I started noticing a rattle that I hadn't heard before, coming from the undercarriage, about mid way back, where I assumed the downpipe is. I only hear the rattle at low RPMs, like 1000-1500 revs, when I pull away from a light. I can stop the rattle by giving it more gas before letting the clutch all the way out, but if it's something I can easily fix myself, I'd rather just do it.
I searched some DIYs and found this. [URL]..................................... I bought new sets of stage 1 dogbone mounts that I need to put in soon, probably next week when I'm on break, if that will remedy it.
GTI 337/20th Anniversary :: Passenger Side Rattle During Acceleration?
Did some searching on this and some said it could be the throw out bearing, some sort of intake rod or something like that, or possibly a heat shield..
Figured I'd ask to see if there has been more of a solution as the threads seemed pretty old.
When I accelerate or rev, the car has a rattling sound coming from the passenger side. If i take the car out of gear and slow down or let it idle, the noise disappears completely.
GTI 337/20th Anniversary :: Center Of Steering Wheel Rattle
The center of my steering wheel rattles (part that you press for your horn) is there any way to tighten this?
View 4 Replies