Ford Transmission :: 1986 - Possible Gear Swap 4.10?
My 1986 F150 in my signature has new 33" tires, up from the old 31" tires, and the even older 28" or whatever the stock size was. Needless to say, it feels pretty sluggish lately. First, I want to change the gears to get the engine back into a favorable RPM area while cruising. I used a calc and figured 4.10 gears would get me back to where it was with the 3.55 gears and stock tires.
There are several different spline counts and carriers and all that stuff. I need selecting replacement gears that will work, and first off, knowing if my carrier will even accept them. It has the stock Dana 44 front and 8.8 open rear...
Ford Transmission :: 5R100 ZF6 Swap Into 2005 F250 5.4L?
The other day I drove a 02 f150 with a 5 speed into the shop i work at, ever since all i can think about is putting a zf6 into my auto f250. its a gas 5.4 reg cab. I know I am gonna need...
zf6 tranny
bell housing
manual dog house
master and slave cylinders
clutches and what not
clutch pedal
Ford Transmission :: Rear Axle Swap - Slow Acceleration
Lets say I want to do rear axle swap, how I would go about this? Would I have to do anything to my tranny or transfer case? and all in all would it be worth it if I am looking for more speed out of my 460? the fastest I can go for an extended period of time is about 55 if i go above that for to longit wears on the gears and overheats the rear end. It has slow acceleration, and I am sure the low slow gears put out a lot of power, but they drink gas. And even though I am good at driving stick, its hard to take off because there's only about two inches of clutch travel that i have to take off, its not the clutch, its the gears.
View 1 RepliesFord Transmission :: 1979 F150 - 4 To 5 Speed Trans Swap?
I am looking to change out my manual transmission in my 79 f150. I want to put a 5 speed in it but still keep my manual clutch. I have a 300 engine that I also want to keep, can I just put a late 80's early 90's 5 speed transmission in it and keep my original bell housing?
View 5 RepliesFord Transmission :: 1992 F150 2WD - E4OD To 4R70W Swap
Situation is I have a 92 F150 2WD donor truck. 5.8l will be going into my 80 F150 4X4. E4OD transmission is long gone, but I do have a 4R70W from a 96 Explorer. Bolting it together is no problem, but there are differences in the transmission controls. E4OD uses a coast clutch, 4R70W does not. EPC, shift solenoids and TCC are compatible. I do not want to use a 5.0l PCM or add external controllers like the Baumannator.
Question is, can I control the 4R70W with the PCM that comes with the 5.8l?
I'm thinking I can ignore the coast clutch output, maybe tie it to +12 through a resistor if that makes the PCM happy. Baumann's controller appears to work with E4OD's as well as 4R70w's doing exactly this. Baumannator TCS Electronic Transmission Wiring Details....
Ford Ranger / B-Series :: Transmission Swap From 1996 To 2000?
Will the transmission from a 2000 fit a 96? They're both 3.0's.
View 3 RepliesFord Super Duty (1999-2016) :: Transmission Swap Of V10 To 7.3L Powerstroke?
Can I take the tranny out of a v10 and put it in my 7.3L Powerstroke?
Both are 1999 f250's.
From what I've read they should both be 4r100's.
Ford 7.3L Power Stroke (1999-2003) :: F250 - Transmission Swap?
I recently bought a 1999 F250 Super Duty 4x4 7.3 Powerstroke MT with 280,000 miles. The reverse is out and after reading several posts am I to understand that any ZF6 well interchange in it or is it year specific. Guess what my question should read "What year vehicles well the transmission interchange and that there isn't any difference between trucks that run this motor with MT except for the powertrain, like F250 F250 super duty F350 and so on. The second question is how hard would it be to fix the reverse myself. I do have some mechanical experience. Except for the reverse, the trucks run perfectly.
This is my first diesel truck . I'm also confused because it has an adjustable gauge mounted on the bottom of the dash that you can select the performance from. I was told it has a performance chip and that's what that was for. I was told by the man I bought it from that the truck had been bullet proof but I don't know a thing about diesel upgrades or what to look for if it has. Except for reverse, everything works. Low high 2x4 & 4x4. Got it because he had to pay the bail bonds man. Guess I got a deal on it I was told.
Ford Super Duty (1999-2016) :: ZF650 6 Speed Transmission Swap?
I own a 1999 F250 sd 5 speed manual, v10. Looking for some specific details pertaining to swapping to a ZF650 6 speed transmission. Any prior example with this swap?
View 8 RepliesFord Super Duty (1999-2016) :: 2003 6.0L - Transmission Swap / Gear Ratios Are Slightly Different
Will an 05-07 5r110w transmission work in a 2003 truck? Some sites show same part number for each and some show different part numbers. I know the gear ratios are slightly different and that there is some other internal changes made to the 5r110w.
View 2 RepliesFord Super Duty (1999-2016) :: Automatic Transmission Swap 2000 F250 To 2003 Model?
I have a 2003 f250 4x4 with a 5.4 motor the automatic trans is shot. I can get a replacement trans from 2000 f250 4x4 with the v10 motor. I tried my best to research it bell housing supposed to be the same so it should fit. But I'm not sure what they changed in those years internally or electronically.
View 2 RepliesRegal :: Engine And Transmission Swap - 3.8L 98 To 01?
I want to do an engine swap 98 regal to 01 regal. Both are series 2 3.8L. Should the engine and tranny swap without a huge problem?
View 2 RepliesCamry :: Auto To Manual Transmission Swap Possible?
Just curious. is it possible to convert my auto camry to manual transmission? also, how much would it be? where can i go?
View 5 RepliesCorolla / Matrix 2009-13 :: How To Swap In 5 Speed Automatic Transmission From Xrs To 1.8
I want to know if its possible to swap in the 5 speed automatic transmission from the corolla xrs to the 1.8 trying to get that extra gear and sequential shift mode , or how it could be done a 4speed to 5 speed manual swap?
View 1 RepliesGolf IV / Jetta IV :: Clutch Pedal Is Rock Solid Hard After Transmission Swap
2004 Jetta 1.8 bought mainly as a parts car w /204K miles on it. Ran and drove fine, but the tranny had no 1st gear. Tried all sorts of things other than going inside the transmission and figured it is/was a bent shift fork. Clutch worked perfectly. Had another 02J tranny from 2003 1.8, so we swapped trannys. Could not get any response from the clutch.
Start the car in neutral and it won't disengage enough to shift into gear. Start it in gear with clutch pedal in and it is obviously slipping/burning/chattering. Have bled the slave cylinder to no end, have reverse pressurized it into the reservoir , etc, etc. Made up a block off plate to go over the end of the slave actuator and when the actuator is "blocked" from moving the clutch pedal is rock solid hard. Yet, the clutch acts as if the actuator isn't extending far enough. Have swapped out the original slave cylinder with the one from the '03, no change.
Removed tranny yesterday to check the condition of the throw out bearing and pivot and Pressure plate. All appeared fine. Reinstalled tranny and same issue.
Ford Excursion :: Trans Swap 7.3 To 6.0?
I am in the middle of the 7.3 to 6.0 swap and wanted to confirm the in and out lines of each cooler. All the links to the websites that were writeups seem to be dead.
View 3 RepliesFord Excursion :: Steering Wheel Swap
I am looking to swap the worn steering wheel in my Excursion. I would like a wood and leather like the Navigators have. Any tips on doing the swap?
View 14 RepliesFord F-150 - 1997-2003 :: Possible To Swap Cab To A 4 Door?
My names brad. I have the old model 97 . Is it possible to swap the cab to a 4 door. Its got a 8ft bed
View 1 RepliesFord Excursion :: 2004 - Seat Swap In 2nd Row
I'm thinking about swapping from captains chairs to bench seats in the 2nd row of my 04 Limited Ex with tan leather. I'd like to mount an amp or 2 under it.
View 10 Replies