Ford Transmission :: 1979 F150 - 4 To 5 Speed Trans Swap?
I am looking to change out my manual transmission in my 79 f150. I want to put a 5 speed in it but still keep my manual clutch. I have a 300 engine that I also want to keep, can I just put a late 80's early 90's 5 speed transmission in it and keep my original bell housing?
View 5 RepliesF Series :: Oil Pan Gasket On 97 F150 With 4.6L And 4R70W
What does it take to pull the oil pan on a '97 F150 w/ 4.6L and 4R70W? I checked into Auto Zone's repair support and it states to just unbolt it from the block and remove it. I looked under the truck and it doesn't appear that there is sufficient clearance to remove the pan without raising the engine/trans.
View 2 RepliesFord Wiring/Electrical :: 1993 F150 - E4OD Stalls Engine And Kills Power To Fuel Pump?
OK, this one has me stumped...I have a 93 F150, 302 with the E4OD. I know the transmission needs to be rebuilt (probably a bad pump). When I put it in reverse, the engine will start to bog down and will die unless I put it back into park or neutral.
If the engine does die, the fuel pump does not prime with the key "on" and the engine obviously will not start. If I let the truck sit for about an hour, the fuel pump primes like it should and the engine starts right up. The fuel pump shut-off does not trip and all fuses are good.
Ford Transmission :: E4od Transmission Slipping - MLPS?
My tranny slips in drive and od when it is warmed up.It's fine for a few miles when it is cold.Did a quick search and it seems like it might be a bad mlps.
My question is, Will a bad mlps act up all the time or just when it's warmed up? Will a mlps and connector from a 91 tranny work on a 95 tranny? Don't really want to throw money at it if it will need a rebuild.
Ford Transmission :: 4R70W - No First To Second Gear Shift
Working on a 2004 E-250 van. [URL] ....
I went through this transmission completely, its back in the van and I get no 1-2 shift.
when I first put it together, I missed the hole in the flex plate for the torque converter stud and started tightening the bell housing bolts down, I heard loud "POP" and realized what I had done. maybe I damaged the pump?
forward and reverse engagement is firm, both give a nice bump when it goes in gear. This tells me the forward clutch is working, but the intermediate clutch is not applying to make second gear happen.
I have done all the easy stuff I can think of, replaced the shift solenoid and put in a new 1-2 accumulator piston. I guess i need to air check the intermediate clutch piston again and make sure its applying. this a 2004 model trans, so it has the new style pump and intermediate piston.
Ford Transmission :: 4r70w Only Reverse Works
98 ford expedition 4.6 2wd, 4r70w only reverse works. Here's the low down on what happen.
First off the truck overheated a little then was cooled off and coolant added. about a week later it wouldn't go forward so i told my wife to check the tranny fluid it was low barely on the dipstick, fluid was added and she was on her way. this past weekend the truck sherd all 5 lugnuts on the driver rear wheel. fixed that but went to drive it away and the tranny was slipping a little. added 2 quarts to fill and on the way again. 3 days later went to drive it to my dads shop to find out where the fluid is going, its slips again, added 2 quarts to fill just to drive 6 miles.
It drives fine until i get to my destination we have to stop to open a gate, i put in neutral to roll back to open the gate and no forward gears, only revers. i drive backwards to the shop about 300' and the tranny is empty again. looks like the fluid is going into the radiator which i'm sure caused the overheating a couple weeks back. no water is getting into the tranny. I've changed the filter and fluid and radiator, but still no forward gears only reverse. could there be an easy fix, electrical part maybe or mechanical or do you think its trashed and need replacing.
Ford Transmission :: 4r70w - Truck Tries To Shift Into 4th Gear
I have a 2005 ford expedition with 91000 miles, it has the 5.4 w/ the 4r70w transmission.
For some reason when my truck tries to shift into 4th gear, the RPM's climb to approx. 3000 rpms (meanwhile the truck is not gaining speed) and slowly drops down to about 1000-1500. once the rpms drop down fourth gear eventually engages and I can go about my business as normal as long as I do not let my mph drop too low.
If I turn O/D off, the truck drives perfect, minus not having overdrive.
If I come to a dead stop and put the truck in 2nd gear, with O/D on the truck drives great and it has good engine braking so I am assuming that the band is holding.
I took it to a transmission shop to have some diagnostic checks done, they told me that fourth gear was barely engaging and that they would have to tear apart the transmission to diagnose it further, I told them not to disassemble the transmission.
So I changed out the torque converter (which I assumed was "fourth gear") and changed out all the fluid, the fluid looked a little burnt but there was no debris in the pan but there was some silver material on the tranny pan magnet, and installed a new filter. and the problem still exists.
Ford Transmission :: Stuck In Middle Of 4R70w Tear Down
I've been making steady progress tearing down the transmission from my 2002 E-150 but have reached a point that I can't continue. The ATSG AODE manual says to "Rotate the shell assembly to align indent with overdrive anchor pin and then Remove forward sun gear." This is the step right after removing the intermediate stub shaft.
Well, the stub shaft came right out but the shell will not rotate, move, or do anything. It certainly cannot be removed. How to get this out?
Background: The trans is being worked on due to a failure that prevented it from being driven and it actually stalled the engine when shifted into any forward gear. It would idle in park or neutral. It would also still allow the engine to run in reverse but the van would still not move. I was able to push it into the garage in neutral.
Ford Transmission :: 4r70w - No Forward Gears Only Reverse
I have a 98 expedition with a 4.2 liter 4x4 and what I believe to be a 4r70w transmission (u code on the door sticker)
The original transmission went at 105k miles and was replaced with a new factory ford transmission by a ford dealer 3.5 years ago. The new transmission only has 10k miles on it.
Now the new transmission only has reverse. reverse works like normal but no forward gears. the idle will change when i put if in gear, but will not move, acts like it is in N . There is no strange noises.
It's hard to believe a new trany is shot already, no towing, or off road use.
My question is : is there ANYTHING that can go bad that would cause this? The trany fluid is clean and clear bright red, and no burnt smell.
I want to check everything I can before calling a tow truck to have it looked at. I will have it repaired if needed, but I don't think I want to replace another tranny.
Ford Transmission :: 4r70w - 4th Gear Shudder While Decelerating?
I just put a rebuilt 4r70w in my '97 expedition and it shifts good but in 4th gear when I let off of the accelerator it starts to shudder until it shifts to 3rd. It acts like it is freewheeling then catches on and off. My thoughts so far is that I don't have the digital transmission range sensor positioned right or the overdrive servo isn't working properly.
View 1 RepliesFord Ranger / B-Series :: Door Swap From 1992 To 1993 Model
Will a driver door from a 92 ford ranger fit a 93 ford ranger?
View 5 RepliesFord Transmission :: 4R70W Trans Stuck In Forward Gears
I have a 1997 Mercury Mountaineer with a 4R70W trans behind a 5.0 liter. Vehicle sat for about 5 months. Went out to put it back on the road, and now the trans seems to be stuck in a forward gear no matter what the selector is in, park, reverse, neutral. Dropped the pan and replaced the filter and replaced what fluid was drained. no difference,.
View 3 RepliesFord Transmission :: 4r70w - Stop Immediately When Take Foot Off The Gas While Going Reverse
I have a 2007 e-150 ford van with only 38,000 miles on it, with i believe a 4r70w transmission. The problem started yesterday. Going in reverse, it would go, but as soon as you take the foot of the gas, it would stop immediately, plus very difficult until it would start rolling, I think this is called engine breaking. Also, in Park, revving the engine, the trans makes a very strange noise, and wants to creep up (move forward) with more gas you give it. neutral does the same thing. When i drive the van, it seems like it switches gears fine, and does not make any noise, but the OD light does not show when you press the button. I did check the fluid, nice and red/pink color no smell at all. No leaks under the car, and the trans is totally dry all around. I do not show a check engine light on. This morning my friend came over with his scanner and hooked it up to my van's plug. It showed no codes of anything wrong. What might be wrong with the trans? My friend seems to think it might be a solenoid problem, I sort of think it might be a shifting problem, but i am no mechanic.
View 14 RepliesFord Transmission :: 4r70w Malfunction On The Dash And OD Light Flashes
Its a 2004 f 150 5.4 2 wd auto, I think is a 4r70w, when I first start out in the morning I get a trans malfunction on the dash and the od light flashes, if I shut the truck off and restart it goes away for the rest of the day, when it does this the speedometer doesn't work right, vss?
View 2 RepliesFord Transmission :: E4OD Shudder On Take Off
My 95 psd recently started shuddering on takeoff... Pretty sure its the torque converter. It has a full ATS tranny with 5 star t/c and all the goodies installed by the previous owner (warranty not transferable). Its only got about 25k on the trans but they have been far from easy miles.
Symptoms: If I hold the brake and keep the truck stopped while holding the throttle its totally smooth, not until the truck starts moving that the shudder begins. It shudders worse the more power i put to it. Does it in first gear and second gear takeoffs. Goes away at about 10 mph or once the speed catches up with the rpm.
Ford Transmission :: Flashing O/D Light Come On For About A Minute - Leaky Harness On 4R70W
Yesterday I had a flashing O/D light come on for about a minute, a quick scan shows a P1747 code indicating a short in the EPC solenoid circuit. Poked around the harness this morning and found this:
I'm guessing transmission fluid shouldn't be there. Do I have to replace the whole internal transmission harness to solve this? How much of a job is that?
Ford F-150 - 1997-2003 :: 2001 5.4L With 4R70W Transmission Won't Engage Any Gear
The problem started with a front seal leak a few months ago which I had no choice but to continue driving with because of low funds. I don't drive much so a couple of quarts of ATF was usually enough to get me out and about for what little driving I had to do. I know.. a front seal is cheap, but I'm partially disabled and unable to work on anything that is not under the hood.
I finally scraped up enough money to hire a friend to replace the seal, but he had a life crisis before completing the work, so I had to get another friend to reinstall the trany... still had the leak, but I could get around by adding ATF as before.
So we tried again... dropped everything and put another new seal on. This stopped the leak, but we got some grinding/squealing noises and could not get the trany to engage any gear.
From reading forum posts and other sources, we decided to replace the TC which we just completed this evening. We got some more of the grinding / squealing noise like before, except that it only occurred the first time we tried cranking the engine, the 2nd time we got no noises, but again no gears engaging.
What to check/replace next assuming there is something we can look at other than a total trany rebuild or replacement. I personally find it hard to believe we could have gone from a tolerably functional trany to scrap metal just replacing a seal and the TC. Its gotta be something simple we overlooked !!
Ford Transmission :: 4R70W Tranny Making Shuddering Sound While Downshifting?
I have a 2002 F150 Super crew with a 5.4 and a 4R70W tranny. The issue I am experiencing is when the truck is driven where the tranny has shifted through all it's gears and cruising at say 55 mph, when depressing the accelerator pedal it either downshifts of something unlocks making a shuddering sound which sounds like when you run over rumble strips on the side of the road. The shuddering only happens for maybe a second at the most. If I am on the accelerator pedal when it up shifts or locks back up it makes the shuddering sound again. The harder the unlocking / locking or downshifting / up shifting happens the harder and longer the shuddering is.
This shuddering happens at the very last transmission function which happens in the transmission during it's normal operation. Other tan this issue the tranny shifts and operates excellent.
Ford Transmission :: E4OD Is Slipping For A Few Seconds
I have an E350 1992 7.3l Diesel, with E40D. The transmission slips in the 3rd and OD position. Every time, if I want to accelerate it slips for a few seconds and then the drivetrain is correct connected. The shifting into another gear works properly, the transmissions slips by changing from free-wheeling into accelerating ( for example: at speed 90km/h and no changing the gear).
I have recognized that the oil temperature is getting higher now. That may an indication for additional losses in the transmission. What do I have to check?