Ford Super Duty (1999-2016) :: Getting Code P0741 - TC Isn't Seated Properly?
99 F350 7.3l with 4R100 trans. About a month ago I took out a monster trans that had about 60k on it and it was burnt up. No warranty. ..customer bought another monster. After the install when going into 4th the torque converter would instantly lock making it feel as though the truck was falling on its face. Monster had me do some data logging and from the info I provided they determined it had a bad solenoid pack. They sent a new one out...when I went to install the new pack I noticed when I dropped the pan that the fluid was iridescent looking...a bolt for the valve body was in the bottom of the pan and lots of material stuck to the magnets....
Needless to say that trans only lasted about 2 weeks after putting the solenoid pack in. Fast forward to today..got trans number 3 from monster under warranty. After the install everything seemed good. About 30 mins into highway driving the od light starts flashing. ..subsequently the P0741 code. I did put 2 new wire pigtails on the front and rear speed sensors. The pigtails were a ford service part but they were a bit different in design. I am pretty sure the wires are correctly oriented..if not would this cause the issue. I really am leaning towards a bad solenoid pack again. My buddy thinks the TC isn't seated properly....where do I start? Also has an edge programmer on it..but it's been on the same map all this time
Ford Super Duty (1999-2016) :: 2002 F350 - Blinking OD Light And Code P0741
My buddy has a 2002 F350 CC Longbed with a 7.3. Last night the overdrive light started blinking. He said he drove it today and it takes about a mile or so for the light to come on but then it is a steady blinking. Truck has about 254K miles on it. He said other than the blinking light everything seems normal. How to figure out what this issue may be?
I got AE hooked up on his rig.
When I pull (ALL) codes this is what I get:
When I pull (Current) codes I get this:
I tried to clear the code and the light stopped blinking, but he said it started blinking again on the way home.
Ford Super Duty (1999-2016) :: 2001 - Transmission Malfunction - Sluggish - Codes P0732 / P0720 / P0503?
My '01 7.3 is having some transmission problems, My O/D light is flashing. Trying to go after stopping at a light is a difficult, it drives very sluggish, like its not in overdrive. Scanned it and got three codes P0732, P0720, P0503. I replaced the ABS/VSS on the differential and the problem still exist.
View 1 RepliesFord Super Duty (1999-2016) :: 2008 - Overheating At Even 65 MPH?
Im running an 2008 F-450. And towing a goose neck trailer with the total weight of 12,000, including the car in tow. We were traveling from Cleveland to Columbus last week. Traveling south down Rt. 71. Which has some subtle gradient here and there. But nothing extreme. I haven't tried any mountain runs yet. when i started noticing the temp gauge climbing from middle normal range to high normal.
It would then kick out the cruise control. It would cool off after about 5 minutes of slower driving. We were only traveling at 65 mph. Outside temp was about 78 degrees. I shut off the A/C and it seemed to improve. Should it be over heating like this. The capacity of the 450 is 25,000. I am at half that right now. Are these truck prone to heating problems. And if so. Is there a high performance supplement cooling system.
Ford F-150 - 1997-2003 :: 1999 - 4WD 4.6L - O/D Light On Intermittently - Codes P0781 And P0743?
Ok, so the OD light sometimes blinked and sometimes not. I drive for a week. About 500-600 mi. Today the tranny starts acting up. Up until today NO probs at all. I bought a code scanner. Codes are P0781, and P0743. I also bought new filter and fluid while there. I read here that it could be a shift spring that is easily accessed when doing the filter change. I guess I should get that and do it,and the filter and see what happens next?
View 4 RepliesFord Super Duty (1999-2016) :: 2012 - Overheating But Only Under Acceleration
My Son drives a 2012 6.7, and just recently it started overheating bu only under acceleration? It runs cool while idling, and once you reach the desired speed, it cools back down, but under acceleration it overheats? We've checked the obvious (coolant etc...), but can't figure out what it would do this only under acceleration?
View 6 RepliesFord Super Duty (1999-2016) :: 2008 - Overheating Under Load
I have a 2008 powerstroke. Dpf and egr have been fully deleted. SCT tuner seems great and have had no issues since installed 6 months ago. I recently hooked up to my camper and headed up a mountain pass. As soon as I started uphill the engine overheated. I allowed it to cool and tried again with the same result. Eventually had to unhook and have another 6.4 (this one being a 2010) pull the trailer the rest of the way. Haven't had any heating issues since unhooking.
View 7 RepliesFord Super Duty (1999-2016) :: 2011 - After Oil Change Overheating?
I have an 11 F350 6.7. It has just under 200K miles on it. Yesterday I changed the oil. Very uneventful. Today however, I was driving home, about 100 miles, and my truck's temp spiked. Not like a little spike, but jumped to the 3/4 mark(if there was one) then slowly kept rising to to the overheat mark. I pulled off onto the hard shoulder waited an hour or so to let it cool down, then finished the drive home.
All the way home my temp gauge seemed like it was on some sort of drug. It would jump a needle width when I would have to accelerate, then slowly cool to normal after I got up to cruising speed.
When I got home I checked the oil level and it was spot on in the "normal" range. I haven't used a different type/brand/weight of oil in the last 100k miles. Did something just give out on my truck? I had the coolant flushed and replaced at the dealer within the last 10k miles.
Up until this point this truck has been exceedingly reliable. I pull a 13k 5th wheel once a month and drive about 40k-ish miles a year.
Ford Super Duty (1999-2016) :: F250 V10 Overheating After Running For A While
My 1999 f-250 superduty shows overheating after it runs for awhile but it doesn't actually overheat the gauge just shows it. What it does is drops down to four cylinders. Is my heads blown or could it be something else it has 260,000 on the engine.
View 2 RepliesFord Super Duty (1999-2016) :: Truck Was Steaming Antifreeze But Not Overheating
I have a 2001 F250 with the 5.4l. I got home today and a lot of steam was coming from under the hood. I couldn't see where it was coming from. I see a reflection on top of the engine near the intake manifold. The truck is not overheating and the heater is working great. I changed the thermostat several months ago. What the issue may be. I checked the dip stick and not visible signs of water in the oil. What this could be? Is there something besides the visible thermostat housing that may have blown a gasket?
View 1 RepliesFord Super Duty (1999-2016) :: Overheating Back And Forth And Blowing Cold Air
I have a 2000 f-350 that overheated 2 months ago I replaced the radiator...it seemed fine for a month then started blowing cold air then would start to overheat and back and forth so I replaced the thermosat.......but when i checked the old one with a cooking theromometer it was fine. not long after that the heater core started leaking so i replaced that..and now its back and forth overheating and blowing cold air....then fine for 1/2 hour..then back and forth again.. Truck has 250,000 miles on it
View 12 RepliesFord Super Duty (1999-2016) :: 2011 F350 Overheating After Oil Change
I have an 11 F350 6.7. It has just under 200K miles on it. Yesterday I changed the oil. Very uneventful. Today however, I was driving home, about 100 miles, and my truck's temp spiked. Not like a little spike, but jumped to the 3/4 mark(if there was one) then slowly kept rising to to the overheat mark. I pulled off onto the hard shoulder waited an hour or so to let it cool down, then finished the drive home. All the way home my temp gauge seemed like it was on some sort of drug. It would jump a needle width when I would have to accelerate, then slowly cool to normal after I got up to cruising speed.
When I got home I checked the oil level and it was spot on in the "normal" range. I haven't used a different type/brand/weight of oil in the last 100k miles. Did something just give out on my truck? I had the coolant flushed and replaced at the dealer within the last 10k miles. Up until this point this truck has been exceedingly reliable. I pull a 13k 5th wheel once a month and drive about 40k-ish miles a year.
Ford Super Duty (1999-2016) :: 2001 - Overheating When Towing Uphill?
I have a 2001 excursion 7.3 4x4 with the 6.0L trans cooler. It is over heating when heavy, uphill towing is under way. I am guessing that my computer has been reprogramed at some point and more fuel is being injected than the radiator is designed to cool. I know my trans cooler is clean. I have tried cleaning the radiator and intercooler with a garden hose. I am considering a hood scoop or some sort of vents in the hood. When it over heats I turn on the heater and open the hood and the engine temps drop in just a few minutes so I believe that the engine needs more cooling or I need to slow down a bit on hills. Any other cheap fixes to get more air in to cool things under the hood more?
View 1 RepliesFord Super Duty (1999-2016) :: F350 V10 - Trans Overheating At Low Speeds
I have a 1999 f350 v10 stock truck. It has plenty of power when it's cold out or raining or I'm on backrooms or highways but if I drive through town on a hot day the transmission kicks bad I have changed the fluid and filter, it also seems to shift at a high rpm from 2nd to 3rd. Unless I you let off quick and go back on kinda like engaging a 2 speed rear end. Does it need a bigger trans cooler or is the trans shot
View 4 RepliesFord Super Duty (1999-2016) :: 1997 F250 HD - Motor Keeps Overheating
I have a 1997 ford f250 HD with the 460 and auto trans lifted on 38s the motor keeps over heating Im not shear what the problem is I checked the water and thermostat water pump is good when I bout it there is a trace of stop leak in the radiator not shear if that can do any thing.
View 1 RepliesFord Super Duty (1999-2016) ::Getting CPS Codes?
I have a farmer with a 2001 F350 SuperDuty with a 7.3 broke down at his farm a few weeks ago. Asked me to come look at it. No start issue. I use the Matco Determinator in my shop, so I take it with me for starters,after running diagnostics I come up with p0340, p0344,& p1670. After googling these codes I make the determination idm is bad. Farmer agrees to let me try one, install a new BorgWarner unit from O'Reillys, and bam truck fires up. I reinstall inner liner clear codes and go about my way. Few days go by and farmer shows up again, truck run a few miles around farm,spits sputters, and dies again. Go run my checks and same thing. Farmer told me in nthe beginning he had CPS changed per the recall. I had idm replaced under warranty truck fires back up, so this time I drive it , and get bout 2 miles down road truck dies. Had to tow strap back to shop. Got a new cps from ford replaced truck fires up. Farmer takes truck drives for bout a week guess what truck gets towed back. 3 codes are back, along with a few others related to low voltage. This time I replaced idm for a 3rd time, truck fires up. Today I let it idle for 3 hours in lot, decided t test drive, got less than a mile down road, truck shudders chi engine light comes on and it wants to die but keeps running. I am able to get turned around but it dies before I can get back home. Run codes and get same 3.
View 1 RepliesCavalier - Chevrolet :: Transmission Slipping In Cold Weather / CEL Codes P0741 And P2761
I have a 2005 Cavalier (60,000 miles) that's been having some transmission slipping in the cold weather. As the weather has warmed up, the issue has lessened but not quite gone away. We added a little transmission fluid, but I haven't yet had a chance to replace the fluid/filter. The check engine light has been on in my car since I've owned it... the shop I bought it from replaced the solenoid, but the code still hung around. Everything I've googled tells me that the issue could be the wiring or could be the solenoid needing replacing. My real question is... how soon do I need to act on this? p0741 p2761
View 4 RepliesFord Super Duty (1999-2016) :: 2008 - Losing Coolant - Overheating On Interstate?
I have a 2008 6.4 f-250. It has 139,00 Miles and I have a problem with the truck losing coolant and overheating on the interstate. When cruising 75-80 my truck will sometimes begin to puke coolant from the degas bottle and my cooling fan will begin to run. Engine coolant temp once spiked to 240 degrees before I could get off onto the shoulder. Around town the truck does fine although I do notice a loss of coolant but no overheating issues what so ever. I have the Dpf Deleted and Egr coolers are off. I run an H+S on a mild tune. Is there any other thing that could be wrong with this truck besides head gaskets? I am not looking forward flipping that bill. Trying the exhaust all other possibilities first.
View 3 RepliesFord Super Duty (1999-2016) :: Overheating - Trans Fluid On Ground And Truck Steaming
I have 2000 ford f350 7.3 diesel. (Approx 95,000 mi). Tried to tow heavy wood chipper out of soft backyard, truck on angle because of grade. Put in low and second for better traction. After somewhat high engine rpm tires started to move me ahead until spinning occurred upon which I would immediately stop and try again (slowly). Next thing I know trans fluid on ground and truck steaming. Let cool down, refilled trans oil to proper level, unhooked heavy load. Fluid NO longer leaking, drive home fine (towing nothing). What are my next steps? Very concerned I've done grave damage!?
View 9 Replies