Ford Super Duty (1999-2016) :: Overheating - Trans Fluid On Ground And Truck Steaming
I have 2000 ford f350 7.3 diesel. (Approx 95,000 mi). Tried to tow heavy wood chipper out of soft backyard, truck on angle because of grade. Put in low and second for better traction. After somewhat high engine rpm tires started to move me ahead until spinning occurred upon which I would immediately stop and try again (slowly). Next thing I know trans fluid on ground and truck steaming. Let cool down, refilled trans oil to proper level, unhooked heavy load. Fluid NO longer leaking, drive home fine (towing nothing). What are my next steps? Very concerned I've done grave damage!?
View 9 RepliesFord Super Duty (1999-2016) :: 2001 F250 - Overheating - Replacing Bypass Valve On Trans?
I am having some trouble with my 4R100 overheating.
Truck is a 2001 F250 XLT 7.3L with 244k miles on it. According to previous owner, the transmission was replaced around 185/190k but there was no paperwork to prove it.
I recently had a leak from one of transmission lines coming into the bottom of the radiator (the one on the passenger side). I replaced it and topped off the little bit of fluid that leaked out. Last weekend I installed a temp sensor in the transmission and hooked it up to my pillar gauges. The first few days driving with it, the temp was at/around 180 degrees, 25-30 degree outside air, unloaded on the highway averaging 70-75mph.
Today on the way home, the temp got to 180 after 35-40min of driving then continue climbing. I pulled off the highway after 1.5hrs and the temp was almost at 210 degrees. I let it idle for 5-10min and the temp didn't change. I turned it off and let it sit for 15 min. Upon starting it back up, the temp had dropped to 180. I continued driving and the temp climbed back up to 210 within 35 minutes. (65-75mph, 24 degree outside temp, unloaded). Once off the highway I averaged 35-45mph on the back roads to my house. The temp started to drop back towards 180 degrees.
Before I start throwing money at it, and installing a 6.0 cooler etc. I am thinking there is something else wrong here. I am going to look at new lines and replacing/repairing the bypass valve on the transmission. I am driving 2hrs to work each way and thats when the temp really starts to go up. The fluid doesnt smell burnt, its still nice and red. I am going to try and flush the lines this weekend and see if something is plugged/caught. I ordered an inline filter today and will put that in with a new hose from the transmission to the radiator (old one is rusted).
Ford Super Duty (1999-2016) :: 2002 F350 - Trans Disengage At 20 - 25 MPH?
2002 F350 Super Duty 7.3 Diesel.Transmission trouble. Came off interstate - took foot off throttle at yield and hit gas as turn was clear. Did it fast and felt like hit wall. Immediately lost transmission engagement. Trans did not reengage until below 20 MPH. Tried to speed up and disengaged at 20 to 25MPH - just free wheel - engine wine. Went to 1st gear and would come up normally. Shift to 2nd and could get up to 30MPH and probably higher - didn't push. Shift to drive and trans disengage. No trans fluid leakage and level looks good and clean. What to look for? 126K miles.
View 1 RepliesFord Super Duty (1999-2016) :: 2011 F350 Overheating After Oil Change
I have an 11 F350 6.7. It has just under 200K miles on it. Yesterday I changed the oil. Very uneventful. Today however, I was driving home, about 100 miles, and my truck's temp spiked. Not like a little spike, but jumped to the 3/4 mark(if there was one) then slowly kept rising to to the overheat mark. I pulled off onto the hard shoulder waited an hour or so to let it cool down, then finished the drive home. All the way home my temp gauge seemed like it was on some sort of drug. It would jump a needle width when I would have to accelerate, then slowly cool to normal after I got up to cruising speed.
When I got home I checked the oil level and it was spot on in the "normal" range. I haven't used a different type/brand/weight of oil in the last 100k miles. Did something just give out on my truck? I had the coolant flushed and replaced at the dealer within the last 10k miles. Up until this point this truck has been exceedingly reliable. I pull a 13k 5th wheel once a month and drive about 40k-ish miles a year.
Ford Super Duty (1999-2016) :: 2011 F250 - Overheating When Running Idle Or At Low Speeds
My truck all of the sudden started overheating when running idle or at low speeds. No towing or anything with 89 degrees outside it can hit max water temp in matter of 2 minutes once at running temperature and standing on red light. I checked the coolant level - looks good and changed the thermostat just in case, but the problem is still happening. The fan is running/kicking in as well when it gets hot.
I'm waiting for OBD2 plug to read the stats from the computer, but what else would you suggest I can check for issues ? Oil temp gets to about 222 and transmission to about 194, but it doesn't keep on increasing. One another thing I noticed is that when I have AC running it will actually pop a overheating message on the display (I don't continue to drive it at that point) and when it gets hot it seems as if it didn't have much power.
I don't know if this is connected, but about two months ago it started blowing black smoke when starting from red light or stop sign or when accelerating with gear reduction. It is a 6.7 diesel one and only has 60k miles on it, so I'm hoping its nothing major.
Ford Super Duty (1999-2016) :: 2012 F350 - Running Temps For Trans
What are the normal running temps for the tranny of a 2012 f350 6.7?
View 3 RepliesFord Super Duty (1999-2016) :: 2008 F350 - Trans Temp Sending Unit Replacement?
The trans temp guage on my '08 F-350. V-10 started acting erratically, and the wrench icon popped up on the display. i crawled under the truck to look for the sending unit and it's lead. i assume that i found the lead. it is encased in a corrugated sleeve, and appears to be a vaccuum type tube and boot connector? the boot still had a small round gray cap plugged into it. it appears that the cap was never glued (go figure) upon assembly. i have tried to reach up on top of the trans to find the sending unit to figure out the best angle of attack. i can barely touch it with the tip of my finger. going with mechanical guages is out of the question at the moment, so i'm wondering can it be driven any distance this way, AND any schmooze tricks developed to get at the sucker without dropping the cross member or exhaust????
View 3 RepliesFord Super Duty (1999-2016) :: 2001 F350 - Trans Temp Sensor 4r100 Installation?
I have an isspro sensor that I need to install on my 4r100. I have it all installed except for the actual sending unit. My question is where is the best place to put it?
I've watched multiple YouTube videos and it seems a lot of people use the test port on the driver side above the linkage. I found out the hard way that it is a very poor choice of location. A lot of people say that the best way is to drop the pan drill a hole and weld in the bung? I was wondering would it be possible to put it on the "out" line on the transmission oil headed to the cooler? 01 f-350 7.3
Ford Super Duty (1999-2016) :: 2001 F350 Manual Trans 4x4 - Temp Gauge Not Working
I replaced the sensor on top of the water pump and the gauge still doesn't work. I tested the gauge by unplugging and grounding out the wire and the gauge goes all the way up. What I can try next. I didn't get a Motorcraft sensor so I'm going to go get one of those tomorrow hoping the duralast wasn't correct even though it looked 98 percent identical to the original. 7.3 lite diesel.
View 1 RepliesFord Super Duty (1999-2016) :: 2001 F350 5.4 - Free Rev Over 2500 RPMs - Engine Or Trans?
Truck: 2001Ford F350 5.4 auto 4x4
Issue: Engine seems to free rev over 2500 RPMs. Barely hits 50 MPH. Revs fine in park, no power in gear. At 1/4 throttle it will move, but sluggish at best. Once you get around 2500 RPMs it stops accelerating and just revs. Does this in every gear, and gets worse the faster you go. feels like its stuck inbetween gears almost. No CEL's
Replaced: MAF, TPS, Trans fluid and filter, fuel filter, cleaned intake system, fuel system treatment, O2 sensors. Trans fluid was dark, but no burnt smell.
I'm about to pull the exhaust and look for a clogged cat.
Ford Super Duty (1999-2016) :: 2004 F350 - Overheating - Oil Leak In Rear Head Gasket?
my truck at 210k miles got a new radiator (seeping at seams), thermostat, water pump (bearings shot, leaking), intake manifold (The crossover was leaking). It now has 227k miles. Oil leak in rear at head gasket by starter (bad head gasket?) It overheated the other day( blowing coolant out the expansion tank needle in the red) Replaced thermostat. Drove around for two full hours, seemed fine, Drove to work today it overheated ( same thing, blowing coolant needle pegged) didn't make it to work. There are no external leaks and its not putting steam or white smoke out the exhaust. I read somewhere that a blown head gasket could make the truck overheat, is that possible? What all could cause this problem?
View 6 RepliesFord Super Duty (1999-2016) :: F350 - Death Wobble At Slow Speeds
1999 F-350 7.3 Dually 2wd Front End issues. I think I may have several things going on so here goes. Truck has about 130,000 miles on it . Bought it with 60,000 miles in 2009.
It's always worn the front tires weird but it's gotten a lot worse and it's happening in about 10-15 thousand miles now. It's wearing the tires on both sidewalls like under-inflation but I run 70 lbs in them. I've noticed for several years now that it makes a knocking sound and I feel it in the floorboard, shakes in the steering wheel when I turn to the left only in a corner at speed. (65-70) ...
Now it's started intermittently going into the death wobble at slow speeds like the caster is to negative on it. I'm sure it could use some shocks but I just rotated the tires and I felt no play anywhere. I know when we used to get that bumping in the floor board on older Fords it was a bad radius arm bushing but that couldn't be all of what's going on here. I've done searches on this and it has happened to others but I haven't found a resolution from any yet.
Ford Super Duty (1999-2016) :: 2011 F350 - Brake Pad Squeal At Low Speeds
At low speeds, I notice a squeel sound in all four wheels. Ford tells me that it is due to the type of metallic pads they use and is essentially brake dust noise that warrants no repair.
Any after market pads that are good quality for towing heavy loads, yet aren't metallic in composition? For instance, are porcelin pads a good choice.
Ford Super Duty (1999-2016) :: F350 - Loud Clacking Clunking Sound Coming Directly From Trans
With the tranny in neutral and clutch out is when it is the loudest. With the clutch in their is 0 noise. The sound is a spinning clacketing sound best I can describe. The clutch is 2yrs old and was installed by a local shop using all OEM parts, the fluid level is perfect and looks brand new. The sound has come on gradually over the past 6 months but now can be felt thru the floor at the top of the gears as a rumble. The funny thing is that their are no performance issues like grinding,popping out of gear,hard shifting,etc.
This is not rolling gear mesh it is very loud clacking clunking sound coming directly from the tranny, not the transfer case, nor rears or u joints. This is standing still. Sometimes it will be a little less loud if I roll to a stop in neutral with the clutch out as opposed to gearing down to a stop push clutch in goto neutral and letting clutch out.
Ford Super Duty (1999-2016) :: 2005 F350 Overheating - Antifreeze Sprayed On Windshield Coming From Under The Hood
So yesterday we were towing our camper home from a weekend trip. We were pulling on the interstate at about 70mph, up a slight grade into a strong headwind. The outside temp was about 85 degrees, so not too hot out. After about 5 miles I got antifreeze sprayed on my windshield, coming from under the left front corner of the hood. The water temp held at about 220 degrees where it usually runs when towing hard but the oil temperature steadily worked up to about 240 degrees. I limped to the nearest place to stop and pulled over to let it cool down.
After it cooled down I added water to bring it back up to the minimum mark. We were 200 miles from home on a Sunday so I stopped in the local Wal Mart and picked up a can of stop leak and poured that in then we hit the road again. About 10 miles down the road the water again sprayed onto the windshield and the oil temp came up, this time hitting about 260. The water temp stayed between 218 and 220, once working up to 225, so I slowed down and the temps came down. I was able to creep along and made it 50 miles to a relatives house where I let it cool again and added more water.
When we hit the road again we made it about 10 miles and the oil temp had worked back up to 240, water temp stayed around 218 so I stopped at my parents house and dropped the camper. We drove the 100 miles home from there without the camper. The water temp stayed around 195 and the oil temp held at 212. If I got over 60mph the oil temp came up, but keeping it under 60 the temp held. So, what is wrong with my truck? Is the oil temp up because I was a gallon and a half low on water? The most I had to put in was a gallon and a half. Did I plug the oil cooler up with the stop leak?
The oil temp when towing has always ran 12 to 18 degrees higher than the water temp. I forgot to add, 2005 F350 with the 6.0 diesel. 240,000 miles on the truck. I have owned it just under a year and don't know a lot about it. I don't know if it has had any work done to it prior to my owning it, the antifreeze looks orange or yellow colored.
Ford Super Duty (1999-2016) :: 2006 F350 - No Crank - Engine Sensor Data / Trans Temp Error
I have an '06 F350 dually with a 6.0 diesel. I bought this used about 5 years ago and for the most part have loved it. i would always smile on the inside when i heard people bash the 6.0...i thought i got lucky....until today.
140k miles. recent oil change. all is swell...until this morning. Stick in key and turn it. glow plug indicator comes on...all lights come on for a few second....wrench, abs, dtc etc....wrench shuts off...glow plug light comes on...4 or 5 seconds later wrench light comes back on....turn key and NO CRANK.
All fuses are fine...starter cranks if i jump the solenoid...but it won't start. Miles to empty and everything else is just dashes hit the OBD and it says "engine sensor data error"/ "trans temp error" ...
Ford Super Duty (1999-2016) :: 2005 F350 Will Not Downshift With Pedal Pressed To Floor At Medium Speeds
Recently my F350 has failed to downshift when the accelerator pedal is pressed to the floor to speed up in traffic. It will usually happen when traveling at speeds in the 30's-40's. It will shift quickly at slower speeds. I have a scan guage on it all the time and it is not throwing any codes.
The transmission has only been serviced by the dealer; last done about 24000 miles ago. No leaks or low fluids/no burned smells. Stock setup with no heavy towing use. Currently at 228000+ miles, this is the first issue with the transmission assuming I am looking at the right area for the cause.
2005 F350 XLT 4WD
Ford Super Duty (1999-2016) :: 2008 F350 - 4x4 Low Light Flashing And Truck Surges Badly At Low Speeds
I'm having a strange issue with my 2008 F350 6.4. I have only had this truck for about 2 months now. Every time it gets wet (from rain or a carwash), the 4x4 low light begins flashing, and the truck surges badly at low speeds. When I get above about 25 MPH, the light stops, and the truck runs normally. At the next stoplight, it happens all over again. After a couple days of dry time (?), the truck is back to normal (until it gets wet again). I have found a couple of old threads involving some similar symptoms, but they were never resolved on this forum (that I could find). I believe the transfer case selector motor has been replaced at some point, as it has a Dorman brand sticker on it. I wouldn't think Ford would use Dorman parts as original equipment.
View 4 RepliesFord Super Duty (1999-2016) :: F350 - Trans Shifts Great Under Light RPMs But 2 - 3 Shifts Very Hard
I have 99 f350 v10 4x4 and trans shifts great under light rpms but 2-3 shifts very hard. At wide open from about 35 mph it will shift down and take off like a bullet but wont shift until I lift my foot and then it bangs hard from 2-3. All other gears are smooth. I did some searching and have found some threads saying it could be an accumulator spring that is broken? Truck has 115,000 miles on it. love the truck but want to fix this before it does some damage.
View 1 Replies