Ford Super Duty (1999-2016) :: Burning Smell While Towing Uphill
For the first time while towing a bumper pull trailer, started getting a very strong burning smell, only while going up decent size hills. After the climb, smell goes away. Kind of smells like burning rubber or wiring, but that should be constant and not just while up hill.
Checked tranny fluid and it didn't look burnt or low and never saw visible smoke. Have seen this discussed before but with no definitive conclusions. Truck has 150K on it and has long ago lost most of its towing power and the hills also drop the speed to around 45mph from 70 when I hit the big ones.
Ford Super Duty (1999-2016) :: 2006 - Tranny Slipping While Towing Uphill
'06 Power Stroke/136k miles.
This last weekend I was towing my rzr up hill and the tranny slipped, lost power, and the "Wrench" check eng came on. I pulled over, checked my fluids, checked for leaks, checked for smells, couldn't see anything visibly wrong.
Turned it back on and no other issues on the way to the camp site. On the way home, days later, same thing happened twice. Is the tranny going bye bye? Would it be worth it to get a flush for the possibility it just may be the fluid and maybe some sediments or something of the sort?
AND the bigger question is, if it is the tranny, should I trade this POS in, or replace the tranny? It has had a few problems lately with the turbo. Needs a new AC compressor. I didn't do much homework or know about the 6.0's before I bought this truck. After I bought this truck last year I heard about all the problems the 6.0's have and wished I would have went another route.
I can turn a wrench pretty decent (Aircraft Mechanic) but I have very little knowledge on vehicles, let alone this POS. I am apprehensive about doing a transmission or any big components without assistance. This is why I am trying to decide what the best option would be for the long run.
Ford Super Duty (1999-2016) :: 2001 - Installation Of Heated Towing Mirrors?
How hard is it to install heated towing mirrors on an 01 f-250 7.3L?
View 3 RepliesFord Super Duty (1999-2016) :: 2001 F250 - Overheating - Replacing Bypass Valve On Trans?
I am having some trouble with my 4R100 overheating.
Truck is a 2001 F250 XLT 7.3L with 244k miles on it. According to previous owner, the transmission was replaced around 185/190k but there was no paperwork to prove it.
I recently had a leak from one of transmission lines coming into the bottom of the radiator (the one on the passenger side). I replaced it and topped off the little bit of fluid that leaked out. Last weekend I installed a temp sensor in the transmission and hooked it up to my pillar gauges. The first few days driving with it, the temp was at/around 180 degrees, 25-30 degree outside air, unloaded on the highway averaging 70-75mph.
Today on the way home, the temp got to 180 after 35-40min of driving then continue climbing. I pulled off the highway after 1.5hrs and the temp was almost at 210 degrees. I let it idle for 5-10min and the temp didn't change. I turned it off and let it sit for 15 min. Upon starting it back up, the temp had dropped to 180. I continued driving and the temp climbed back up to 210 within 35 minutes. (65-75mph, 24 degree outside temp, unloaded). Once off the highway I averaged 35-45mph on the back roads to my house. The temp started to drop back towards 180 degrees.
Before I start throwing money at it, and installing a 6.0 cooler etc. I am thinking there is something else wrong here. I am going to look at new lines and replacing/repairing the bypass valve on the transmission. I am driving 2hrs to work each way and thats when the temp really starts to go up. The fluid doesnt smell burnt, its still nice and red. I am going to try and flush the lines this weekend and see if something is plugged/caught. I ordered an inline filter today and will put that in with a new hose from the transmission to the radiator (old one is rusted).
Ford Super Duty (1999-2016) :: 5.4L - Hold Up For Towing?
How does the 5.4 hold up for towing? Which trans works the best with this motor? I have a 5th wheel car trailer that I pull with a 36 hp tractor and loader on it sometimes. Would the 5.4 be to small or should I just stick with my powerstroke?
I was think of updating my old pickup with a 99 f250 cc 4x4 with either a 5.4 or powerstroke and either a auto trans or 6 spd manual What are your thoughts?
Ford 7.3L Power Stroke (1999-2003) :: 2001 F250 - Black Smoke When Towing Uphill
I have always seen other trucks blow black smoke with towing up a hill but mine for the most part has not. I pulled my 5er to CO this summer and notice my truck starting to blow black smoke. I consider myself a very conservative driver. I always stay around 65 MPH while towing and never push my truck up the hills. I always try to keep the RPM around 2000 and let the MPH fall where they may until I reach the summit. With the black smoke I'm starting to see what is my truck trying to tell me? It's not bad but would like to fix now before it becomes something more.
2001 F250, 4X4 crew cab, 7.3 with 205,000 miles.....
Ford Super Duty (1999-2016) :: F250 - No Power When Towing
We have a 99 F250 193,000 miles with a 5.4 and a 5 speed manual with 3:73 gears and we tow a camper that weighs empty 6700 lbs. I knew something was off when we were bringing it home, there was no real umph in the motor. It wouldn't get past 55 in 5th gear on the express way, and just felt as though it was gonna blow up. Its a new to us truck and on paper it should tow this easily. We have a couple of trips under our belt now, and nothing has really changed. With gear and goodies I dont think we're even talking 7500 lbs. I like the truck, and don't really want to get rid of it. With in reason what should I expect to be able to tow and what can I do to better the situation.
View 14 RepliesFord Super Duty (1999-2016) :: 2004 6.0 Stall After Towing
My early 04 runs great until I tow my 24ft rv any distance over a 2 or 3 hour period. When I exit the eway to fuel up or take a break it will stumble and this last time it quit running all together. I use my scanguage, all Temps good while towing never go faster then 65mph, new batteries etc. I had it towed to a local diesel repair shop that I have used before (all the 6.0 problems, oil cooler, egr hpfp, ficm).. When I Went to see them a day later, told me truck started right up and ran great, pulled a few minor codes, none that would have caused my issues. Scanner based testing passed air management, injector balance, all cylinders even.
When they originally scanned, it did show multiple docs for injector contributing, egr insufficient flow, 2 glow plugs and cam/crank sensor, but after cool down again started up and ran great. Truck has 200k on it. Last oil analysis showed internal engine in great shape. I trust this shop and this is not the first 6.0 they have worked on, I am just learning now of taking the rv on the road now. It would be difficult to hook rv up and just runaround to try and replicate what happened and be able to get to any repair facility. Truck is stock with exception of 4 inch exhaust,turbo back, no tuner etc. Also shop and I checked ICP and it is good, quarter volt. It was replaced with pigtail a few years ago.I also have the blue spring upgrade .Just drove to town and back and it runs perfect!
Ford Super Duty (1999-2016) :: Towing And Dual Rear Wheels
To tow a CASE 580L backhoe I believe a 1 ton should be just at its legal limit for towing. My question is do I need DRW's if I've got a gooseneck trailer total weight about 18K lbs (or will single rear wheels be legal)?
View 10 RepliesFord Super Duty (1999-2016) :: 2005 F250 - While Towing ABS Light Comes On?
I am wondering IF THERE ARE ANY CONNECTIONS WITH TOWING AND THE ABS LIGHT coming on? I just did 360 mile round trip on I84 and I 81 in western NY and eastern PA with decent hill climbs (some with 6% or so grades) - think coal country. I was pulling 8,000 or so pounds (trailer with a jeep on it).
On the way out, the ABS light came on. I pulled into a rest stop and shut her down for a bit. I had been driving on this terrain for the better part of 2 hours. I restarted and the ABS light turned off for the balance of the trip. It was cold (in the 20's) outside. On the return trip 2 days later, the same thing happened after 90 minutes. I stopped again and restarted the trip which turned off the light. This time, the light came back on 10 or so minutes later.
This is the only occasion when my ABS light has come on.
2005 F250 Crew Cab SuperDuty 6.0L
Ford Super Duty (1999-2016) :: V10 Switching To Defrost At Times While Towing Usually Above 65 MPH
So, my 06CC V10 likes to switch to the defrost at times while I'm towing, usually above 65mph, would that be a vacuum issue? Also, the truck seems to always have hot air blowing in to the cab somewhere from the fire wall? Lastly it seems to me that the steering wheel has a lot of play in it (left/right) before the wheels actually turn, should I tighten up the steering box, or is this normal.
View 4 RepliesFord Super Duty (1999-2016) :: 2013 F550 - Towing Limits?
I have a new 2013 F-550 Lariat 200" WB on order. I can and will increase the combination weight on the truck, to make full use of the 19, 500 gvwr. My question is how much will a current F-550 pull on a 5th wheel/gooseneck style trailer before it becomes dangerous? I plan to set the truck up with an 11ft aluminum Eby flat body, with a Holland FW6000 5th wheel placed under the body. I am considering a 35 or 40 ft flat gooseneck.
The combination weight would be changed based upon the axles I choose to put under the trailer. Two 12k axles will give me 44,000 gcwr, two 15k axles will give me 50,000 gcwr, and two 16k axles would give me a 51,000 gcwr. The truck will be able to carry about 10,000-11,000, the trailer needs to take the rest. I am confident that 44,000 gcwr will not be a problem, but the idea of 50,000, or 51,000 really makes me question safety. So, how much have you hauled with a F-550, and a gooseneck trailer?
Ford Super Duty (1999-2016) :: 2006 V10 - Loss Of Vacuum While Towing
Having trouble with vacuum on my '06 CCLB V10. I only lose vacuum while towing, not sure why. Lines all seem like they're fine. I have no issues while unloaded. What could be causing this?
View 8 RepliesFord Super Duty (1999-2016) :: Dies While Going Uphill?
My truck has been broke down for a few months and I just got it started a few days ago my alternator was bad so I replaced it yesterday I also replaced the map sensor now I have a hypertech installed in it and showing a Wastegate fail error code and anyways my truck only from a dead stop acts real sluggish and 3 times in a row when I go up a fairly steep hill it will almost instantly die just go and then it doesn't want to start for a while after I roll it back on level ground now I can back up a hill and no problem its only when im heading uphill its really weird
View 3 RepliesFord Super Duty (1999-2016) :: 2005 F350 - Shake Worse At 60 - 65 MPH When Towing
I know there are tons of threads on this and ive spent hours reading through them. but there are a few differences to mine.
2005 F350 6.0l regular cab long box. 4" lift on Duratec 33". Wheels balanced, driveshafts balanced, all u-joints checked and 1 was replaced (made no noticeable difference), all new brakes and rotors recently(due to wear)
When im not towing, vibration is noticeable between 60-65, but its only slight and i can live with it. Its felt in the seat and not the wheel.
There is also a very low grinding/pulsing feeling that happens as i am slowing down from highway speeds starting at around 10 mph until I completely stop. Its not the brakes and feels driveline to me. Can only be felt at these very low speeds while decelerating/coasting. Feel it in the seat and not the wheel. Not the end of the world but i have a feeling its related to my high speed issues. It is not felt on acceleration and I don't feel it when I am moving around parking lots/etc. ONLY when decelerating from highway speeds.
When I am towing the vibration randomly gets really bad right around 65mph the whole truck shakes and its very uncomfortable. It doesn't matter if I am on the gas or not, hill or no hill. If i slow down to 60 it goes away. It is very rhythmic with road speed (3 pulses with a slight pause)
Been doing a lot more towing lately and its bugging me. I keep falling back on tires, but not quite ready to bite the bullet on new tires as the ones on it still have tons of life left.
Ford Super Duty (1999-2016) :: 1995 F350 - Stock Fog Lamps And Towing MPG
Fog Lamps. How do you turn them on. I have a new (to me) 2005 F-350 Crew Cab Long Box Dually King Ranch 6.0L with all the fixes, S/C Programmer, and a water filter system. 200,000 miles
How do you turn on the Fog lamps and what kind of towing MPG are you getting? My 28' 5th Wheel weighs under 7,000, and my 36 footer triple axel under 12,000.
This sure isn't my old '95 F-350 7.3L single axel XLT Crew Cab 4X4 Long Box.
Ford Super Duty (1999-2016) :: 2014 F250 - Fuel Mileage While Towing
My 2014 f250 4x4 crew cab with 6.2l gasser only gets about 7.5-8 mpg at 65 mph while pulling my 27' bumper pull travel trailer. I know that thing is basically a wall trapping the air but is there anything I can do to gain a couple mpg more? I can average about 15 mpg at 65 mph without the trailer on the highway.
View 14 RepliesFord Super Duty (1999-2016) :: 2011 F350 - Towing Mirrors Won't Extend
I have a 2011 F350 with the towing package. I got it used as it and it was a northern truck. My towing mirrors won't extend in or out. They fold and unfold just fine. When I press the button to telescope them I can hear the motor running so I know the fuse is good. I took the glass off the mirrors and scraped some salt out of the joints. I sprayed some lube on the joints as well but still no luck. I also tried forcing them but not too much to avoid breaking them.
View 1 RepliesFord Super Duty (1999-2016) :: Truck Jerks Violently When Trying To Brake Only When Towing
Truck jerks violently when tring to brake only when towing. Its has done it when towing a large trailer with surge brakes, Does it 1 out of 3 times when stopping with electric brakes (goose neck trailer)...
View 12 Replies