Ford Super Duty (1999-2016) :: 2008 F350 - Fuse 9 And 15a Keeps Blowing
2008 F350 6.4 diesel. I have the listed truck in the heading, my #9 fuse which is for the interior lighting, lighted running boards and it is a 15a fuse, keeps blowing as soon as I touch the fuse to the fuse box to replace it. I have look at all the map lights and interior lights and can not find any thing out of the ordinary, all of these light were working fine, also my cruise control and the back up sensors stopped working and they are not on the same fuse and the other components that are on the circuit with the crule and back sensors still work, I know that this is a lot of different things but hate chasing electrical ghosts...
View 3 RepliesFord Super Duty (1999-2016) :: 2001 F350 - Battery Drain Fuse 15 Location?
The 5amp fuse 15, (Stop lite switch, GEM, PCM, 4WABS, Brake shift Interlock, Cluster 7 PCM-Keep Alive memory), is drawing 2.7 amps with key off.
The battery has gone dead two times overnight. The truck will start and run. I don't know where to proceed from this point to isolate the problem.
Ford Super Duty (1999-2016) :: 2005 F350 - Reverse Lights Blowing Fuse
My 2005 f350 reverse lights just started to not work . So I checked the fuse and it was blown and every time I put new fuse in it blows, where to check. Sounds like a ground issue am I correct .
View 4 RepliesFord Super Duty (1999-2016) :: F350 Dripping Water After Engine Shut Off
I have a 1999 F350 7.3 truck and when I shut off the engine I get a small drip of water (not antifreeze or oil) for about 20 seconds and then it stops. It's coming down from the passenger side somewhere under under the wheel well back around the firewall. Everything in the truck appears to be running normal and all fluids are at normal levels.
View 12 RepliesFord Super Duty (1999-2016) :: 2002 F350 - Fuse Keeps Blowing Every Time When Touch The Brake Pedal
I have a 2002 f350 7.3 PS that every time I touch the brake pedal it blows the #6 fuse(trailer tow brake/turn signal). I need to use my trailer.
View 14 RepliesFord Super Duty (1999-2016) :: F350 Lost Power - Fuse Panel Under Steering Wheel Shorting Out
So I have a 1999 F350 diesel and the fuse panel under the steering wheel is acting up. I was driving my truck home the other night and I lost power and my truck shut off. I have had a problem in the past with the #30- 30 amp fuse ( controls the PCM and glow plugs from my understanding) that is under the steering wheel, I replaced the fuse and everything started working normally again.
Until the other night when my truck shut off, so I replaced the fuse the truck drove again for 20 feet died again, I was able to hold the #30 fuse and allow my truck to start up again but would eventually killed the PCM and shut off again and would not start up due to what I believe the fuse location shorting it out and killing the power to the PCM preventing me from starting it up again. I had my truck towed home and charged the battery and it started up fine the next morning. If I push on the #30 fuse my truck the shorts out and kills the power, I do not know if this is normal?
The fuse is sitting loose in the fuse holder is there anyway making it fit tighter to prevent it from being so loose? I have read every other post online about the problems and tried everything they have recommended but still can not figure out what was wrong with my truck. I disconnected the fuel filter heater, and also the wastegate solenoid to see if that would prevent the truck from shorting out if I pushed the fuse it did not work.
What the problem could be causing the #30 - 30 amp fuse to be shorting out preventing everything from working? Or how to test the fuse panel and all the relays?
Ford Super Duty (1999-2016) :: 2002 F350 - Direct Short In Windshield Wiper Blowing Fuse
Windshield wipers, and washer were suddenly not working the other day, so I discovered a blown fuse. Put a new one in, and it immediately blew again. So there is definitely something grounding out, and I am suspecting the wiper motor itself because so far I have not been able to find any wires shorting out, but before I go to the trouble of pulling the motor out and testing it, or replacing it.
Truck is a 2002 F350CC 7.3 TD. Wipers were working fine the other day before I pressure washed it, which is why I really suspect the wiper motor itself.
Ford Super Duty (1999-2016) :: 2015 F350 - Water Pump Quit Working At 20k?
The water pump on my 2015 350 (6.2L) failed this morning and the dealer says it needs to be replaced. What might have caused it?
View 6 RepliesFord Super Duty (1999-2016) :: F350 DRW - Oil Leak Out Of Front Housing
I noticed an oil leak out of the front housing of my 2016 350. I have 3 Ford dealers nearby and all 3 can't get me in until 8 August. It looks to be just a few drops daily. Is it safe to drive pulling a 5th wheel until they get me in? The leak is at the bottom of the housing.
View 3 RepliesFord Super Duty (1999-2016) :: 2006 F350 - Vacuum Leak When In 4x4
When I put my 06 f350 in 4x4 my ac defaults to defrost. I assume this means a vacuum leak. My question is, is the white tube supposed to be open for air intake or plugged off with something?
View 5 RepliesFord Super Duty (1999-2016) :: 2006 F350 - Cannot Find AC Freon Leak
I had a new engine put into my 2006 F350 SD 5.4 last year and ever since then I can't keep the freon charged in my ac. The mechanic said all he did was lay the compressor out of the way and didn't disconnect anything ac related. I have 2 different shops keep my truck for a couple days and neither could find a leak. Yet a month later, freon is low. I think I have more dye in my system than freon.
I put 2 of those ac leak sealers, the ones you have to ask for behind the counter and can keep my ac working for maybe 45 days, then throw 3 cans in it. No dye is showing up nor will the sniffer find anything. I hate to go to the dealer because I figure they will want to replace everything. Any tips other than try another shop and maybe they can find the leak.
Ford Super Duty (1999-2016) :: 2003 F350 - Minor Coolant Leak
03 f350 5.4. Very minor coolant leak at the moment. Valley behind water pump looks a little damp and leak has shown a little on the passenger side block above the starter. Shows on the tranny bell housing and hits the y pipe every once and a while. I am thinking its the hose that runs under the intake manifold but wanted to check in here for some wisdom. Can it be bypassed or rerun without pulling everything.
View 12 RepliesFord Super Duty (1999-2016) :: 2002 F350 - Gas Oil Leak At The Back Of Engine
I have a 2002 V10 F350 6.8L that I recently purchased at auction and am fixing up. I've made good progress already and replaced many of the suspension components so that the tuck drives straight. It does however have an oil leak that seems to manifest of heavy acceleration.
I'm not sure exactly where from as I have not crawled under the car, but I can see a drip land right on the Y pipe coming out the exhaust manifolds. There is enough of a drip to create quite a smoke storm under the hood. Any common areas to look for?
Ford Super Duty (1999-2016) :: 2003 F350 V10 - Exhaust Manifold Leak?
2003 F350 short bed 6.8L V10---On start up a slight tap sound, almost like a cranky lifter, but it is an exhaust manifold leak. At the bolts, I am not sure. This has been this way for 5 years, no better no worse. After I run about 2 to 3 minutes it seals itself. Not a hint of noise. Due to heat, something is expanding to seal it (aluminum).
At my annual PA. State Safety Inspection the Tech says 'that has to be corrected if it worsens', but It does not fail inspection. This puzzles me.
How is the call made for correction. A flip of the coin, a guess and is it serious enough to fail inspection. Is this normal with the 6.8L or V10s. I know the cost involved for a fix is big league, but can it be justified. TRUCK RUNS GREAT !---
Ford Super Duty (1999-2016) :: 2007 F250 - Water Leak / Carpet Wet On Passenger Side
I have a 07 6.0L and the other day while cleaning it out I noticed that the carpet on the passenger side was wet. I have never noticed it before so this had to recently start. I don't think its heater core related as its completely clear and doesn't have a smell to it. I am also not loosing any coolant. The truck only has 18,300 miles on it,and it sits most of its life until recently after I took it over.
It has never had the windshield replaced,to be honest nothing has been replaced. I don't believe its a/c drain related either, the hvac controls have been in the off position for the last 2 weeks,and just 3 days ago after drying the carpet out completely(with a fan), its wet again after a nights rain, not as wet as before, but its damp.
And last night it was pouring down rain and I had the carpet pulled back to dry/air out, so I thought I would go out and take a look to see if i can see water coming in. Sure enough there are 2 trails of steady water flow. Its coming from directly under the glove box, there is a silver canister that is held on by 2 screws, its dripping down 1 of those screws. I cant quite make it out where its coming in from, but i am thinking the blower housing.
Ford Super Duty (1999-2016) :: 2005 F350 - Water Dripping In Cab Over Glove Box In Rain - A/C Blowing Humid Air?
2 things-
1) When it rains, I get water dripping in the cab over the glove box. The seal on the windshield looks fine. Truck has a sun roof. Is there a drain tube or something from there that might be plugged?
2) AC sometimes blows very humid air in the cab. It doesn't do it all the time, but seems to be in a cycle. After it runs for a while it switches to this humid mode and gets almost unbearable, to the point that I turn it off. In summer, when cooling, this air is warm. In winter, air is warm, but fogs windows pretty bad. What causes this? Noticed also that the tubes under the hood covered in frost and truck drips water from this area seemingly excessive when I park it.
The truck is an 05 F350 King Ranch 4x4 with the 6.0 Powerstroke
Ford Super Duty (1999-2016) :: 2005 F350 - Vacuum Leak - Manual Locking Hub?
So I have an 05 f350 5.4 with the shift on the fly and the auto/manual locking hubs.. I already know I have a leak with the vacuum and I just use the hubs manually, then shift on the fly to activate the transfer case.
I went to use the 4wd the other night in a snow storm and I have no 4wd, light on the dash comes on and i can hear the transfer case clicking in when i hit the switch between 2wd and 4wd.
So I got under the truck while it was on the ground and manually locked the passenger side, Then tried spinning the axle and it wont spin freely, so obviously its locked.
Tried the same thing on the driver side and the axle spins freely while the hub is locked, So obviously the locking part of the hub is no good... So i guess my question is, even with just 1 wheel locking in the front, shouldn't I pretty much get 3wd? or am i missing something...will it not engage at all because both sides arent locked?
Ford Super Duty (1999-2016) :: 2005 F350 - Leak In High Pressure System
I recently came a cross a no start issue with my truck. It is 2005 ford f350 6.0 ... Found out I have a leak in the high pressure system. When I was taking out the bolts out from the manifold I stripped out two bolts. I know ford part # w301383 is the ford bolt. But I was thinking why use that same bolt and had have that issue again later.
View 1 RepliesFord Super Duty (1999-2016) :: 2011 F350 - Windshield Washer Tank Leak
Filled up the windshield washer tank this morning and could not get the sprayer to work. Looked under the truck and it looks like all I put in is on the drive. Any one else had issues with 2011 F350 washer tanks?
View 3 Replies