Ford Super Duty (1999-2016) :: 2003 F250 - No Heat And Coolant Flow Restriction
I have a 2003 F250 Super Duty 5.4L V8 with no heat. It wasn't missing, running funny or blowing white smoke out of the tailpipe and there were no coolant leaks nor did it overheat. Thermostat has been replaced twice, heater core flushed twice, water pump replaced, fan clutch replaced and blend door works...Cabin airflow gets colder when turned from hot to cold. This thing is sitting in my driveway and I am about to push it over a cliff. Did I mention it only has 56,000 miles on it?
Coolant was drained to replace water pump and flush heater core (again, water ran through in both directions with no stoppage). 3 gallons of undilluted antifreeze was put into the overflow bottle to be topped off with water...the coolant went in and stopped. Engine was started to force coolant from bottle...coolant backed up into the bottle and out the top. Heater core inlet hose is hot and outlet hose not very warm if at all. Upper radiator hose is soft. Didn't check lower radiator hose as I was a bit peeved and slammed the hood closed and called it a night. I have been throwing money at this thing that I do not have and am at my wits end with it.
Ford Super Duty (1999-2016) :: 2003 F250 - T-Stat Stuck / Puking Coolant In Front Of Engine
I have an 03 F-250 6.0 Lariat with almost 200,000. The other day my t-stat started sticking and popping at 220 and then would go back to normal. Now it won't pop and it's puking coolant in the front of the engine. Would just a bad t-stat cause this or do I need to do my water pump as well.
View 1 RepliesFord Super Duty (1999-2016) :: F250 - Coolant Reservoir Was A Bit Low
I just purchased a 2007 Ford F250 5.4l V8. I noticed the coolant reservoir was a bit low so I went out and bought some Prestone extended life universal coolant, distilled water and a hydrometer. The current Coolant I have is a yellow/gold colour, which I believe is motocraft brand. I added 150ml 1:1 of distilled water and coolant. After that I tested the temperature rating and it was off the gauge (the previous owner obviously added just coolant and no water). My plan was to drain the radiator half way and refill with distilled water. But, how to do that I came across a lot of forums saying you can't mix Prestone ELT with Motocraft coolant or it will eat away at your engine as well as create a thick goo. Is this true? Will such a small amount (75ml) cause this effect? Do I have to do a radiator flush now, or can I just continue with my plan of draining it half way? The old coolant looked pretty clean. Do you think the Prestone anti freeze has already done any damage?
View 14 RepliesFord Super Duty (1999-2016) :: F250 V10 - Smell Coolant When Heater Is On
I got my 1999 f250 super duty v10 about a month ago. It had 200,700 some miles on it. It's now at 201,865. My issue is when I turn on my heater I smell coolant. It's kinda strong. No leaks that I can see. Not in the ground or in the cab or from what I can see of the heater core. It only smells when the heat is on, no smell on the cold setting. It sat for months before I bought it from a dealership. What it could be? Ok now it sounds like I have the ticking death sound. The one people have said happens when spark plugs are about to fail. So I guess new plugs are in order.
View 8 RepliesFord Super Duty (1999-2016) :: 2006 F250 - Coolant Leak Only When Truck Is Cold
I have a 2006 Ford F-250 coolant leak only when the truck is cold. Ive noticed it in the morning when I leaving for work. It looked liked it was coming from the passenger side yesterday and today it's on the drivers side when I'm sure is because my driveway has a small tilt to it I've looked everywhere I could under the hood and don't see it leaking.
I don't have any temp problems or white smoke and my coolant level has changed that much and for a few days the drip stopped now it's back. I tried to search for the answer but can't find it. I'm just wanted to make sure it's not the head gasket but I'm sure I would have a sign it it was. I will include where I saw it dripping from. It's parked on flat ground here ... That's where I saw a drip coming from driver side ....
Ford Super Duty (1999-2016) :: 2000 F250 - Mixing Coolant In The Block And Leaking Oil
I just bought a 2000 F250 SD 6.8 v10 and its mixing coolant in the block and leaking oil. I'm debating on just dropping a newer v10 in it but im just not 100% sure that this engine is shot. It runs great when there's oil in it and I can't even tell there's any problems going on for well over a couple hours after i fill it up with oil.
View 8 RepliesFord Super Duty (1999-2016) :: 2004 F250 - Coolant / Transmission Gauge Switched
A few months ago I had a battery go bad. When I started the 2004 F250 6.0 it barely started. After that my transmission gauge became the engine coolant gauge and the engine coolant gauge became the transmission gauge. I tried disconnecting batteries but that did not work. I have the Scan Gauge tool and confirm the gauges are reading correctly but just swapped. So I'm wondering if the is a reset procedure for instrument panel.
View 7 RepliesFord Super Duty (1999-2016) :: 2006 F250 Does Not Start And Spiting Coolant From Reservoir
I am new to fords i have an 06 f250 6.0 lariat i just replaced head gaskets and studded the heads with egr delete with new oil cooler ..my issue is now the truck wont start it trys but wont run and i have coolant spitting out from reservoir and its smoking from it as well. I really don't want to have to spend the money on a shop to rebuild it...
View 6 RepliesFord Super Duty (1999-2016) :: 2012 F250 - Coolant Change Required Message At 59 Kms?
My 2012 F-250 gas just started showing this message that a coolant change is required. I am just over 59k miles. Is this a timed message all F-250's get, or is it an indications something is wrong? The truck does not run hot, it keeps perfect temperature even when I am towing my 13klbs boat.
View 3 RepliesFord Super Duty (1999-2016) :: 2000 F250 - Leak From Oil Pan Gasket And Coolant Lines
I have a leak from the oil pan gasket and oil coolant lines. From the research I have done, it looks like I have to lift the motor to change the oil pan gasket. Any way to get this done without lifting the motor??? 2000 f250 5.4 2wd....
View 4 RepliesFord Super Duty (1999-2016) :: 2006 F250 Misfire - Coolant In Spark Plug Well #8?
I have a 2006 F250 5.4L. I was getting a noticeable misfire after not driving the truck for a while. Mode 6 revealed that cylinder #8 was misfiring.
I took off the coil/boot and there was coolant on the tip of the boot and some at the bottom of the spark plug well.
I cleaned everything up and put everything back together and that took care of that problem when I started the car. I also stuck a wad of paper towel by the intake manifold nearest spark plug number 8 and tightened the manifold bolts down a little. Some of them were not as tight as others.
I went back today and started the vehicle and it has the same problem again!
I took a look at the paper towel and it was totally dry! There is no coolant around the top of the spark plug well - only in the bottom of it. Where is this coolant even coming from? There are no coolant lines near cylinder #8. Is this a head gasket leak?
I have taken a look at the head gasket and that doesn't seem possible since the head gasket does not seal around the spark plug well at all as far as I can tell.
Ford Super Duty (1999-2016) :: 2011 F250 6.7 - Check Coolant Additive Warning Light Won't Go Away
I have a annoying check coolant additive warning light that wont go away, is their another way to turn off the light other than the button on the steering wheel? I have searched the forum but have had no luck, my coolant level is at it's proper level.
View 3 RepliesFord Super Duty (1999-2016) :: F250 Running Hot While Towing Travel Trailer - Coolant Loss
My 99 f250 ran hot while towing my travel trailer when the fan clutch gave up. ever since iv been noticing coolant loss and pressure in the day tank.ive changed the water pump,radiator. day tank and cap plus the thermostat.
View 9 RepliesFord Super Duty (1999-2016) :: 2008 F250 - Coolant Leak Above Lower Radiator Hose
I'm trying to troubleshoot a leak on my 08' F250 with a 6.4 powerstroke. It's been dripping coolant when cold pretty aggressively. Once the truck heats up, the coolant leak seems to mostly go away.
Here's a picture of the drip, it's marked by a dart, so you can see the location from the top (second pic). The radiator house connection around the engine seems dry.
Pic from Top ....
What's hidden here that could be causing the leak?
Ford Super Duty (1999-2016) :: 2003 F350 - Minor Coolant Leak
03 f350 5.4. Very minor coolant leak at the moment. Valley behind water pump looks a little damp and leak has shown a little on the passenger side block above the starter. Shows on the tranny bell housing and hits the y pipe every once and a while. I am thinking its the hose that runs under the intake manifold but wanted to check in here for some wisdom. Can it be bypassed or rerun without pulling everything.
View 12 RepliesFord Super Duty (1999-2016) :: 2003 F250 - Getting 10 - 11 Mpg?
I have a 2003 f-250 s/d 7.3 ltr. 4x4, it is lifted 4" with 20 " pro comp tires and an auto tranny. I am getting between 10 and 11 mpg. whether pulling my 26 ft. trailer or just driving around town. I was told that is not good mpg. What I can do to improve the fuel economy or is 10 mpg normal.
View 11 RepliesFord Super Duty (1999-2016) :: 2003 F250 - Vibration Between 40 And 60 MPH
I have an '03 F250 Super Cab, 7.3L PSD, 4WD. I've started getting a large vibration between 40 and 60 mph. Started after driving on the PA highways towing a trailer with a car and hitting several deep pot holes.
I have had the wheels balanced, rotated, balanced a second time by a different shop and had them perform an alignment - Still No change.
The garage I took it to said the hubs were shot so I had them replaced - supposedly with Moog, lifetime warranty hubs. Still - No Change.
The tie rods and steering linkages are a year old, so unless something was damaged (visually, they look good, and feel tight) it probably isn't them.
I replaced the ball joints around 80,000 miles and now the truck has 155,000 miles. They appear to be ok, with maybe just a little movement in the Passenger side upper.
If there is any movement at all in the ball joint, will it cause a vibration?
I plan to rotate my full size spare through all 4 corners this weekend to eliminate the possibility of a bent rim.
I have another set of ball joints and seals on order which should arrive next week. Probably next weekend's project.
Ford Super Duty (1999-2016) :: 2003 F250 Has Rusted Bed?
My '03 F250 has a rusted bed. Both Rear fenders have it and if i didn't have a bed liner the bed would be rusted through. Where i can get a new take off or used bud decent bed? Any color doesn't matter just needs to be the short bed not the 8ft one.
View 4 RepliesFord Super Duty (1999-2016) :: 2003 F250 Dies When Put In Gear
I have an 03 f250 5.4l that I've been having some problems with. When the engine is cold it will drive fine and everything. When it warms up, if I go to put it in gear it just dies right away. Why?
View 1 Replies