Ford Super Duty (1999-2016) :: Ratcheting Air Sound Going Uphill
I have a 2005 F350 SD with 217K. It's got a Magnaflow aftermarket exhaust and newer OEM turbo. When I'm driving uphill and around 1800 RPM or higher, the engine makes this weird ratcheting sound when I let off the gas. It almost sounds like air is backflowing somewhere. It doesn't do it on level streets or downhills or when I'm below about 1500 RPM. The sound is not a metal on metal type sounds. It literally sounds like high pressure air backflowing somewhere or not being discharged properly. Also, I bought the truck used a couple months ago. So I'm not sure of all of the aftermarket upgrades done to the engine.
View 7 RepliesFord Super Duty (1999-2016) :: 2008 F250 Has Been Slow Going Uphill
Last few months my 08 F250 has been slow going up hills. The fluid checks out ok and it shifts fine.
It just seems to take forever to get up hills. Has 124K....
Also has a huge hissing noise thats RPM dependent on the passenger side. Will make the sound in neutral just revving.
Ford Super Duty (1999-2016) :: Burning Smell While Towing Uphill
For the first time while towing a bumper pull trailer, started getting a very strong burning smell, only while going up decent size hills. After the climb, smell goes away. Kind of smells like burning rubber or wiring, but that should be constant and not just while up hill.
Checked tranny fluid and it didn't look burnt or low and never saw visible smoke. Have seen this discussed before but with no definitive conclusions. Truck has 150K on it and has long ago lost most of its towing power and the hills also drop the speed to around 45mph from 70 when I hit the big ones.
Ford Super Duty (1999-2016) :: 2001 - Overheating When Towing Uphill?
I have a 2001 excursion 7.3 4x4 with the 6.0L trans cooler. It is over heating when heavy, uphill towing is under way. I am guessing that my computer has been reprogramed at some point and more fuel is being injected than the radiator is designed to cool. I know my trans cooler is clean. I have tried cleaning the radiator and intercooler with a garden hose. I am considering a hood scoop or some sort of vents in the hood. When it over heats I turn on the heater and open the hood and the engine temps drop in just a few minutes so I believe that the engine needs more cooling or I need to slow down a bit on hills. Any other cheap fixes to get more air in to cool things under the hood more?
View 1 RepliesFord Super Duty (1999-2016) :: 2008 - Loss Of Power And Sputters Going Uphill
I bought 08 6.4 113000 on it 4x4 lariet drove 300 miles home. No problem 2 days later runs fine for 45 minutes than loses power and sputters up hills starts no problem every morning every time wait awhile sometimes runs fine was on e when test drove canged both fuel filters oil and drained 8 quarts tranny fluid and replaced it. When problematic rpms wont go over 2 turbo psi seems high seems in sync with rpms dropped...
View 3 RepliesFord Super Duty (1999-2016) :: No Power / Going Uphill Is Rough / Gas Engine Loud
I had a leaking coolant crossover so had to remove that and replace it with a new one. In doing so i removed the air assembly, throttle body, fuel injectors, and Spark plug coils. I reassembled everything, no more leaks but now my GAS engine sounds like a school bus. I've lost power, going up hill is rough, once i hit 40mph my car starts to shake a little bit but when I am on a straight away it will sometimes drive normal and sometimes go back to driving slowly. it also idles rough.
View 14 RepliesFord Super Duty (1999-2016) :: 2005 F250 - Transmission Slipping Going Uphill
I bought my F-250 Super Duty 6.0 last October, and I am extremely happy with it comparing to my former '03 Dodge 2500 TD. The Ford drives so much better!
There is only one problem I have with it. Without pulling it shifts nice and has lots of power. A Month ago I bought a fifth wheel trailer and I hardly notice it behind the truck, also it doesn't use more diesel pulling. However going uphill the transmission seems to slip, and I can hear (sounds like) a fan running loud? I loose speed.
All the temperature gauges stay normal, no difference. It starts to pull worse. I replaced de tranny filters, inside and the outside one. Also I did put the correct transmission fluid in there, no difference. Almost no grindings in the oilpan/magnet.
I looked on many sites, but cannot find anything on this. Personally I think it's the torque converter? My final step would be to have the transmission rebuild, with the best parts available, (close to WA, ID, MO)...
Ford Super Duty (1999-2016) :: F350 RPMs Surges When Going Uphill With A Load
1999 F350 7.3 Super Duty surges when going uphill with a load. The only time we drive it is when towing the horse trailer - also has a camper on.
The truck doesn't physically surge, just the RPM gauge goes up and down and along with it a humming noise.
Also, What conditions should I engage the towing button on the end of the gear shift? I've heard several answers. Should it be engaged when towing or off?
Ford Super Duty (1999-2016) :: 2006 - Tranny Slipping While Towing Uphill
'06 Power Stroke/136k miles.
This last weekend I was towing my rzr up hill and the tranny slipped, lost power, and the "Wrench" check eng came on. I pulled over, checked my fluids, checked for leaks, checked for smells, couldn't see anything visibly wrong.
Turned it back on and no other issues on the way to the camp site. On the way home, days later, same thing happened twice. Is the tranny going bye bye? Would it be worth it to get a flush for the possibility it just may be the fluid and maybe some sediments or something of the sort?
AND the bigger question is, if it is the tranny, should I trade this POS in, or replace the tranny? It has had a few problems lately with the turbo. Needs a new AC compressor. I didn't do much homework or know about the 6.0's before I bought this truck. After I bought this truck last year I heard about all the problems the 6.0's have and wished I would have went another route.
I can turn a wrench pretty decent (Aircraft Mechanic) but I have very little knowledge on vehicles, let alone this POS. I am apprehensive about doing a transmission or any big components without assistance. This is why I am trying to decide what the best option would be for the long run.
Ford Super Duty (1999-2016) :: 1997 - Uphill 4th Gear Very Hard - Clutch Slipping?
I have a 1997 F250 heavy duty 4x4 7.5 efi. I just bought a 2003 weekend worrior weighing 5800lbs dry. When I go up slight hills in 4th gear it seems to work real hard especially on freeways, could my clutch be slipping or am I just at max tow
View 11 RepliesFord Super Duty (1999-2016) :: FIPL Sensor For 4r100 - Downshifting On Acceleration Going Uphill
Having downshifting problems with REbuilt transmission. Is there a FIPL sensor for the 4r100? I was told to check all engine codes first, but i just have a EBPV sensor code, but removed the valve when I installed the GT38R turbo...
Rebuild:
- Tugger kit
- triple disc Billet torque converter
- New clutches and seals,.
- Banks Trans command module
... I also have a 6-pos tuner.. I had a Super chips tuner too and it has ALWAYS had the downshifting on acceleration on up-hill grades!!
Ford Super Duty (1999-2016) :: Temp Gauge Pegs Over 250 And OD Light Flashes Steadily Going Uphill
When I purchased my truck 1999 F350 about 5 years ago, I was told it was on its third transmission since the awesome 7.3 diesel engine has 200,000 miles on it. At first I noticed that going up a hill with the truck empty would cause the tranny temp gauge to climb to 250 degrees F. Nowadays when I tow my boat or carry my camper, the temp gauge pegs over 250 and the overdrive light flashes steadily when I do any hill climbs. I have had the fluid flushed several times, and I have a large fan powered oil cooler too. I also recently noticed that the tranny heated up when the truck is just idling in place.
I just got back from burning man and during the 800 mile round trip the overdrive light started flashing at least 6 times and the temp gauge read over 210 the whole time, with it pegging over 250 during hill climbs. No fluid boiled out but I am very concerned that damage is being done.
Is it possible there is a clog in a line somehwere restricting the flow of oil? Or should I replace the tranny?
Ford Super Duty (1999-2016) :: 2006 F250 Truck Shifts Into Neutral When Driving Uphill At 40 MPH
Driving up a slight hill unloaded yesterday at about 40mph constant pedal pressure the truck shifts into neutral...at least that's what it feels like. Revs go up and no power. When I take my foot off the pedal the transmission catches and drives fine. There is no bucking or hard shifting, just that slipping. What it could be? This problem arose suddenly....never had any problems prior. It is not an issue that has gotten worse over time...
View 14 RepliesFord Super Duty (1999-2016) :: 2005 - Blue Smoke Pouring Out Of Back Of Truck At 70 MPH On Uphill Section
I was towing a 16' Carmate Box trailer (empty), in tow/Haul mode, through the mountains on the PA turnpike. On an uphill section, 70 mph, suddenly blue smoke was pouring out of the back of the truck. I immediately slowed to about 50mph and pulled over at the next opportunity, about a mile. The bottom of the trans pan was coated with fluid, mostly on left side and the exhaust crossover pipe was smoking. Gauges were all normal. Ambient temp was 90F.
I drove another 40 miles, mostly about 60 mph. No problems. When I started climbing in elevation, and hit 70mph again, the smoke started again. I pulled over again and crawled under to fine the crossover pipe in flames. I grabbed a rag and beat out the flames. Fluid was red. Gauges were normal again. Once I disconnected the trailer, I can find no leaks. Snugged pan bolts. I cannot duplicated the problem without the load and speed.
Background: 2005 Crewcab, 5.4, 5R110 trans, 3.73. 416,000 miles, I have towed about 50K miles of that. Trans always ran great. Never replaced.
Ford Super Duty (1999-2016) :: 2008 F250 - Lost Power While Driving Uphill At 60 MPH / Shut Off / No Start
While driving up hill at 60mph the truck lost power. Rpm jumped up as to change gears as it hit 55mph. Still losing power until it shut off. I tried to restart and just got a click from the solenoid. No engine codes whatsoever. Battery had 12.1 volts but when turning the key to start in getting 8 volts. Had it towed home. Today I swapped batteries with my other truck and same click noise from solenoid. All lights, radio, ect still work. Where should I start? Alternator, fuses...?? 2008 f250 5.4 ...
View 12 RepliesFord Super Duty (1999-2016) :: Truck Dies When Turning
So I've been having this problem that sometimes when I am turning the truck dies. It doesn't stutter or anything it just shuts off and will start right back up. It doesn't do it all the time either. Was also having an issue where the windshield wipers would shut the truck off too. But I don't think that's the same problem.
View 3 RepliesFord Super Duty (1999-2016) :: 2003 F250 Dies When Put In Gear
I have an 03 f250 5.4l that I've been having some problems with. When the engine is cold it will drive fine and everything. When it warms up, if I go to put it in gear it just dies right away. Why?
View 1 RepliesFord Super Duty (1999-2016) :: F250 4x4 460 Dies While Driving / No Warning
My 1997 F250, 4x4, 460, auto has started dying with no warning while driving from 5 to 30 miles. Changed the fuel filter and the fuse under the hood. Where to start.
View 14 RepliesFord Super Duty (1999-2016) :: Dies In Mud Hole - Insulation On The Hood Wet?
5.4L f250 is dead. Went through a small mud hole and the he truck just died. The muddy h20 was about 1/2 way up on my tires. After getting pulled out I checked the air filter and its dry. I did notice that the insulation on the hood was wet towards the back half of the engine. Guess maybe the fan sprayed it up there. Tried starter fluid with no luck. Just turns over. Also checked the fuel reset and its normal. Where should I start.
View 14 Replies