Ford Super Duty (1999-2016) :: 2002 F250 - Door Ajar Light Stays On / Power Locks On Driver And Passenger Door Not Working
Vehicle: 2002 f250 xlt 7.3 powerstroke reg. Cab
Issue: door ajar light stays on, power locks on driver and passenger door don't work, radio stays on after truck is off an door is opened.
Events leading up to issue: went to temporarily hook up a wolo dixie horn to see if it worked. Wanted to do it fast so I took + cable, tied one end to the battery terminal and then connected other end to dixie horn relay. I then grounded both negative wires to the truck. One ground on the frame the other I temporarily wrapped around a one of factory ground mounts under the dash. Immediately after doing this the problems stated above started.
How can I fix this. I need to fix this by tomorrow. I have a guy from Craigslist coming to look at the truck. Now the 4x4 issue.
Truck has zf6 manual and the electric 4wd select ****. Just thought I'd list this if it was needed to be known for solutions.
4x4 high light stays on in while 2wd all the time. 4 low will stay on after switching back to 4 high and 2wd but it goes out if I ether stop the truck shut it off then restart it. or back up and slam on the brakes. Also when in 4 high the front driveshaft won't spin. However It will spin when in 4 low.
Another random issue I'd thought I'd just list while I'm writing this.... Cruise control does not work. And when I press the "on" button and the "coast" button at the same time the horn honks.
Ford Super Duty (1999-2016) :: Door Ajar Light Won't Go Off?
It's been happening the last week or so, on and off. I'll open the door and close it and the cab light won't go off and the red DOOR AJAR light on the dash won't go off. The last two times it went off after about a minute. Now I don't care about it in the daytime, but at night it's a real pain. How do these sensors work? I see the little plastic lever on the rear door (ext. cab), but it can happen when I open just one of the doors. Is there a centralized receiver for both the door sensors?
View 3 RepliesFord Super Duty (1999-2016) :: Door Ajar Light Is Illuminated On The Dash
2004, cc/lb 6.0 ... I get in the truck and the dome lights come on, key the ignition and they stay on though they should go off, start truck and they still stay on until I reach 5 mph. Door ajar light is illuminated on the dash. If the truck is off and I open the drivers door, the domes will come on, they will not come on if I open the other three doors. I just replaced the switch on the drivers door and no change.
I held the trip button and started the engine. I kept tapping the button until "door 40" came up. When I opened the drivers door it would change from 40 to CO. When I opened the other doors, it would stay at 40.
I did notice that once I had the drivers door open and completely off the latch and my hands off the door handle, I would move the door and it would then change from 40 to CO. At this point the latch switch is out of the picture. So if i move the door slightly open/close it would switch from 40 to CO when the door is nearly closed. Is there another switch or sensor somewhere near the hinges?
Ford Super Duty (1999-2016) :: 2013 - Driver Door Ajar Warning?
I have a 2013 F350 CC 6.7L Lariat. The last two days I have been getting the Driver's Door Ajar warning coming on every time I get in the truck. Sometimes it will go off by itself, other times it wont. If I lowly push the door shut, just before the door latches completely closed the light will go off. But as soon as the door closes completely the light comes back on.
I tried squirting WD40 in the lock mechanism as recommended in some older posts for other models. No worky! I searched Fordparts.com, but cannot find a listing for the door ajar switch. Where to find the switch for this warning light?
Ford Super Duty (1999-2016) :: Passenger Side Door Ajar Warning
2008 F-350 Reg reg cab .....
All the sudden got a pass side door ajar warning. I tried doing the WD40 trick but its still there. Do I need to change out the entire latch or do they sell just the door ajar switch ....
Ford Super Duty (1999-2016) :: 2003 F250 - Door Ajar Light Stays On When Driving
I bought a crew from a dealer, all the dome lights and cargo lights had the bulbs removed, so i put them back in and of coarse they all stayed on after you close the door, plus the door ajar light stays on when you are driving. I do notice the radio shuts off when you open the door after you turn off the ignition. Does that work on the same door switch, eliminating those?
Also are there switches on the rear doors also? Noticed that the radio isn't effected when you open a rear door. I tried to get the dealer to look at it a day after i took it home, a ford dealer at that, and they told me they tried to figure it out , and couldn't before they sold me the truck. Doesn't say much for their service department.
Ford Super Duty (1999-2016) :: Door Ajar Light Staying On And Radio Not Shutting Off Upon Exiting The Truck
Truck '02 F250 SuperCab - I was having an issue with the door ajar light staying on and the radio not shutting off upon exiting the truck. After having no luck with the WD-40 fix, I replaced the door switch sensor on the driver's side door and disconnected the negative battery cable for a few minutes (maybe 5-10).
Problem solved or so I thought...a few days later (approximately 5) the door ajar light came back on and the radio did not shut off. I disconnected the negative cable and sure enough that fixed it...again The problem is that every few days I have to go thru this. I'm not sure if it's related or not, but the CD player has started giving me "error reading disc" on even brand new CD's.
Ford Super Duty (1999-2016) :: Dome Light Not Working When Open The Door And Ajar Light Is On
My Dome lights don't work when you open the door. I can manually turn them on though. Also door ajar light is on. Are these issues caused by the door latch switch? Also have no fog lights I replaced the switch and bulbs. I have a 2003 F250.....
View 2 RepliesFord Super Duty (1999-2016) :: 2006 - Door Sensor Location?
Where are the door sensors located?
The ones that turn the light and off when you open and close the doors.
It use to be switches on the old trucks and cars.
But on my 2006 F-250 I can find anything that seems to do that function, nor is anything mentioned in the repair manuel.
Ford Super Duty (1999-2016) :: 2002 - Airbag Sensor Location?
Where this sensor is? I am trying to mount a front bar and need to know if I can drill thru the tube behind the bumper ( this is the one that is right behind the plastic trim piece.)
View 2 RepliesFord Super Duty (1999-2016) :: 2002 F250 - Trans Temp Sensor Location
I have noticed my trans temp gauge needle is dead center of the gauge even on a cold start. I thought my sensor was under the pan so I pulled it and did not see any sensor at all. Is there a external sensor?
View 5 RepliesFord Super Duty (1999-2016) :: 2002 - Disable Automatic Door Lock Mechanism?
Can I disable the automatic door lock mechanism? Maybe pull a fuse? All of a sudden the locks start locking and unlocking over and over and the lights dim. I would like to disable the automatic and use the key to lock and unlock the doors. It is a 2002, F-250-Super Duty 4x4 SuperCab.
View 5 RepliesFord Super Duty (1999-2016) :: Transmission Swap Of V10 To 7.3L Powerstroke?
Can I take the tranny out of a v10 and put it in my 7.3L Powerstroke?
Both are 1999 f250's.
From what I've read they should both be 4r100's.
Ford Super Duty (1999-2016) :: Swap F350 V10 Into F450 6.4?
Can an f-450 with a blown 6.4 diesel received an transplant from an f-350 V-10.
How much would need to go over from the f-350 to f-450?
Ford Super Duty (1999-2016) :: 2002 F250 - Dome Light And Door Lock Reversed?
Today I purchased a 2002 f250 GAS super duty 5.4. The first thing I've noticed wrong is: The driver door doesn't lock with the remote control but the passenger door does. I also noticed: when I shut the driver door, the dome light comes on and stays on but when i open the driver door, it shuts off (as if something's reversed). Do you think these two situations are related, and how can I fix it?
View 9 RepliesFord Super Duty (1999-2016) :: Dash Swap 1999 To 2008 Model?
I'm thinking of doing a dash swap on my 99 super duty to the 2008 super duty dash, steering wheel, etc. I know the od in my truck is mechanical and in the new one its electronical is it possible to swap without having to redue the whole electrical system and computer? Is the steering wheel going to line up and the ducting? How should i approach the wiring?
View 14 RepliesFord Super Duty (1999-2016) :: 2002 F250 - Door Open Light On Dash / Locks Not Working
I bought a 2002 f250 Crewcab bout 6 months ago. A couple of months back I noticed that after driving it and turning off ignition and opening door my radio would stay on and doors would not respond to key fob or switch on doors. Eventually it would reset and radio would turn off and key fob would work. It also makes the locking sound when press on brake. It doesn't happen all the time though and that's only issue. Truck is in awesome shape only 106,000 on it, belonged to an old man who only used it to tow camper twice a year. I've read a few posts that have similar problems and have heard could be gem or vsm.
View 2 RepliesFord Super Duty (1999-2016) :: Axle Swap 3.73 To 4.30 In A 2011 F250 6.2?
Love my '11 f250 SD 4WD CC SB. 6.2 with 3.73 e-locker. I've got 5 Star tunes in it, and the truck is a joy to drive empty, and tows my current 7k camper fine, though on steep inclines I wish I had the 4:30 gears.
Well, we just bought a bigger trailer, dry weight is an addtl 2400+ at 9400, so I'll need to do something.
I don't want a different truck, don't want (another trouble-prone) diesel. I think with 4:30s and the tune, I should be fine towing that trailer (with gear and passengers, probably 11-11.5k loaded). Not doing mountains here, just Michigan hills.
What's the best way to "do" a gear swap? I know if I buy a set of gears and a shop screws Em up, it's gonna whine/hum and still cost 2k to do (truck is 4wd)
I'm up in the boonies and finding a shop to swap the gears will be a problem. Getting Em done right will be even MORE trouble.
Can I just find 4:30 axles ans have them swapped (anything in t-case or sensors need to be touched?). I don't care if I lose the e-locker, I never use it.
Ford Super Duty (1999-2016) :: ZF650 6 Speed Transmission Swap?
I own a 1999 F250 sd 5 speed manual, v10. Looking for some specific details pertaining to swapping to a ZF650 6 speed transmission. Any prior example with this swap?
View 8 Replies