Ford Super Duty (1999-2016) :: 2002 F250 - Door Ajar Light Stays On / Power Locks On Driver And Passenger Door Not Working
Vehicle: 2002 f250 xlt 7.3 powerstroke reg. Cab
Issue: door ajar light stays on, power locks on driver and passenger door don't work, radio stays on after truck is off an door is opened.
Events leading up to issue: went to temporarily hook up a wolo dixie horn to see if it worked. Wanted to do it fast so I took + cable, tied one end to the battery terminal and then connected other end to dixie horn relay. I then grounded both negative wires to the truck. One ground on the frame the other I temporarily wrapped around a one of factory ground mounts under the dash. Immediately after doing this the problems stated above started.
How can I fix this. I need to fix this by tomorrow. I have a guy from Craigslist coming to look at the truck. Now the 4x4 issue.
Truck has zf6 manual and the electric 4wd select ****. Just thought I'd list this if it was needed to be known for solutions.
4x4 high light stays on in while 2wd all the time. 4 low will stay on after switching back to 4 high and 2wd but it goes out if I ether stop the truck shut it off then restart it. or back up and slam on the brakes. Also when in 4 high the front driveshaft won't spin. However It will spin when in 4 low.
Another random issue I'd thought I'd just list while I'm writing this.... Cruise control does not work. And when I press the "on" button and the "coast" button at the same time the horn honks.
Ford Super Duty (1999-2016) :: Door Ajar Light Won't Go Off?
It's been happening the last week or so, on and off. I'll open the door and close it and the cab light won't go off and the red DOOR AJAR light on the dash won't go off. The last two times it went off after about a minute. Now I don't care about it in the daytime, but at night it's a real pain. How do these sensors work? I see the little plastic lever on the rear door (ext. cab), but it can happen when I open just one of the doors. Is there a centralized receiver for both the door sensors?
View 3 RepliesFord Super Duty (1999-2016) :: Door Ajar Light Is Illuminated On The Dash
2004, cc/lb 6.0 ... I get in the truck and the dome lights come on, key the ignition and they stay on though they should go off, start truck and they still stay on until I reach 5 mph. Door ajar light is illuminated on the dash. If the truck is off and I open the drivers door, the domes will come on, they will not come on if I open the other three doors. I just replaced the switch on the drivers door and no change.
I held the trip button and started the engine. I kept tapping the button until "door 40" came up. When I opened the drivers door it would change from 40 to CO. When I opened the other doors, it would stay at 40.
I did notice that once I had the drivers door open and completely off the latch and my hands off the door handle, I would move the door and it would then change from 40 to CO. At this point the latch switch is out of the picture. So if i move the door slightly open/close it would switch from 40 to CO when the door is nearly closed. Is there another switch or sensor somewhere near the hinges?
Ford Super Duty (1999-2016) :: Dome Light Not Working When Open The Door And Ajar Light Is On
My Dome lights don't work when you open the door. I can manually turn them on though. Also door ajar light is on. Are these issues caused by the door latch switch? Also have no fog lights I replaced the switch and bulbs. I have a 2003 F250.....
View 2 RepliesFord Super Duty (1999-2016) :: Door Ajar Light Staying On And Radio Not Shutting Off Upon Exiting The Truck
Truck '02 F250 SuperCab - I was having an issue with the door ajar light staying on and the radio not shutting off upon exiting the truck. After having no luck with the WD-40 fix, I replaced the door switch sensor on the driver's side door and disconnected the negative battery cable for a few minutes (maybe 5-10).
Problem solved or so I thought...a few days later (approximately 5) the door ajar light came back on and the radio did not shut off. I disconnected the negative cable and sure enough that fixed it...again The problem is that every few days I have to go thru this. I'm not sure if it's related or not, but the CD player has started giving me "error reading disc" on even brand new CD's.
Ford 7.3L Power Stroke (1999-2003) :: Door Ajar Light Stays On All The Time When Engine Is Running
Here are some signs of the problem.
*Key fob does not work - battery is good.
*Interior overhead light works only on manual.
*Driver's auto door lock (with driver door open) will lock all four doors but the driver's door will automatically open back. To secure the truck I manually lock the driver's door.
*I replaced the driver's door 'ajar switch' with no results. The old switch was good after testing - normally closed until the ball is depressed then it goes to open.
*No codes.
*I just checked all the mini-fuses with a VOM and they are good.
*Could one of the relays be part of the problem?
I am curious if there is a scanner that can identify the bad door ajar switch if any?
From what I have read so far it appears the VSM (Vehicle Security Module) may be bad as a many of these 2002's complain of this problem and the VSM generally solves the issues. Are there folks other than the dealerships that can program the module if I purchase a new one and remove the old OEM one? Other than the inconvenience the truck runs fine other wise.
Ford Super Duty (1999-2016) :: F250 - Brake Light Stays On
The brake light stays on all the time. It started 5+ years ago going out intermittently, then began going out more frequently for longer as the years went by, until now, where it stays on continuously (except for one small miracle where it cam back on during a short drive around town). I don't normally care if it stays on, but for the first time in 7 years I'm going on a long road trip and can not engage cruise control with the light on.
View 9 RepliesFord Super Duty (1999-2016) :: 2005 F250 - ABS Light Stays On
2005 F250 4x4, manual locking hubs, ABS light stays on. Plugged it up, front sensors had a bad signal. Replaced both front sensors, still had light. Pulled out the sensors, cleaned the sensor rings the best we could with a little screwdriver. Installed the sensors, cleared the codes. Drove the truck a few miles, light came back on. Plugged it up, same codes. Removed the sensors and there was grease back on the sensor rings. Cleaned it up again, ran through the motions, drove it, light comes back on. Is there supposed to be grease on the sensor ring? It keeps coming back in every time it is driven. My next guess would be the hub bearings are going bad?
View 4 RepliesFord Super Duty (1999-2016) :: F250 - Parking Brake Light Stays On
I have a f250 super duty. I blew a brake line the main going to the rear. So the genius that I am I replaced the line an simple enough I decide hell why not replace the master cylinder too, so I did an I bleed the brakes an everything works jst fine but now the the brake light won't turn off I have tried everything not sure what could possibly cause the light to stay on. I will eliminate some suggestions, I bleed the brakes, the brake fluid is full, the level sensor is completely attached, the parking brake is not on, I pulled the parking brake completely out, even completely disconnected the sensor thinking it would turn off bu it didn't.
View 1 RepliesFord Super Duty (1999-2016) :: Dome Light Stays On For A Bit Before Shutting Off After Closing The Door
Had this issue for a while, but it doesn't seem to cause a problem. It's more of a curiosity than anything... Most of the time, the dome light operates as usual- close the door and the light stays on for a bit before shutting off. But about a quarter of the time, the light goes off immediately after the door is shut. It's done this the entire time I've owned the truck (about 2-1/2 years). Why?
View 1 RepliesFord Super Duty (1999-2016) :: Dome Light Stays On / No Door Ding / Radio Won't Turn On
I have a 2003 Ford F-450 with the 7.3 Powerstroke. The problem I am having is the dome light stays on, the map lights will not turn on, I have no door ding with the key in the ignition, and the radio wont turn on. If I press the clock button on the radio the clock comes on but the radio will not come on when I press the power button. What it may be? I already hosed the door latches with lubricant and that changed nothing. I checked all the fuses they are good.
View 2 RepliesFord F-150 - 1997-2003 :: Door Ajar Light On - Inside Light Stays On?
when i bough the car i went on a test drive and everything was fine, once i bough it and went home my fiance opened the passanger side door to get in, and every sense than the door ajar light is on and the inside lights will never turn off and its draining down the battery, we have tried slamming the door shut and we just dont know what to do, theres not even a sensor botton to check out theres no way to tell what it could be for me as when i open the door to check out the botton like most vehicles do, there isnt one, what could it be?
View 9 RepliesFord Ranger / B-Series :: 1999 - Door Ajar Light Stays On
In the past week after work the door ajar light comes on and stays on. I've checked all doors and they are not ajar. The dome light comes on when i start the engine and goes off after a few seconds, but only when i have this door ajar problem. After I get home and shut off the engine for about 30 seconds, then restart, the dome light nor the door ajar don't come on.
View 14 RepliesFord Super Duty (1999-2016) :: 2002 F250 - Heat Coil Light Stays On / Sometimes Radio And Windows Won't Work
My 2002 F250 Crew/Diesel/4X4/lariat has ever since I bought it, had an electronic problem.. sometimes I start it, the heat coil light stays on, sometimes the radio won't work, the windows won't work.. then about 2 minutes later, they work, my back up alarm always comes on turned off... sometimes my fuel gauge registers weird, ....
View 1 RepliesFord Super Duty (1999-2016) :: 2013 - Driver Door Ajar Warning?
I have a 2013 F350 CC 6.7L Lariat. The last two days I have been getting the Driver's Door Ajar warning coming on every time I get in the truck. Sometimes it will go off by itself, other times it wont. If I lowly push the door shut, just before the door latches completely closed the light will go off. But as soon as the door closes completely the light comes back on.
I tried squirting WD40 in the lock mechanism as recommended in some older posts for other models. No worky! I searched Fordparts.com, but cannot find a listing for the door ajar switch. Where to find the switch for this warning light?
Ford Super Duty (1999-2016) :: Passenger Side Door Ajar Warning
2008 F-350 Reg reg cab .....
All the sudden got a pass side door ajar warning. I tried doing the WD40 trick but its still there. Do I need to change out the entire latch or do they sell just the door ajar switch ....
Ford 7.3L Power Stroke (1999-2003) :: 2002 F250 - Door Ajar Light Is Lit Up On The Dash
I have a 2002 f250 screw. my door ajar light is lit up on the dash. I have tried the wd40 trick, pulled the sensors and bench tested them. What are the codes the instrument cluster test has for each door?
What I am thinking is, if we get a list posted it would be much easier to diagnose the door sensors for others. there should be a open/closed bit for each door. possibly a code for all doors open too. I am curious if there is a code for bad communication on the VSM.
From what I have read, correctly working the doors should read 00 when they are closed. drivers front open=80, pass front open=40 ... My door code does not change no matter what combination of door open/close I use.
Truck is 2002 f250 crew cab ...
My code is C0 ...
Ford Super Duty (1999-2016) :: 2002 - Can Swap Door Ajar Sensor Polarity?
I bought a 2002 F350 Dually Diesel 7.3L Lariat Crew Cab. I had the famous faulty VSM issue that plagued many a 2002 model. Got a new security module and everything worked just fine... Except for the doors. The door ajar light constantly stayed on. I do NOT want to pay my local stealership $140 to dig for my VSM and reprogram it since pretty much everything else worked plug and play.
Hoping it was the other infamous stuck door ajar sensor issue, I've been making my door lock hinges drunk on WD40 with no positive results. This saddened me. Today, though, I made a interesting observation.
The door ajar light goes OFF when both front doors are OPEN. Back doors have no effect one way or the other. I was thinking if I switch the polarity of the door ajar buttons by just crossing the wires associated, that should fix my problem.
Ford Super Duty (1999-2016) :: 2006 F250 - Dome Light Does Not Come On When Open The Door
I just bought a 2006 F250 Lariat. The previous owner did not have a manual for the vehicle. When I open a door the dome light does not come on. Is it supposed to come on in that vehicle? The exterior light above the rear window that illuminates the bed of the truck does come on when a door is opened so it makes me think that there is a wiring issue with the dome light. I can light the dome lamps with the switches on the lamp housing so I know that it is working and the bulbs are good.
View 8 Replies