Ford Super Duty (1999-2016) :: 2009 F250 - Smoke Coming From Underneath The Truck
Our 2009 F-250 in our signature with 53,000 miles on it recently had a transmission episode that has me concerned. We were towing our fifth-wheel camper which weighs around 9000 lbs. We were nearly home on a 275 mile trip. All interstate at speeds of no more than 67 MPH. As I was in the process of exiting the interstate on the last 12 miles of our journey I noticed some smoke coming from underneath the truck. I immediately stopped and got under the truck and noticed transmission fluid running down from the top of the transmission and dripping onto the crossover exhaust pipe.
I let the truck idle for several minutes and it seemed to stop dripping fluid, or at least it had slowed considerably. I took off again being very careful not to gas it up at all, if fact I was very light footed with it from there on home. The ScanGauge II showed the transmission temp. had never got above 186 all the way home and it was at about 185 at the time I saw the smoke. The ambient temperature was around 90 and the truck had not labored at all on the way home. It would do the usual down shifting at overpasses but since I installed the 4.30 gears it doesn't do all that much shifting with the cruise control set on around 65-66 MPH.
I couldn't see where the oil was coming from but it was toward the top of the transmission. The transmission acted perfectly normal in every way even at the time of the dripping.
As I said, I took it plenty easy all the remaining 12 miles home and the tranny temp. dropped down to around 181. I parked the truck and camper on our asphalt driveway and saw no sign of drippage after it was parked. I fired the truck up the morning after this incident and drove it pulling the camper until the transmission temp. got to 185 and came home and parked it on the asphalt again and saw no signs of any leakage.
I checked the transmission fluid level per the instructions in the owners manual and it appeared to be right up to full. I don't believe it was over full. It smelled like it was new without a hint of any burnt odor. I bought the truck with 31,000 miles on it and had the dealer at which I purchased it change the transmission fluid at that time so it should be in very good condition.
I am going into a very busy time with this truck and can't chance any down time if it can be avoided. According to the research I did at the time I purchased this truck the automatic transmissions Ford used in the 2009 F-250 are pretty much bullet proof if maintained properly and not overly abused. This one has been well maintained and I've NEVER abused it. I wanted a manual trans. at the time I bought this unit but could not find one anywhere. I'm not a big slush-a-matic fan and I sincerely hope this one doesn't make me realize my long standing fear of slush-a-matic transmissions.
Corolla / Matrix 2009-13 :: AC On And Water Coming Out From Underneath Dashboard On Passenger Side
So today I'm out running errands. Its hot and the ac is on. I notice water is coming out from underneath the dashboard on the passenger side. I pull the floor mat and water is everywhere. Soaked!! Ok so the ac water that's supposed to drip outside and underneath the car is now dripping inside the car. I pull off all the plastic crap, glove box to see if I can tell where its coming from. Not seeing it. Also some crap must have gotten wet because my check engine light is on along with a flashing vsr off light.
View 6 RepliesFord F-150 (2009-2014) :: 2011 - Doors On Truck Leaking Water Into The Cab
The doors on my truck were leaking water into the cab due to poorly adhered splash shields on the interior of the doors. The splash shield sits between the door shell and the trim panel.
Signs of the leak are water pooling in the groove in the weather strip at the bottom of the opening. Mine were pooling water at the front of the opening and when the door was opened you could see the water running down from behind the door panel.
If you have a water leak along the door opening on a newer vehicle, make sure your dealer checks for this new TSB. It was supposedly only put out in the last week.
Ford F-150 (2009-2014) :: 2012 - Rusting Out From Underneath
We just sold our 04 Supercrew that was rusting out from underneath itself. I was unsure of what to get next until I drove this 2012 F140 XLT supercrew with the ecoboost. It is in fantastic shape and drive great. It does have 90k on its odometer and I wasn't sure if that should be of any real concern.
It was a one owner trade in and you would never tell the mileage by looking at it. I averaged 5k miles per year for the 5 years I owned my 04 so I don't drive real far. I also tow a 20' ultra lite camper which may get upgraded to a 24' ultra lite in a few years.
I just didn't know if I should be concerned about the high mileage with my driving habits and not driving very much. Do these motors have any maintenance issues? Everything I've read seems to be good....
This story really piqued my interest : [URL] ......
2012 F150 XLT Ecoboost with 90k.....
Ford F-150 (2009-2014) :: 2011 - Rusty Knuckles Underneath
Ok, so I have a brand new 2011 F150 SCrew EB direct from the factory. It's about a week or so old and I have almost 700 miles on it. It is garaged all the time while at home...
So I was looking under the front end just checking things out...getting to "know" my new truck (which by the way I love) and everything looks new and great underneath...nice new painted surfaces...metal etc until I see...the knuckles behind each of the front wheels are starting to rust. I'm assuming these are cast iron but why would they not paint these?!
I mean, everything else is painted and looks great but then you see the rusting knuckles underneath?? AM I missing something here...is this normal? For all of you who own the same truck, have you seen the same thing?
Ford F-150 - 1997-2003 :: 2001 - Strange Rubbing And Whumping Noises Coming From Underneath The Truck
I have strange rubbing and whumping noises coming from underneath my truck. Yesterday I changed the old e-brake and lines, thought it my be rubbing on the wheel. Today I changed the front and rear axle u-joint and rear pinion seal. The front u-joint was ceased and the pinion seal was leaking. I thought this would cure it but the noise is still there , the noise is more pronounced when I make a turn. Besides that the truck runs perfect. This summer I changed all 4 rotors, calipers and pads and ball joints , shocks and muffler. Tomorrow I will jack the front up and check the front, where the noise would coming from.
2001 F150 4X4 7700 ....
Volvo :: Drivers Side Carpet Soaked After Rain - Water Coming From Underneath The Car
After several days of rain I found that the drivers side carpet is soaked. Upon further investigation I realized it was coming from underneath the car rather than from the side. I was able to put my hand under the carpet and feel the metal body underneath. It was soaked. I have never had this problem before and have not been in an accident. The car drives very well and has 130 miles. I recently replaced the transmission and was hoping to have this for a few more years.
View 1 RepliesFord Super Duty (1999-2016) :: 2004 F250 Won't Start - Spraying Noise Coming From Underneath The Truck
I have a 2004 f250 with a 5.4l and it won't start. I went to leave the store and went to start it and the truck started when I turned the ignition on not when I engaged the starter so I drove home anyway but there was what sounded like a spraying noise coming from underneath the truck all the way home the truck did die once on the way home but started right back up without me doing anything. Got home shut the truck off now it won't crank or anything all my lights and everything come on like normal just won't crank. What the problem is?
View 7 RepliesCorolla / Matrix 2009-13 :: 2010 Toyota S - Unbearable Clicking Sound Coming From Underneath Glove Box
There is an unbearable clicking sound coming from underneath the glovebox. Already tried removing blower motor to see if there were mouse droppings, paper bits anything -- it was clean. What this could be?
View 1 RepliesFord F-150 (2009-2014) :: Water In 3rd Brake Light?
I washed my truck for the first time tonight, and while doing so, I noticed what looks like water got into the third brake light on top of the cab. Is that a common issue and is there an easy fix? I've seen foam inside at the very bottom of the light fixture, it kind of looks like there are two housings though, with the foam in between. I checked the inside headliner, and everything there is dry.
View 8 RepliesFord F-150 (2009-2014) :: Water Sloshing Around Inside The Door
Opened one of the rear doors on my crew cab and there must have been several gallons of water sloshing around inside the door. Shook the door a few times and water started draining out both corners of the door seam. After about an hour (I told you it was a lot of water) it seems to have stopped draining. Now I'm wondering how long this has been going on and what the inside of the door looks like by now.
View 6 RepliesFord F-150 (2009-2014) :: 2010 FX4 - Water Leak Through Sunroof
I have a 2010 fx4 150. I have a water leak threw my sunroof?
View 1 RepliesFord F-150 (2009-2014) :: Fan Won't Break Loose When Changing Water Pump
2009 f150 5.4. Replacing water pump and I can't get the fan to break loose. I've broken 2 belt wrenches. I've just sprayed liquid wrench on it .
View 9 RepliesFord F-150 (2009-2014) :: 2011 - A/C Condensation - Water Dripping On The Ground?
On my 2011, I have been running AC in the normal setting and in max setting, but don't get the water dripping on the ground like I am used to seeing, especially with the high heat and humidity. My 2000 truck used to make lots of water and the wife's '09 Flex does too.
Is this normal with the new trucks?
Ford F-150 (2009-2014) :: 2013 FX4 Not Draining Water - A/C Drain Tube?
I just noticed my 13 FX4 isn't draining water, but I checked inside and the carpets feel dry. Maybe I'm just being paranoid but the wifes Jeep always has a huge puddle under it. I'm sure the drain is somewhere under all that silver sound deadener. Is this common?
View 3 RepliesFord F-150 (2009-2014) :: Lowering New Truck
I want to lower my 2014 FX2 supercrew 2/4. Can't seem to find any drop spindles for it. What are you using to drop your trucks. I don't want to change the driving or handling of the truck any more than necessary.
View 14 RepliesFord F-150 (2009-2014) :: Truck Won't Blow Hot Air?
My truck doesn't blow hot air no more, just ice cold, for sure no fun with -15 c the temp. gauge shows that the engine is warm, blower motor works, got coolant replaced last summer...
F150 2009 xlt 5.4L....
Ford F-150 (2009-2014) :: Water Leak In Passenger Rear Corner Of Headliner
My 2014 F150 has been in 5 times now for a leak issue and I'm tired of it. I get a water leak in the passenger rear corner of the headliner that makes a big wet stain in the headliner. It rained all day yesterday and now the drivers side rear is wet. The dealer has resealed the rake light, changed to an "upgraded" gasket, sealed again, sealed the top roof trim, sent the truck out to have the rear window removed and resealed...and its still leaking...if anything worse now.
The gasket Ford uses is clearly not the right answer as it's sub par, and Id rather not use silicon as I've heard it can damage paint and even the metal eventually. Is there a permanent fix for this? I'll do it myself so it just gets fixed right...5 times at the dealer is enough! I'd buy a light like a Recon or something if I knew it would fix this leak issue for good. Wondering what others have done. This is a brand new truck with under 10,000 miles on it and I've been fighting this crap since I had 500 miles on it. It's literally unbelievable!
Ford F-150 (2009-2014) :: Shroud Under The Front Of Truck
So my truck hit 1,000 miles. I decided to change the oil to get the factory oil out and remove any material that may be in there from the break in. I know the motor hasn't fully broken in. My question is what is the purpose of that shroud under the front of the truck? It seems like it can almost get caught on parking bumpers. It also makes it very difficult to get under there and change the oil. I had to go from the side. Need to remove it? It seems to be held by 2 good size bolts by the frame.
View 14 Replies