Ford 6.7L Power Stroke Diesel :: 2014 - Removing Glow Plug Harness?
I'm really struggling to get this sucker off my 2014 6.7 F350
it says in the ford manual to lift the plastic tabs then pull off, I did that easily with 3 on each side, but the end plug on each side (the one closest to the windshield) does not seem to have a liftable tab (it looks different to the others as its at the end of the cable)
I've almost broken it but not quite, its over $300 for new harness, ouch
I do have the odd little hook tool they sell for this, it worked with the other 3 for sure, but I've spent ages on the 4th on each side and cannot budge either of them
Ford Wiring/Electrical :: 1990 F250 Hard To Start - Glow Plug Controller Relay Wiring
I just bought a hard to start 1990 F250. Per the board, just replaced all 8 glow plugs with Motorcraft. Still wouldn't start (it turns over but will only start if you use either). I attempted to install a new BWD brand (Borg Warner I believe) glow plug connector relay today...I removed the old no problem, but am unsure what wires to plug where....the only connection that I'm sure about is the blue wire that works the WTS feature...it plugs in easily but I don't know if there are other connections that need to be made or not? All the wires run from the posts and into the bottom of the unit.
View 2 RepliesPrius (2010-12) :: Corroded A/C Wiring Harness
The AC stopped working on our 1020 Prius. No mechanical problem with the compressor. It turns out that the wiring harness connector to the AC compressor is so badly corroded that the pins are gone. The car has 48,000 miles on it. It has spent it's life in the Seattle area so no harsh weather or a bunch of winter salt on roads to deal with. The dealer says it's due to the humidity here combined with the low miles. The theory is that moisture has the chance to build up in the connection because the car is not driven enough to regularly heat it up and drive the moisture out. Our 2004 Subaru Outback has lived in exactly the same environment since 2004 with pretty much the same rate of miles per year and no electrical issues at all. If that theory is correct, seems like a serious design flaw to me. The dealer's repair estimate is close to $4000!
View 19 RepliesFord 6.0L Power Stroke Diesel :: Leaking Glow Plug Harness Cause Hot No Start
Could a leaking passenger side glow plug harness cause a "hot no start?
View 5 RepliesFord 6.0L Power Stroke Diesel :: 2003 - Leaking From The Glow Plug Harness
Got a 2003 6.0 that seems to be leaking from the glow plug harness. How hard would it be to just replace them? I've heard that trying to remove these things can be a pain because they almost always break. But if I'm just going to replace them who cares right?
Is there anything I need to be careful about? Or can I just rip em on out? Also I've noticed two different styles of harness should I replace mine with the other style or just keep it the same? And yes those valve cover nuts are loose. I'm aware
Ford Wiring/Electrical :: Moving Engine And Ignition System - Wiring Harness For Further Use?
I plan on moving the engine/drivetrain from my 1986 F350 460 to my 1996 F250. I also want to move over the 1986's ignition system with a Duraspark 2 setup.
Although I could just cut in the easiest places to remove the wiring for later reuse I am looking for where to make the cuts, what to take and what to scrap. Alternatively I am also asking if there are aftermarket or OEM replacement sets out there are aren't a ton of money. The current harness in the 1986 has been sprayed with engine oil and cooked for 27 years so I am looking at alternative options if there are any.
Ford F-150 (2009-2014) :: 2013 - Install Wig Wag Flasher Kit?
Looking for some information on best way to install my wig wag flasher kit? I've attached the directions that came with it but it seems too plain to me. No, I'm not very mechanically inclined but looking to do this myself. The product is Galls Wig Wag Flasher With Built In Switch...
View 2 RepliesFord F-150 (2009-2014) :: How To Install Sub And Amp On Stock Head Unit
I took my sub and amp out of my SD when i traded it in and I want to put it in my new truck but it has a stock head unit... I am not wanting to put a new deck in so I am curious how to do this with the stock stereo. I have a 2012 f150....
View 14 RepliesFord F-150 (2009-2014) :: Changing Wiring From 4 To 7 Wire?
I purchased a trailer recently and decided to change the wiring from 4 wire to a 7 wire. I matched up one for one and blew a fuse on the truck. Looking at my manual there are a number of fuses related to the towing or trailer hitch wiring.
View 3 RepliesFord Excursion :: Under Dashboard Wiring Harness?
Early 2000 vs 2001? Looking for info on replacing wiring harness under the dashboard?
Is there enough clearance to pull the harness without removing the dashboard?
Ford F-150 (2009-2014) :: 2011 Ecoboost 4x4 Wiring Schematic?
Need excess to a wiring diagram schematic for a 2011 f150 ecoboost 4x4 as I need to check what powers up the dash on the 2011 ecoboost as well as other wiring, I have one that had damage on the front end with the battery exploding everywhere, the truck did run and drive and the only difference between than and now was that it was water washed under the hood to clean off the battery acid, it did run shortly after it was washed, but after repairs it will not start, as in not turn over the starter and not power up the dash, its as if there isn't any power coming up to the dash as the dash will not light up or power up the gauges when the key is turned on, or it's not recognizing the key. We took it to a ford dealer to scan it and the tech said it would not link to the OBD scanner and said to check for power at the computer and if there was power that it might be the PCM, we have put in a new PCM, no difference, changed out the BCM (fuse box on right kick panel), no difference, we took the under hood wiring out/untapped it all and checked for damage, no damage, still nothing...
View 5 RepliesFord F-150 (2009-2014) :: 2012 - Wiring Diagram For 4X4 Switch
Looking for the wiring diagram for the 4X4 switch that is connected to the back on of the coin holder on a non-4X4? It is an 8 pin plug but only has 5 wires connected to it on my 2012. Can you get 12V switch power here?
View 2 RepliesFord 6.0L Power Stroke Diesel :: Disable Glow Plugs While Testing Trailer Wiring?
I drained my batteries enough that I needed a jump after the last time I was troubleshooting trailer wiring, since I keyed on a bunch of times. What fuse or relay do I need to pull out next time? I'm thinking of pulling fuse 302, HFCM relay (or fuse 7 in the disto box under hood) to disable the fuel pump, but what fuse or relay is for the glow plugs?
View 2 RepliesFord F-150 (2009-2014) :: 2011 - Ecoboost Wiring Rear Lights
2011 f150 super cab eco boost rear wiring?
View 1 RepliesFord Excursion :: 2002 7.3L - Wiring Harness For Brake Controller
I am going to be pulling a trailer next week. I bought a raybestos voyager XP controller. I expected it to be plug and play but what I got was four wires. I have heard that there is a plug ready under the dash to plug a controller into directly. I found a gray pigtail with male ends. Is this it? Should I take controller back and get one with the correct plug or is there a harness one can buy or is a stop to my local ford dealer in the future.
View 5 RepliesFord 6.7L Power Stroke Diesel :: Cab Light Wiring Harness PN?
Need to know the Ford part number for cab light wiring harness? I am wanting to install some LED cab lights but I do not currently have any so I will need the wiring harness.
View 3 RepliesFord Excursion :: 2005 - Extra Wiring Harness Under Radiator
This is on my 05. I assume its for fog lights. Is that correct? If so, where is the fog light switch? I don't have one near my headlight switch. Is this one of those things where everyone gets the harness, but the option is only on the switch if equipped?
Here is the harness....
Ford A/C :: 1997 - Climate Control Unit - Wiring Harness?
Looking for wiring diagrams for a 97 gran marq. Specifically I want to hotwire, the climate control , to give me heat and defrost for more then 2 minutes an hour. I've got the climate control unit out of the dash, and the relays click just before the heat comes on for a few minutes. Of course that was an invitation to smack things with the screw driver. OOPS If there are no heater fuses hiding, besides the ones over the parking brake, I've now also destroyed the unit. Blocks of wood on the vacumm actuators, and wiring the fan direct will work with my unemployment check just fine. BRrrrrr it cold in the car...
View 2 RepliesFord F-150 (2009-2014) :: Interior Wiring - High Beams And Reverse Lights
For my 2013 with HID lights, I'm adding a light bar, and trying to find a good wire to tap into so I can wire in a relay to turn the light bar on with my high beams. As it's going to a relay, I originally thought to use a fuse tap, but the high beam fuse is always powered. Any other wire I can use in the cab?
I'm also looking for an in cab wire for the reverse lights I'm adding. I've been trying to make sense of the wiring diagrams online, but I am not having any success.