Ford - Ranger :: 2004 - Low Pitch Clunk Through The Steering Wheel
I own a 2004 Ranger 4x4 V6 4.0 Liter engine with 118,000 miles. This summer it has been experiencing a clunking/knocking noise for the first time. The noise only happens during days where temps are above 90 degrees and I've been driving for at least 10 minutes. I can hear and also feel the low pitch clunk through the steering wheel. It is more pronounced if I hold the bottom of the steering wheel. I park on concrete and have not seen any fluid leaks under the engine. The power steering fluid is not low. I've jacked up the truck to test tires. The tires do not wobble. A Ford mechanic has inspected the suspension and cannot find anything wrong. Of course when I took the truck to the mechanic is was a cooler morning.
View 8 RepliesFord F-150 (2004-2008) :: Engine Knock / Clunking Noise When Come To A Stop Or Takeoff Or Steering
I am having a hard time locating a mechanical knock coming from my truck. This is not an engine knock but rather a clunking noise when I come to a slightly abrupt stop and sometimes when I take off or am steering. I have recently replaced my upper and lower ball joints and all the u-joints as well. My truck has a 6" Fabtech Coil over lift and a 3" body lift. The truck is also rather squeaky when going over speed bumps.
View 8 RepliesFord F-150 (2004-2008) :: Clunk From Front End On Bumps
I have a 04 4.6 f150 4x4. I have had some off road wear on the truck but put a stop to it here recently. I have replaced ball joints , struts , sway bar linkage , hubs , and now have a clunking sound going over every bump no matter the speed. Everything is tight underneath while stopped, other than the front driveshaft. It seems to have too much play to me? What it could be ???
View 8 RepliesFord F-150 (2004-2008) :: Under Powered / Clunk When Accelerate
I've got a lifted 2006 F150 crew cab lariat and I understand mileage is poor 10-11 per mile. 35" tires under a pro comp 6" lift. I have changed out my plugs twice last year and am still very under powered. What else can i do? I also have a clunk when i accelerate, sound like the rear end or drive line possibly. Had my transfer case replaced recently by ford and don't remember the noise prior.
View 11 RepliesFord F-150 (2004-2008) :: Tranny Clunk While Going In / Out Of Overdrive
Well this weekend I'm doing quite a bit of work to the truck. My tires and exhaust got delivered last night, now I'm just waiting on the leveling kit. Here's my issue:
For a little while now (5k-ish miles) going in and out of overdrive the tranny makes a clunk noise during the shift. Time to change the tranny fluid and filter? I am making a trip up north on Sunday and don't want to have the tranny the bed on the way.
On saturday I am doing the leveling kit (2"), brakes, exhaust (MBRP), and new tires (325/60r20 Terra Grapplers). Should I go ahead and do the tranny fluid and filter while I'm at it, or just wait till I get back. I am figuring on about 2k miles throughout the trip.
IS F (2008-2014) :: 2011 - Clunk / Tapping Noise When Full Steering At Slow Speed
Just like the tittle says. My 2011 ISF with 56k miles on it is making a Clunking noise when pulling out of a parking spot or just anytime I fully steer to the left side and begin to move. If I try it in reverse it doesn't matter if I turn the steering wheel fully to left or right it makes the same noise as I begin to move at slow speed. It almost feels like something is pushing the front wheels out. During normal driving I don't feel anything at all, just as steady as solid the car can be.
Is there any common issues with ISF with premature wear of ball joints, cv joint, sway bar bushings or hub bearing?
Ford F-150 (2004-2008) :: Loud Clunk Feels Like Tire Comes Off The Ground
I have a 2004 f150 4x4, When I put it in four wheel drive everything fine until I make a sharp turn. It's not a little wheel hop its a loud clunk that feels like the tire comes off the ground. I changed the cv axle from the side that seemed to be doing it but it didn't work. Could it be the actuator?
View 1 RepliesFord F-150 (2004-2008) :: Clunk / Bump When Takeoff From Dead Stop
As I said when I take off from a dead stop I can feel a clunk or a bump that feels like it is coming from the rear wheels. I can feel it more than I can hear it, although I can hear it a little. It is difficult to describe this. It is only for a second and kinda feels like the rear wheels have no traction then it bumps and takes off. If I ease into the accelerator I can avoid it, but I don't have to hit it real hard at all to get it to do it. I am sure it is not u-joints as I put a brand new drive shaft from driveshaft specialist on in the spring.
View 3 RepliesFord F-150 (2004-2008) :: 2005 - Clunk Noises Several Times When In 4 Wheel
My 2005 150 4X4 made a "clunk" noises several times when in 4 wheel this last weekend.
Sounded like the transfer case wasn't fully engaged.
This was after doing numerous 3 point turns on a dead end road to turn around. A real nightmare, cliffs on one side mountain on the other.
when we got back to relativity flat ground it ran fine with no more "clunking" noises.
It has 95K of hard miles on it. We didn't want to get stuck out of cell phone range, so we headed home.
Ford F-150 (2004-2008) :: Intermediate Steering Shaft Replaced - Hard Steering
Replaced the Intermediate Steering Shaft at 114,000 miles. Symptoms felt like power steering going out but no pump noise or low fluid. Steering became hard to turn and it sometimes felt like a tie rod was letting go.
Temporary resolution was to spray the two steering shaft joints with penetrating oil (PB Blaster). That freed them up pretty well. Then I ordered Dorman part 425361 (425-361) from Rock Auto. Simple enough job. Lots of good vids on YouTube.
I don't recommend spraying the steering shaft joints as preventative maintenance. Penetrating oil will get into the needle bearings and break down the bearing grease. That will cause the joints to fail over time.
Two side benefits, the truck steering is much smoother and small road bumps and potholes are much less noticeable. Feels like it was when new.
Ford F-150 (2004-2008) :: Loud Clunk / Clank From Rear If Accelerate Quickly
I drive a 2006 F-150. I'm new to the forum and already found some good info on the annoying tick coming from my 5.4.
I have recently purchased a ski boat and lately when towing my boat and coming to a stop I feel as light movement coming from the rear of the truck that feels like something slides forward slightly. When I accelerate "it" slides back and if I accelerate quickly, "it" makes a loud clank noise.
I have ruled out hitch, receiver, ball, anything from the boat/trailer etc... It is coming from the transfer case/ spare tire area under the truck and it only appears to do it (or to where it is noticeable) while towing the boat.
Ford F-150 (2004-2008) :: Steering Shimmies Really Bad
I have a 2004 f 150 heritage 4.6 liter triton supercab long bed and the steering shimmies real bad. When sitting at a stop light you slightly turn the steering wheel and its like the wheel fires back the opposite way when turning at highway speeds you cant hold the wheel from shaking its scary...
View 4 RepliesFord F-150 (2004-2008) :: Vibration In Steering Wheel?
I have a 04 stx f-150 4x4, had the front springs changed, shocks and struts! now when I am driving at either 43mph or 53 mph, I get vibration in steering wheel.....
View 6 RepliesFord F-150 (2004-2008) :: 2006 - Vibration In The Steering
I have an 06 4x4 lariat 4dr. 5.4L.... bought it used about 6 months ago with 107 K on it, and put a few thousand miles on it. haven't really had any problems with it, but I have noticed that when I break about 45 mph, my steering wheel gets shaky, I've tried reading on some forums but haven't really found anything very useful, and I alot of the information is on the '04 models. And honestly I"m just not really sure what to make of it all, and I don't wanna start replacing random stuff just taking a guess. I live in south texas at the moment and the air here it's salty, so I'm hoping that something just corroded and is warn...My guess is a front bearing.
View 8 RepliesFord F-150 (2004-2008) :: Squeaky Steering Wheel?
I have had some play in the steering wheel of my '04 F150 screw 4x4 for a long time. Today, I replaced the outer tie rod ends in order to get rid of a squeak. While I was down there, I tried to move the inner tie rods in and out and didn't detected any movement so I figured they were still good.
Now that the new outer tie rods are in place, my squeak is much better but I am still noticing play in the steering wheel. Assuming that I checked the inner tie rods correctly and that they are indeed ok, and assuming my new outer tie rod ends are good, why would I have any play at all in the steering wheel?
Ford F-150 (2004-2008) :: Steering Wobbly Offset
I have a 2004 f150 heritage Super Cab Xlt with the 4.6. It has a fabtech 6' suspension lift on it. And 315/75/16 BFG A/T KO tires. I replaced inner and outer tire rod ends. Steering Box and idler arm. Replaced rotors and brake calipers on the front and brakes. Replaced rear rotors and rear brake calipers.
Now to the point. Lets say the road steers to the left. I have to steer the wheel to the right ad left in order to stay within means of the lane and stay straight. If I am driving on a straight road I always have to have my steering wheel held to the right in order to stay straight. So lets say the road starts turning left. I have to keep the steering wheel held to the right then slightly left.
But I can't just steer the wheel left or right. It seems that it has to be a special way of steering the truck. I have had tires rebalanced and many shops have said the truck is within alignment specs. It always seems that the steering wheel has to have a offset. Could something else be wrong with the truck ? frame ? u-joints ? Steering wheel column ?
Ford F-150 (2004-2008) :: 2006 - Steering Started Going Stiff?
So I have a 2006 f150 a wile back the steering started going stiff when I would come off the highway. so after some forum searching, I decided to buy a new steering shaft to repace the universals that see up. then the pump started squealing when we turned befor I could install the new shaft. so I replaced the pump and didn't put the new steering shaft in yet. now when I rev the motor past 2000 RPM the pump wines like when you turn the weeks to far to one side on an old truck and it is still stiff when I come off the highway. Could this be the rack
View 14 RepliesFord F-150 (2004-2008) :: FX4 - Steering Wheel Shake After Lift
I have a 2004 fx4 supercrew 4x4 , 170k miles. I bought it a few months ago and installed a 6" rough country lift and 35" tires. I noticed a little shake in the steering wheel but not too bad, just annoying. I just put on a fabtech dual steering stabilizer to remedy the problem and its much worse. What could be at fault that dual stabilizer would make it worse? I hate to just take them off, I would rather find the problem. Oh, the tires are all balanced and I had an alignment done also.
View 14 RepliesFord F-150 (2004-2008) :: 2006 - Steering Hangs Up When Turning
I have an 2006 Super Cab that has 72,000 miles on it. Stock everything except for Magnaflow exhaust and Hankook Dyna Pro tires. Last month I noticed some weird "hang" ups with the steering when turning and it just seemed to be a bump or something while turning. I was gone on vacation last week and started the truck after a week of sitting and the steering acted like it was binding or hesitating. It almost felt like a tire was down, got out and check pressures, everything was good (high if anything and got it to the right pressures).
After driving it got no better potentially worse. I start a turn and it is fine but at a certain degree it starts to bind and seems like the power steering is not there. It does not return to normal position easily either. I have checked the fluid and it is fine, the belt is normal (and original) with no tears, or rips in it. Not sure where to start, but have a couple thoughts of power steering pump going or front end has issues? Best description of the problem is that it is a binding feel and happens both left or right turns. Have to force it like the power steering is out.