Ford F-150 (2004-2008) :: Intermediate Steering Shaft Replaced - Hard Steering
Replaced the Intermediate Steering Shaft at 114,000 miles. Symptoms felt like power steering going out but no pump noise or low fluid. Steering became hard to turn and it sometimes felt like a tie rod was letting go.
Temporary resolution was to spray the two steering shaft joints with penetrating oil (PB Blaster). That freed them up pretty well. Then I ordered Dorman part 425361 (425-361) from Rock Auto. Simple enough job. Lots of good vids on YouTube.
I don't recommend spraying the steering shaft joints as preventative maintenance. Penetrating oil will get into the needle bearings and break down the bearing grease. That will cause the joints to fail over time.
Two side benefits, the truck steering is much smoother and small road bumps and potholes are much less noticeable. Feels like it was when new.
Ford - Crownvictoria :: 1994 - Shimmies When Accelerating At 35 Mph
I have a 1994 Automatic Ford Crown Victoria with apx. 120,000 miles (the odometer stopped working about 20k miles ago, what can ya' do).
Recently it has started doing a subtle vibration/shake/shimmy when accelerating from (I believe) 1st to second gear at about 35 mph. It doesn't happen when decelerating, and i think it might happen the same way at around 65 mph...not always though. It isn't a rough vibration, but it lasts for about 3 seconds. it is definitely coming from the engine, it isn't the tires or brakes
Ford - F350 :: Shimmies And Shakes When Turn Right At Speeds Greater Than 40 Mph
My 1996 Ford F350 front end shakes like crazy when I turn right at speeds greater than 40 mph. It does not shake when turning left. To stop the shake I slow down past 25 mph and speed back up after I have straightened the truck out. What is going on?
View 1 RepliesFord F-150 (2004-2008) :: Vibration In Steering Wheel?
I have a 04 stx f-150 4x4, had the front springs changed, shocks and struts! now when I am driving at either 43mph or 53 mph, I get vibration in steering wheel.....
View 6 RepliesFord F-150 (2004-2008) :: 2006 - Vibration In The Steering
I have an 06 4x4 lariat 4dr. 5.4L.... bought it used about 6 months ago with 107 K on it, and put a few thousand miles on it. haven't really had any problems with it, but I have noticed that when I break about 45 mph, my steering wheel gets shaky, I've tried reading on some forums but haven't really found anything very useful, and I alot of the information is on the '04 models. And honestly I"m just not really sure what to make of it all, and I don't wanna start replacing random stuff just taking a guess. I live in south texas at the moment and the air here it's salty, so I'm hoping that something just corroded and is warn...My guess is a front bearing.
View 8 RepliesFord F-150 (2004-2008) :: Squeaky Steering Wheel?
I have had some play in the steering wheel of my '04 F150 screw 4x4 for a long time. Today, I replaced the outer tie rod ends in order to get rid of a squeak. While I was down there, I tried to move the inner tie rods in and out and didn't detected any movement so I figured they were still good.
Now that the new outer tie rods are in place, my squeak is much better but I am still noticing play in the steering wheel. Assuming that I checked the inner tie rods correctly and that they are indeed ok, and assuming my new outer tie rod ends are good, why would I have any play at all in the steering wheel?
Ford F-150 (2004-2008) :: Steering Wobbly Offset
I have a 2004 f150 heritage Super Cab Xlt with the 4.6. It has a fabtech 6' suspension lift on it. And 315/75/16 BFG A/T KO tires. I replaced inner and outer tire rod ends. Steering Box and idler arm. Replaced rotors and brake calipers on the front and brakes. Replaced rear rotors and rear brake calipers.
Now to the point. Lets say the road steers to the left. I have to steer the wheel to the right ad left in order to stay within means of the lane and stay straight. If I am driving on a straight road I always have to have my steering wheel held to the right in order to stay straight. So lets say the road starts turning left. I have to keep the steering wheel held to the right then slightly left.
But I can't just steer the wheel left or right. It seems that it has to be a special way of steering the truck. I have had tires rebalanced and many shops have said the truck is within alignment specs. It always seems that the steering wheel has to have a offset. Could something else be wrong with the truck ? frame ? u-joints ? Steering wheel column ?
Ford F-150 (2004-2008) :: Clunk From Steering Box Only With Engine Off
Yesterday my 5 year old daughter was "driving" my 07 S-cab 4x4 while I was installing steps on the rocker panels. (yes the engine was off and E-brake on). Anyways as she was steering rapidly from R-to L ther is a noticeable steel-to-steel banging coming from the box area. I could feel it too in the steering.
I started the engine, and steer R-to L, and no more clunk. Shut it down and there it is again. It goes down the road very nicely with no issues. Is this a "normal" situation, A "clunk,, clunk, clunk" when steering back and forth with the engine off, or is something need attention?
Ford F-150 (2004-2008) :: 2006 - Steering Started Going Stiff?
So I have a 2006 f150 a wile back the steering started going stiff when I would come off the highway. so after some forum searching, I decided to buy a new steering shaft to repace the universals that see up. then the pump started squealing when we turned befor I could install the new shaft. so I replaced the pump and didn't put the new steering shaft in yet. now when I rev the motor past 2000 RPM the pump wines like when you turn the weeks to far to one side on an old truck and it is still stiff when I come off the highway. Could this be the rack
View 14 RepliesFord F-150 (2004-2008) :: FX4 - Steering Wheel Shake After Lift
I have a 2004 fx4 supercrew 4x4 , 170k miles. I bought it a few months ago and installed a 6" rough country lift and 35" tires. I noticed a little shake in the steering wheel but not too bad, just annoying. I just put on a fabtech dual steering stabilizer to remedy the problem and its much worse. What could be at fault that dual stabilizer would make it worse? I hate to just take them off, I would rather find the problem. Oh, the tires are all balanced and I had an alignment done also.
View 14 RepliesFord F-150 (2004-2008) :: 2006 - Steering Hangs Up When Turning
I have an 2006 Super Cab that has 72,000 miles on it. Stock everything except for Magnaflow exhaust and Hankook Dyna Pro tires. Last month I noticed some weird "hang" ups with the steering when turning and it just seemed to be a bump or something while turning. I was gone on vacation last week and started the truck after a week of sitting and the steering acted like it was binding or hesitating. It almost felt like a tire was down, got out and check pressures, everything was good (high if anything and got it to the right pressures).
After driving it got no better potentially worse. I start a turn and it is fine but at a certain degree it starts to bind and seems like the power steering is not there. It does not return to normal position easily either. I have checked the fluid and it is fine, the belt is normal (and original) with no tears, or rips in it. Not sure where to start, but have a couple thoughts of power steering pump going or front end has issues? Best description of the problem is that it is a binding feel and happens both left or right turns. Have to force it like the power steering is out.
Ford F-150 (2004-2008) :: Changing Power Steering Pump?
Ok, my next job is replacing a very rusty power steering pump, don't want and unplanned failure. (06 f150 5.4 XLT)
View 4 RepliesFord F-150 (2004-2008) :: Tight Steering When At Low RPMs Or Not Moving
I've got an 08 F150 and the steering has gotten tight when at low rpms or when not moving. The pump's whining and laboring. Fluid is clean and full.
View 3 RepliesFord F-150 (2004-2008) :: Tight / Stiff Steering At Times?
So our 2006 f150 fx4 has been having an issue with stiff steering... at times like it doesn't have power steering at all.
We recently had the lower ball joints on both sides replaced. Before that the upper control arm on the drivers side was also replaced.
There are days that it is better... other times not so much.
Ford F-150 (2004-2008) :: Steering Wheel Tends To Shake A Little Bit When Driving Down The Highway
As I'm driving down the highway my steering wheel tends to shake a little bit. My tires are fine but are offly loud . They are balanced and all but just sound loud u can hear them rolling inside the cab sounds maybe like if I had mud tires but I don't they are all terrains. . I was told maybe the bearings but I don't know.
View 1 RepliesFord F-150 (2004-2008) :: Adding Stereo Controls To Steering Wheel?
I would like to add the stereo controls to my steering wheel. From what I gathered it can be done by just buying the buttons and the taking it to the stealership to flash the computer to get them to work? BTW This is on my 06 XLT Scab.
View 1 RepliesFord F-150 (2004-2008) :: Steering Click When Sitting Still With The Wheel Straight
Got my 2007 XLT Screw here, love this truck, not one problem with it since i got it. but i have started to hear and feel a noise.
I have a click sound and slight click feel in my steering wheel. This happens when I am sitting still with the wheel straight, and i just slightly rock the steering wheel back and forth. If i turn the wheel a full turn left or right then rock the steering wheel back and forth I don't get the sound or feeling. Also if I am cruising down the road and rock the wheel back and forth slightly I don't get it.
This is something between the steering wheel and the firewall. I checked all steering shafts and all suspension from the firewall down to the wheels. So that at least make me feel better that I am not dealing with one of those steering shafts or a suspension repair.
Ford F-150 (2004-2008) :: 2006 - Hard Steering / Heavy Feel
I've got an '06 F150 and the steering isn't right with it. It has had a heavy feel and is almost like the power assist is only working half as good as it should. It's been like this for a couple months. I 've had all four ball joints and the steering rack replaced in the last month. It had the heavy steering feel before and after everything was replaced. It also doesn't recover itself on sharp turns, I have to turn the wheel back as I complete the turn. Could it be the power steering pump? I thought it was a mechanical device and it either worked or it didn't, maybe they get weak?
View 14 RepliesFord F-150 (2004-2008) :: Slight Vibration In Steering When Turning The Wheel To Right
It feels like I am having a front bearing issue, when turning the steering wheel to the right I feel a slight vibration in the steering, need to know which one is going out,??? I have already replaced the passenger side twice It just seems to not tighten completely as I can still move the tire slightly while up on a jack...
View 12 Replies