Ford F-150 (2004-2008) :: Buzzing Noise Coming From Fuel Pump But Not Enough Power To Turn Over
I have a 2005 F-150 supercrew 4.6L with appx 127,000 miles on it. Back in December i took the family to a drive in movie and left the ignition turned to the on position. I jumped the battery and drove a few miles home. The next morning when i tried to start the truck it would not turn over. There was a buzzing noise coming from the fuel pump but not enough juice to turn the truck over. This has happened a few times in the last couple of months but will jump and run fine for weeks at a time. I've taken a 2500 mile round trip to Texas with no issues. I took a 200 mile trip this past weekend and now it will not start. I'm thinking it could be the fuel pump relay? I went to the parts store and bought a relay but it's not the same size as the one in my Haynes Manual. The part from the store is the same size as the bigger relays in the kick panel fuse box but does not match any of the plugs. According to my manual the fuel pump relay should be a smaller relay.
View 4 RepliesFord F-150 (2004-2008) :: 2006 Truck Making Noise That Is Coming From Engine
My 2006 f150 was making a noise that's coming from the engine. It sound like rocks in the engine. When I'm going 50-60 MPH the engine starts to make a sounds like rocks in the engine. What's happening. When I go about 40 it stops.
View 12 RepliesFord F-150 (2004-2008) :: 2006 - Grinding Or Whirring Noise Coming From Front Passenger Side Wheel
I owned a 99 f250 a little while ago. Just bought a 2006 crewcab F150 xlt about 2 months ago, and for the past month there has been this unusual grinding or whirring like noise coming from the front passenger side wheel.
I took it to the mechanic and he found a bad wheel bearing on drivers side and replaced it but that wasn't the issue. He could hear the noise but wasn't able to figure out what the actual issue was.
The noise only happens when my foot is on the throttle. (not when coasting) and i also just discovered that it doesn't make any noise at all when put in 4x4.
Ford F-150 (2004-2008) :: 2006 - 4x4 Light Not Coming On
just picked up a high mile f-150. (146,000) 4x4 light not coming on. jumpered out the vacuum solenoid first, nothing. Then found out I could try to tap on the actuator motor at transfer case. It worked. Just wondering if i keep exercising the actuator motor, if it will continue to work, sounds like the previous owner did not put it in 4x4 for a long time. also, if needed, where is a good place to purchase the replacement actuator motor? If this truck has heated seats ( it is a lariat) , where is it controlled from? Seems to ride a little rougher than i expected. new tires, but it seems a little harsh. I have an f-350 as well. it seems to ride just about as good.
View 2 RepliesFord F-150 (2004-2008) :: 2006 - Small Shutter Coming From Rear End Every Now And Then
OK so I noticed the last few weeks that I have just a small shutter coming from my rear end every now and then. It feels like it locks up for just a sec and then is fine. It will normally do this earlier in the day and maybe once or twice. Is this telling me its time to add some more friction modifier into the rear diff or do I have another issue. I don't notice it once the truck is warmed up and been driving around some.
2006 F150 Screw Fx4
Ford F-150 - 1997-2003 :: Mechanical Buzzing Noise Is Coming From Under The Wipers
I was warming my truck up this morning and I turned my wipers on to get the bit of snow on my windshield off. The wipers moved a few inches, stopped, and a mechanical buzzing noise is coming from under the wipers. I can move the wipers with my hand and they'll go all the way up and return to the bottom, but do the exact same thing when they move again. I searched the forum but can't find anything about the wiper problem I'm having. I also see a lot of discussion about GEM in relation to wipers...
View 13 RepliesFord F-150 (2004-2008) :: 2006 4x4 Light Not Coming On - Actuator Motor Sticking
Just picked up a high mile f-150 (146,000) 4x4 light not coming on. Jumpered out the vacuum solenoid first, nothing. Then found out I could try to tap on the actuator motor at transfer case. it worked,. Just wondering if i keep exercising the actuator motor, if it will continue to work, sounds like the previous owner did not put it in 4x4 for a long time. Also, if needed, where is a good place to purchase the replacement actuator motor? If this truck has heated seats ( it is a lariat), where is it controlled from? .... Seems to ride a little rougher than I expected. New tires, but it seems a little harsh. I have an f-350 as well. It seems to ride just about as good.
View 3 RepliesFord F-150 (2004-2008) :: 2006 Truck Won't Start - Squealing Coming From Under The Hood
I went for a tour with my truck and everything was fine, 5 minutes before getting home I heard a squealing coming from under the hood, I then lost all my gauges inside the truck. The truck didn't shut off so I drove it home. when I shut it off I tried restarting it and it wouldn't even roll over. I tried boosting it and it still won't even crank over.
View 1 RepliesFord F-150 (2004-2008) :: 2006 STX - Oil Leak Coming From Where Transmission Connects To Engine
2006 STX 4.6 .... I recently changed my oil a couple of weeks back. I've noticed spots of oil on the driveway. I thought it may be coming from the oil pan drain plug but i checked it and it seems to be coming from where the transmission connects to the engine. Lotta oil on the bell housing. That's where it looks like it's dripping off of. Could it be the rear main seal?
View 1 RepliesFord F-150 (2004-2008) :: Popping Noise Coming From Front End
Alright, so about a month ago I was driving when I heard a terrible noise sounded like a pop can stuck between a bike tire coming from the front end. I figured this was the dreaded noise most folks hear when the 4wd system isn't getting enough vacuum.
It did this for about two days, even after replacing the IWE solenoid, then it just stopped and I haven't heard it since. Me being on the cautious side, I'm a bit worried. I haven't jacked the truck up, but I did (brace yourself) lay under it while my buddy drove slowly over, there was no unusual movement.
Question is, if I had to replace anything, what exactly would it be and how much am I looking at? My warranty will be up in about a month or so and Ford has been less than spectacular with repairs thus far so I'd like to go ahead and fix it myself
Ford F-150 (2004-2008) :: 2006 - Steering Wheel Gets Loose For A Split Second When Coming Onto Bridges And Off
I purchased a 2006 Lariat crew cab 4x4 back in early feb... since then, I've been on the Interstates a little more than usual ( traveling back home.. dad had a surgery 3 hours away) . . . anyway, the truck gets kinda loose feeling when coming onto bridges and off of them, almost like the back end is swaying and the tires are leaving the ground in the front.. my steering wheel gets loose for a split sec. When I bought the truck I wrote this off as bad tires.. it had some over inflated BFG stock looking tires and where too small.
now, I have new wheels and new tires one size up on the tire. While the ride is great off any bumps.. the second I hit a bump it gets squirmy... I had a guy look at the shocks, he said the seemed ok.. could it be possible to have the wrong shocks on ?
My 2004 crew 4x4 did not do this.. so I know its not a characteristic of the truck. Tired of feeling like I am driving on ice... which is how I lost my 04. My first guess was the Shocks... I bought a level kit for my 04 and never got to put it on... so, it may work out to replace them while I am at it.
Prius (2004-09) :: 2006 Engine Noise - Loud Fan Like Buzzing / Especially Loud On Highway
For the past few months I've been hearing a loud fan-like buzzing noise coming from the passenger side of the front of the car. I don't know that much about cars, but it almost sounds like the engine is racing or something is spinning too fast. It has gotten increasingly worse, and seems especially loud at high speeds on the highway.
It is not the heating/cooling fan - the noise is present when the heating/cooling system is turned off.
Ford Wiring/Electrical :: F250 - No Power / Loud Buzzing Noise Coming From Under The Dash
Tried to start my truck after sitting for 2 days in sub zero weather. wouldn't crank. pulled the batteries and charged them over night. Tried to start it the next day-wouldn't crank but the starter relay clicked. Was going to pull the starter and check it but decided to replace the relay first. replaced it and tried to start but now have no power to the cab-nothing comes on. I've checked the batteries with a load tester and they are ok. I've checked the fuses and they seem to be ok. when I tried to start it and the relay clicked there was a loud buzzing noise that seemed to be coming from under the dash. it has done this before but this time was louder than usual. I live out in the sticks so taking it somewhere is a last resort. It is a 1999 7.3 with 290000 miles.
View 14 RepliesFord F-150 (2004-2008) :: Whirring Noise Coming From Front End While Driving
I recently installed a 2" aluminum HBS leveling kit on my F150. ('04 FX4 SCrew, 5.4, 61K miles). I was excited to finally improve the truck rather than fix something. The install was straightforward and I didnt have any issues (other than Cleveland, OH rust).
After installing the kit I noticed a whirring noise coming from the front end while driving, but I didnt think much of it and I got an alignment a couple of days later. Immediately after the alignment, the problem is still there. It sounds just like aggressive mud tires driving down the road, so I think it is coming from the tires.
The noise follows the speed of the truck (the pitch gets lower as you slow down) but you cant really start to hear it until you slow down below 45 mph. It is much more noticeable at lower speeds (probably because of the lower wind noise in the cab). I dont think it would be a CV joint/axle issue, but who knows. I am considering taking it back to have the alignment checked, but I figured I would check on here before I do.
I just bought this truck last fall, and it is one step away from being traded in because of the countless nuances this thing has (wet floors and consequently rust everywhere on the inside of the cab, rattling window trim, shaking bed, squeaky rear window, noisy phasors).
Ford F-150 (2004-2008) :: Tapping Noise Coming From The Engine After Oil Change
I just bought an '04 F150 from a friend. It has 250K miles on it. When I got the truck there were no tapping noises coming from the engine. Now that I changed the oil, at start up till about 5 miles down the road, I hear the tapping noise. I put Castrol high mileage 5W-20 in it. Could it just be the oil I'm using or something more expensive?
View 9 RepliesFord F-150 (2004-2008) :: 2007 5.4L - Ticking Noise Coming From Somewhere Around The Motor
I have a question about my 2007 F150 4x4 with the 5.4L. It has a ticking noise sound coming from somewhere around the motor, but it's not there till the motor has warmed up. It almost sounds like a exhaust leak, but I'm not sure. What it might be, or what to look for?
View 11 RepliesFord F-150 (2004-2008) :: 2005 - Popping Noise Coming From The Front End?
I have a 2005 ford f150 supercab 4x4, and around feb I replaced all the ball joints my self, and now recently when back with the wheels turned turned to the left and then put it in drive and turn the wheels all the way right and give it has to take off there is a popping noise that comes from the driver side front wheel and it just does it once I take off and quit . I've looked and everything and cant see anything that would cause this. And know when I put it in park and it rolls forward I can hear a popping noise that sounds likes it coming from the rear end. I had my rear rebuilt, with new pinion bearing and race, a new axle on the pass side with bearing and the shop told me that it the driver side is questionable on the axle but it has new bearing also, they also told me that it needs a carrier case cause it had groves wore in it where the axle bearings wore out so much. at the time I could afford to have them to replace the carrier case. what would cause the popping from the front end and now the popping in the rear end.
View 1 RepliesFord F-150 (2004-2008) :: Grinding Noise Coming From Front Wheels
I have an intermittent grinding noise coming from what sounds like both front wheels, it sounds like metal on metal almost like something metal rubbing the rotor but I just put new pads on and the noise was there before as well with nothing touching the rotors but the pads. The sound will appear out of no-where at low speeds of 35 or below and will continue until I brake and slow down, just before I come to a compete stop the noise will stop with a slight clunk.
I can then drive away with no noise. I am pretty sure it is not brake related except maybe ABS somehow but was also thinking front axle or diff, also have read posts that are bearing related, but both at the same time?. It is the slight clunk before stopping that I can not figure out is related to. It is an 05 f150 xlt 5.4 super cab 4wd with 85k miles
Ford 7.3L Power Stroke (1999-2003) :: 2001 - Buzzing Noise Coming From Flasher Relay?
2001 F-350, 7.3L,
Has done this off & on for a few years and am tired of it! Noise is kind of a buzzing that seems to come from the flasher/turn signal relay. It stops buzzing when you turn on a turn signal, activate the flashers, or lift up on the shifter arm(?). Had to drive home yesterday with the flashers on! So I see from researching that it may actually be the multi-funtion switch on the steering column. So I removed that, cleaned up all the contacts, and put it back on and the buzzing did not go away.