Ford F-150 - 1997-2003 :: Transfer Case Output Seal Leaking?
I got a 97 f150 4x4, 4.6 and I had the shop replace the seal 3 times and it's still leaking, the seal where the driveshaft goes into the t case, I call it the slip yoke seal, they said the bushing inside looks good, there doesn't seem to be a whole lot of play in the driveshaft, it doesn't seem to leak a whole lot, I'm about ready to just forget about it and just run it, they put a seal from oreillys in, it seem to be leaking out of the bottom hole on the seal...
View 8 RepliesFord Super Duty (1999-2016) :: Overfilled Transfer Case Or Leaking Transmission Output Seal
I just changed transfer case fluid on my father's F-350 for the first time in 13 years. (over 230k). Removed fill plug first and fluid gushed out of the fill hole unexpectedly. Did not have catch pan ready, so made a mess. I thought it was just over filled form the factory, but too much was coming out to be simple overfill. Almost 2 qt came out of the fill plug.
Did some google search and found many Ford trucks have failed transmission output shaft seal and transmission fluid leaks out to transfer case, causing transfer case to overfill. I am yet to check transmission fluid level, but considering how much came out of it that probably is the case.
Now, how bad of the problem this really is? Will overfilled transfer case cause some serious problem? 4x4 is rarely used (once or twice a year in winter) on this truck and from what I understand transfer case doesn't really do anything in 2WD other than just passing output from transmission through.
There are no fluid leaking outside and repairing the seal would be a too much of work for me.
Also changed rear differential fluid for the first time and I was surprised how clean the fluid was. There were thin layer of black sticky residue (sludge?) covering everything, but the fluid itself looked clean and no visible metal shavings. I guess that is why Ford said it does not require change under normal condition.
Ford Super Duty (1999-2016) :: F250 - Engine Rear Main Seal Leaking
Changing out the rear main oil seal on my 1999 F250 Super Duty. I have a 7.3L diesel with 6 spd manual trans. with 98K miles. This past week it has developed a very slow engine oil drip where the engine meets the transfer case. Is it necessary to remove the engine or just the transmission? What does a transmission/transfer case combo weigh? What special tools would I need?
View 1 RepliesPassat (B5) :: Gear Lube Leaking To The Passenger Side Output Flange Seal
My wifes car started leaking gear lube in the driveway. I traced the leak to the passenger side output flange seal. At first I thought the cause was a bad CV joint but when I tried to shake the axle, I noticed the whole flange moving...How can this be repaired? Does the whole tranny need to be removed or just the output pod?
View 4 RepliesFord Super Duty (1999-2016) :: 2009 F250 - Rear Diff Fluid Change / Pinion Seal Leaking
I just picked up an 09 F250 a couple of weeks ago and I was planning on replacing all the fluids since I'm not sure when everything had been done in the past, but it did pull a camper 5th wheel. It has about 93000 Km/57000mi on it
One thing I noticed when reading the manual is that a rear diff fluid change is not necessary on these rear axles unless they have been submerged in water or repaired etc..
Just after I got it I noticed the pinion seal was leaking. It was fixed under warranty but the dealer did not replace the diff fluid as they said Ford will not pay for it.
My question is do you think I need to replace the diff fluid or should it still be good, given the relatively low mileage.
Ford F-150 (2004-2008) :: 2006 - Leaking From The Front Of Rear End
I noticed the rear end of my F-150 starting to leak from the front of the rear end. What will I need to do to fix it and is there a quick way to fix this issue, as two kids unfortunately prevent me from having much time to fix the issue.
View 5 RepliesFord F-150 (2004-2008) :: 2006 - Rear Cargo Light Might Be Leaking?
I think the rear cargo light on my dad's 06 F-150 might be leaking. Had a water stain trail down the back seat. Is this very common? Is it hard to replace the gasket/seal in the light? I dont really think it's the seal that holds the back glass in.
View 2 RepliesGMC - Sierra :: 2006 - Front End Vibration / Grease Leaking Out Of Rear Seal Of Hub
I have a 2006 gmc sierra, 4x4, 1/2 ton, has 155,000 miles on it. I recently changed both front hubs on my truck. They didn't have any play in them just noise. I had one new front hub that was leaking grease out of the rear seal. I took that one back off and got a new one. Must have had a bad rear seal. Now I'm getting a front end vibration at highway speeds. Between 70-75mph. It gets worse when turning left when highway turns. It goes completely away when turning right at highway speeds. It doesn't shake in the steering wheel. Feels like its coming from the left front area or left front tire. More in the floor boards. So i rotated my tires, and its not as bad but still is there in the same spot. I've checked everything.
Cv axles have no tears in the boots and aren't spinning out any grease. I turn the steering back and fourth while the truck was on the ground and I didn't notice any play in any of the front end components. The only thing I did notice was the passenger side inner tie rod boot had a bunch of grease built up on it. But the boot was actually full. Could one of the bad wheel bearings caused something else to go bad? Warped rotor? Truck doesn't shake or vibrate when braking either.
Ford F-150 (2004-2008) :: Rear Axle Seal Relationship To Rear Diff
I recently had my rear axle seals replaced due to leaking. Does the rear diff fluid get replaced on that repair since the rear diff cover comes off? Trying to figure out when my next interval for changing rear diff fluid should be.
View 1 RepliesFord 6.7L Power Stroke Diesel :: Rear Main Oil Seal Leaking
2011 F-350 CC, 45k miles... Found out yesterday mine is leaking. Way to early for these issues to pop up.
View 1 RepliesFord Excursion :: 2005 - Rear Axle Seal Leaking On Passenger Side
2005 4wd excursion. I have a leaking rear seal on passenger side.
I have the hub assembly off. I'm down to the spindle. My old seal came out in pieces. There's either a piece of the old seal or another seal on the back of the spindle.
Are there two seals? This what looks like a seal still on the spindle against the plate on the back...
Ford F-150 (2004-2008) :: Oil Leaking From Rear End?
I have a 2004 F-150 FX4 and I noticed I have oil leaking from my rear end. It is leaking from inside the wheels on both sides. More on the passenger side though.
View 8 RepliesFord Excursion :: Driver Rear Axle Seal Leaking Coating The EBrakes In Gear Oil
While diagnosing an issue with my ebrakes I found the drivers rear axle seal was leaking coating the ebrakes in gear oil, replaced the seal. Decided to pull the differential fill plug and check to make sure it was full - drained a good bit out pulling the hub to replace the seal. To my horror this is what I find when I pull the plug. First photo is as it came out on the magnet - second is after a clean up. What is it? I am almost afraid to drop the cover....
View 14 RepliesFord 6.0L Power Stroke Diesel :: 2004 F250 - Coolant Leaking On Rear Right Of Engine
I spotted a leak last nite on my 6.0. It is coolant, running down the right rear on 2 metal lines that go to the trans I think. It was dark and 24 degrees so I did not spend too much time looking. Shut the mother down til I could research. 2004 250, 6.0 FX4x4, stock. Coolant was changed to green by previous owner. Bought it 4 months ago. 187,000 miles.....
View 14 RepliesFord 6.7L Power Stroke Diesel :: Rear Main Seal Leaking Where Engine Connects To The Transmission
I haven't had time to take my truck to the dealer to actually be checked yet but it appears I might have a rear main seal going out from what I can see. I pressure washed the whole underside of my truck the other day and there is fresh oil where the engine connects to the transmission.
My truck is a 2011 with a 2013 engine in it. The truck has 103,900 miles on it. The engine has almost 60,000 miles on it. I have the extended warranty on it which is good. All this truck has to do is last 2 more lousy months and I'll replace it.
2011 Ford F-450 6.7L Diesel 12' Flatbed
Ford Super Duty (1999-2016) :: Rear Hub Outer Oil Seal Leaking / Replacement Part?
The rear hub outer oil seal on my 05 350 is leaking. The 350 Super Duty Twin Cab was never imported into the UAE so can I use the same seals as the Excursion or another Ford vehicle?
Failing that do we know the name and part number of a seal manufacturer whom I might be able to source from in Dubai? Ford don't make the seals them selves so there must be an alternate source for these things surely?
Ford Ranger / B-Series :: 1999 - Output Shaft Seal Won't Stay?
I replaced the seal the other day on my ranger because I noticed my fluid disappearing. Went ahead and changed the filter and fluid as well. Flushed the system, and I go back to my truck tonight and there's a huge puddle of trans fluid. And the output shaft seal is once again, up against the drive shaft. I've spent like $150 on trans fluid since Friday, and $1000+ to get the truck running again last month, so pardon me if I get edgy about her.
99 2.5 auto. I changed the trans pan gasket too. No leaks from it.
Intrepid :: The Rear Main Seal Is Leaking
My daughter has a 2000 intrepid with i believe a 2.7 engine. the rear main seal is leaking.
View 1 RepliesFord F-150 (2004-2008) :: Fluid Is Leaking From Rear End Of Transmission
My dad's truck recently started leaking transmission fluid and we're having trouble identifying what needs to be replaced, here is a picture of where it's leaking from.
2005 Ford F-150, 5.4L Engine...
Fluid is leaking from the rear end of the transmission. The black stuff is some instant weld fluid...