Ford F-150 - 1997-2003 :: 2002 V8 - Camshaft Position Sensor Harness
Just bought a 2002 4.6 v8. Check engine light was on and it pulls code po340 for the camshaft position sensor. I took a look at it and found its not plugged up. The plug is missing but the two wires are still there. I can replace the two wire plug but does it matter which wire goes to which side of the sensor?
View 3 RepliesFord F-150 - 1997-2003 :: 2000 - Engine Swap Of 5.4 To 4.6?
I have a 2000 f150 5.4 4x4 auto with a bad engine, and have 1997 f150 4.6 4x4 auto rolled but with a strong engine. What would need to be done to replace the 5.4 with the older 4.6 engine?
View 1 RepliesFord F-150 - 1997-2003 :: 4.6L DOHC Engine Swap To 2000 SOHC?
I have acquired a 4.6l DOHC out of a mid year 85 mustang cobra, would like to install in my 2000 F150 that has a 4.6l sohc, what is available for ECM with the swap?
View 2 RepliesFord F-150 - 1997-2003 :: 2000 - Trans 3rd Gear Out / Revs Up But Does Not Pull At All
I recently purchased a f150 with a reg cab short bed 4.6 4x4, and when you put it in drive the it shifts up to second fine, but when goes to third just revs up doesnt pull at all. Have to shut o.d. off and goes steady but run 2500 rpms to go 40 mph. I was told to check the solenoids but i dont know, if i do need a new trans how do i identify my trans. I know it has the code "U" on the door sticker, but its an 4r70 w code-w. But the junk yard has a YL3P-FA and a YL3P-JA?
View 1 RepliesFord F-150 - 1997-2003 :: 2002 - Trans Cooling Lines To Radiator Leaking?
2002 4.6 SC with towing package... Transmission cooling lines to radiator leaking. Replacing them? How long does it take, can it be done while working on the ground? Any tricks or problems to look out for?
View 3 RepliesFord F-150 - 1997-2003 :: Water Leaking Form Rear Window Frame?
Patching cracks of the rear window frame? I am talking about the actual glass casing assembly and the cracks are viewable from inside the cab of the truck. I've found two small cracks and that is exactly where the water will stream in.
I was just about to pull the rear window out to replace the butyl seal when I pinpointed the cracks. So is it possible to use some RTV, form a gasket, or JB weld or something else to patch these cracks?
Are the sliding rear windows more prone to cracking? If so I'll probably replace the assembly with a solid rear window. Where I should purchase a replacement window?
Ford F-150 - 1997-2003 :: 1998 - Battery Light Only Off Over 2400 Rpm - Humming Noise Form Background - Alternator?
Vehicle is 1998 F150 with 194k. The battery is 1 1/2 yrs old and belts and alternator are original.
Yesterday morning my VHF and dog tracking eqipment started humming with the truck running. The hum on the tracking eqpt. only happened when I pointed the antennae over the direction of the hood with truck running. When I shut truck off everything is normal. Later in the day the battery light came on. The battery light would go off if I kept it over 2400 rpm's. The charge on the dash was normal but as I got closr to home last night it dropped to almost nothing and the lights were very dim.
I am thinking alternator. What I am confused about is the humming noise in the background. The tracking eqpt. is completely separate from the truck while the VHF is direct to the battery with an iline fuse. Bad voltage regulator?
Ford F-150 - 1997-2003 :: 2001 - Fog Horn Sound Coming Form Left Side At Idle After 4.6L Warmed Up?
My '01 F-150 2WD, XLT has a foghorn sound coming from the left front side at idle after the 4.6L is warmed up. It goes away with an increase in engine RPM and is unnoticeable at hwy speeds. I have no codes (I have checked w/ my code reader). The service desk guy at the stealer said it is my abs pump going bad (I figured it was a pump of some sort, my 55 packard PS makes the same noise when almost empty-the system leaks). It also appears this is a stealer only part, and going to cost 6 or 7 benjamins to buy and probably another 5 benjamins too fix.
View 4 RepliesFord Super Duty (1999-2016) :: 2007 - Mirror Swap - Wire Harness?
I have a 2007 F-350 SRW. I bought some mirrors of craigslist from two different sellers. They are from 2008 or later, they didn't know the exact year. I have looked in the tech folder and searched and searched. could not find wires that are the same color as mine. Yes, mirrors are OEM. I need to know what color goes to what color.
Do they match color to color? question mark represents color that doesn't line up
drivers side door colors=============== new drivers side mirror colors
green------------------------------------------------- green
black--------------------------------------------------black
green/white-------------------------------------------black/white?
blue----------------------------------------------------blue
yellow--------------------------------------------------yellow
red------------------------------------------------------red
brown---------------------------------------------------brown
passenger door colors=================new passenger mirror colors
green/purple------------------------------------------white?
black---------------------------------------------------black
white/blue---------------------------------------------black/white?
yellow--------------------------------------------------yellow
green---------------------------------------------------green
brown---------------------------------------------------brown
brown/purple-------------------------------------------purple?
Side note these are in no particular order as far as pin location.
Ford F-150 - 1997-2003 :: AC Clutch Harness Causing Truck To Not Start
My issue started as simply a lack of air conditioning. Upon initial inspection I noticed that the compressor clutch is not engaging when I turn the ac on. So I figured the next step would be to see if I am getting voltage to the clutch. My Chilton book says to test this with the truck on, so I disconnected the harness from the compressor, attached my meter to the cable, and attempted to start my truck. I've found that the truck wont start with this cable disconnected. It will turn over but just never starts. Also the fuel pump comes on as it should.
I've repeated this several times. It always starts with no problem when the compressor clutch is connected. I understand that there is some monitoring circuit with the pcm so maybe that has something to do with it but I'm pretty fuzzy on how that works. Upon further inspection, it looks like I should be able to test my ac signal with the engine off, so maybe that's not such a big deal, but this whole truck not starting business is blowing my mind.
Ford F-150 - 1997-2003 :: Possible To Swap Cab To A 4 Door?
My names brad. I have the old model 97 . Is it possible to swap the cab to a 4 door. Its got a 8ft bed
View 1 RepliesFord 7.3L Power Stroke (1999-2003) :: 2002 - No Start After Harness Shorts
While engine was running. brake switch "recall harness" shorted to exhaust manifold blowing fuse 22. truck died instantly. found the short and replaced fuse. checked all fuses good but no start since. WTS indicator stays on. tried a new GPR and a new CPS.
Does IPR and brake switch (on master cylinder) share fuse 22? fuse 22 holds now (when wire was fused to exhaust manifold it blew as soon as key turned on). unplugged FBH no change. recall harness "beeps" good and wires do not appear burnt. also shuffled relays around in central junction box.
Could formerly access OBD2 port with superchips programmer but no access now. fearing the worst, but hoping maybe bad ipr sensor (or another sensor) could cause this. Is it likely or not that this short fried the PCM?
Ford 7.3L Power Stroke (1999-2003) :: 2000 - Ignition Harness Wiring Colors?
My 2000 f350 has wires that dont match anything I've seen. I need to mate this to an 08 harness so I need to be accurate. I have
(2) yellow. I know this is 12v constant
(2) green/purple I know this is 12v constant
(1) red/black
(2) solid red
(1) solid black
(1) gray/light blue
Ford 7.3L Power Stroke (1999-2003) :: 2000 - Got Code P1316 - Injector Wiring Harness?
I have a 2000 Ford F550 7.3. I bought a Superchips programmer to read the codes on my truck and up pops this P1316, so I did some research and found out that the most common problem is the injector wiring harness. I bought new valve cover gaskets and the injector wiring as well because the truck is old and I figured new wires wouldn't hurt.
So after installing the new wiring harness and gaskets I'm still getting this Code! The truck idles rough and serge's sometimes, also there is a lack of power and some shaking between 40 and 50 miles per hour, however form 50 to 60 MPH seem's to be just fine. I don't trust the "Mechanic Shops" around here and will only take the truck in as a last resort.
Ford F-150 - 1997-2003 :: Older 5.4 Engine Swap To Newer From E-series?
Having older 5.4 truck tried to swap in a newer 5.4 2v from a E- series? The vans never got the 3v engine. I have a 2001 5.4 w/150000 miles, and I have a line on a 2008 5.4 2v from a E-350 with only 30,000 miles. Any issues/problems with the swap?
View 2 RepliesFord F-150 - 1997-2003 :: 5.4L Motor Swap And Engine Has Rough Idle
2001 5.4L 4x4...Engine bought from reputable junkyard with 140K has new manifold studs, motorcraft spark plugs, and 8 coils (bought on Amazon).
No check engine codes...checked for vacuum leaks...And has rough idle.
Is there a reason it might have rough idle aside from blown motor? The mechanic was going to take it to get computer reflashed but not trying to throw money down the drain...
Ford Excursion :: Trans Swap 7.3 To 6.0?
I am in the middle of the 7.3 to 6.0 swap and wanted to confirm the in and out lines of each cooler. All the links to the websites that were writeups seem to be dead.
View 3 RepliesFord Transmission :: 1979 F150 - 4 To 5 Speed Trans Swap?
I am looking to change out my manual transmission in my 79 f150. I want to put a 5 speed in it but still keep my manual clutch. I have a 300 engine that I also want to keep, can I just put a late 80's early 90's 5 speed transmission in it and keep my original bell housing?
View 5 RepliesFord Super Duty (1999-2016) :: Automatic Transmission Swap 2000 F250 To 2003 Model?
I have a 2003 f250 4x4 with a 5.4 motor the automatic trans is shot. I can get a replacement trans from 2000 f250 4x4 with the v10 motor. I tried my best to research it bell housing supposed to be the same so it should fit. But I'm not sure what they changed in those years internally or electronically.
View 2 Replies