Ford F-150 - 1997-2003 :: CEL On - Heavy Pinging?
I have a 1997 F-150 4.6. I have a cel and a heavy pinging that seems to get better the colder the outside temp is. If I unhook battery , the rehook the cel is gone for a day or so and the pinging is much less, but in a day or so it comes back on and condition worsens.
View 1 RepliesFord F-150 - 1997-2003 :: Random Pinging Noise From Under The Truck
I just picked up a 1999 F150 5.4 with around 19k miles on it. Truck is in mint condition, stored in a heated garage since new. Before we made the deal I checked everything out pretty well including checking all the fluids, test drive, other usual stuff and didn't notice anything out of the ordinary. However, today I went for a short ride with the windows down I noticed a random pinging noise from under the truck. At first I thought it was a few small rocks bouncing off something metal under the truck, however it continued to do it randomly for the next 5 minutes. I would say I hear a ping every 15-20 seconds randomly. Doesn't matter if it's idling or under load, happens about the same either way. Aside from this, truck starts and rungs great and no error or warning lights have kicked on.
When I got home I started the truck back up and climbed under to see what it was. I found that the noise is coming from the exhaust system, mostly heard at the catalytic convertor. It resembles the metal expanding kind of ping, but I think its actually originating at the engine and the noise is just carrying through the exhaust system. I then went back to the engine bay and could hear the same random ping, just much quieter. I don't know the condition of the fuel, but based on the low miles I haven't ruled out a bad tank of gas. Only other issue with the truck is there is a bit of rust and corrosion on the inside of the exhaust tips and up into the exhaust pipe. They are still shiny and silver on the outside, just a little rust buildup on the interior of the exhaust. Hoping it's just the last 1' or so that is rusted
Ford F-150 - 1997-2003 :: Spark Knock - Pinging When Go Above 3000 RPM
Had it before, code p1401. Changed out dpfe and it worked for 6 months. Now spark knock again. Now though I have no codes though. No vacuum leaks that I can find. New egr from before I had the problem. I applied vacuum to the green hose and it stumbled so the ports should be ok. Snytime I go above 3000 rpm i get the pinging. I replaced the dpfe again and no difference.
View 3 RepliesFord F-150 - 1997-2003 :: 1999 - Squeaking Badly - Replace Chassis Bushings?
I am buying my Dad's '99 F-150 4x4 Lariat from him and this truck squeaks something terrible. I am assuming that the chassis bushings need to be replaced. I have 2 questions.
1. Am I on the right track to solve the problem?
2. How hard is the job?
Ford F-150 - 1997-2003 :: 4x4 Truck Cutting Out When Towing
My 03 f150 lariat 4x4 (5.4 L, 60,000 mi, 6500 g.v.w.r.) cuts out when towing (3,000 - 7,000 lb trailer wt.s) mostly highway but also in town. Usually restarts easily and when I drop trailer , problem disappears. Same problem with different trailers/weights - no error codes on my OBD reader.
View 1 RepliesFord F-150 - 1997-2003 :: 1999 - Maximization Of Gearing And Towing?
I have a 1999 f150 super-cab flareside, 5.4L, automatic, 4x4, with 175k miles on it, its runs perfect, i believe it has 3:55 gears. what can i do to maximize its towing ability like gear up to 4:10? I dont wana sell it to buy a f250 diesel or whatever and its paid off, what possible options do i have to keep the truck and maximize its towing rate.
(how do they rate a truck for towing? is it like how much torque the engine got? or is the frame or suspension built strong?)
Ford F-150 - 1997-2003 :: 1998 - Slow Towing - Specific Trailer?
I bought my truck a couple months back for my custom furniture business. It's a '98 F-150, XLT, 5.4, supercab, 4x4, 3.73, 4R70W, 176k miles, with tow package. Today I picked up a single axle 6x12 trailer enclosed with metal mesh, weighs about 2000 lb. This was my first time towing with this truck and I figured it would run a little slow but this was ridiculous.
Highest speed I could get to was 64 going slightly downhill with OD locked off. Most of the smaller inclines and flat areas were max 55, then the worst was a two mile 7% incline at 35 mph. That last one just wouldn't downshift. This was all between 5000 and 6000 elevation in the Rockies. It's a little embarrassing getting passed by loaded semis
Am I doing anything wrong? Could it just be this specific trailer has issues?
Ford F-150 - 1997-2003 :: Misfire On Cylinder 3 (P0303) But Only During Towing With Ethanol
I drive a Supercrew F150 5.4L XLT 02 since 9 years, I put a Fuelflex module since 8 years, since some months I Misfire on cylinder #3 (P0303) but only during towing with Ethanol (over 2000/2500 rpm), when I drive on gas all is fine, I changed Flexfuel modul, plugs, coils, header gasket, without any positive results, it's very curious to have the problem only with ethanol (E85), I can drive very hard and at high speed with just the truck, but with a trailer as soon as I ask more power i lose one cylinder, with misfire...but like I said only on ethanol? I know engine needs more ethanol than gas, so I go check fuel pressure and maybe try to change fuel injector...
View 8 RepliesFord Ranger / B-Series :: 2003 2.3L - Pinging / Tapping Or Knocking Noise
My 2003 Ranger 2.3L When I purchased it in 2005 I never noticed this tapping noise until in 2007 when Tennessee forced 10% Ethanol added to fuel. That is when the noise started.
What this could be. I have since moved to Texas and found a station that sells Ethanol Free gas, but that does not remove the noise.
Ford 7.3L Power Stroke (1999-2003) :: Slight Pinging Sound At Low RPM When Climbing A Steep Hill
Was climbing a steep hill at 35 mph just before truck down shifted to 2nd, I was hearing a pinging sound. Sounded like only I cylinder was doing so. What it could be. I am currently running a 1/4 tank of Fppf fuel injector cleaner. Is this a injector noise. No knocking just a slight pinging.
View 1 RepliesFord Wiring/Electrical :: 1997 - Tail Light Not Working After Installation Of Trailer Towing Kit Round 7 Pin?
I have a 1997 F150. I installed a trailer towing kit round 7 pin. I followed the instruction and replaced three different fuses after installation. The passenger side turn signal will not work. I replaced the bulb. The brake light works and the bulb is on when the lights are on it just will not blink. When the turnsignal is on it clicks very quickly.
View 4 RepliesPassat (B5) :: 2003 V6 Pinging When Warm Under Normal Load
I have a very annoying problem with my new (to me) 2003 Passat, when warm it tends to ping under what i would consider normal load, it's more apparent after it changes gear (auto) and also if you are traveling down the road you give the gas an extra tickle.
It soon shuts up but pinging is not a good thing any time. The car has 45000 miles so is barely broken in.... It also suffers from what i consider to be a lazy transmission which tends to make it a little worse.
I am using the recommended super grade of fuel and have tried different fuels to see if it is biased.
Ford 7.3L Power Stroke (1999-2003) :: More Black Smoke When Towing?
Normally I run around sea level at home but Iam on road trip in Wyoming at over 5000' elevation I am noticing alot more black smoke when towing. I run a DP tuner with 40 and 60hp tow mode. I also notice alot more black smoke in 60HP Econo Mode when not towing? Would this be typical due to the higher elevation?
View 2 RepliesFord 7.3L Power Stroke (1999-2003) :: F250 Overheating While Towing
Alright I got a '99 7.3 Superduty F-250 I have been overheating while pulling my 1985 Camper weights around 6K. I put a new thermostat in still overheated.
Scenario, Rpms 2500-2700 top end trying to keep fluids moving. OD to D to 2 to 1. Run in between 1 and 2 basic on the up and flat of the road.
6-8% grade engine gets hot pull over and let it cool put it in 4 wheel works a little bit 4 wheel at least keep the tranny around 180. I only have a tranny gauge, I'm using the dash temp gauge for the engine.
What I'm I doing wrong or over looking.
Hyundai - Santafe :: 2003 - Missing Badly - Keeps On Shutting Off
I used some mass airflow sensor cleaner yesterday. My Hyundai santafe check engine light came on but it was running fine. Tried to drive it this morning and it was missing bad and kept shutting off. It would cut back on, once in drive and move a few yards it shut right back off. I cleaned the sensor BC my truck kept idling up high and shutting of when coming to a complete stop. It seem like it was flooding itself, kept smelling fuel when I would try to start back up. Knew it had to be fuel regulator or air flow sensor. So I decided to clean air flow sensor before buying parts. Now after cleaning truck is worst but at least it will start right up. Unlike at first when I would have to wait 15 mins when it shut off.
View 7 RepliesFord 7.3L Power Stroke (1999-2003) :: 2000 - Vibration While Towing At Low Speeds
I have a 2000 with a six speed and through the first 2 gears while giving it only a little throttle, worse on hills and worse while towing I have a pretty decent vibration. Once you get to 3rd and up its fine. I have read about axle wrap and due to the fact my springs are pretty wore out I think this is a big part of it. Any other things to look at other than new springs? The u joints all look and feel fine so I haven't touched them.
View 8 RepliesFord 7.3L Power Stroke (1999-2003) :: Some Gauge Reads Towing Light
Towed 3 axle trailer loaded with a 73 VW bug, two implement bars, plows and a small boat. I would guess total weight at 7,000 max. The ambient temp 97 degrees and very humid. I have a 2000 dually.
The following are from the ScangaugeII
TFT trans temp 175 max
EOT end oil temp 205 max
SLP trans slip 0.20 max and 0.0 in high gear
From glow shift
Water temp 196
The one I am worried about is the trans slip, from a stop taking off always went high 0.15 to 0.20 and then drop quickly. Once the TC locked 0.0 down the road. Also, when I reverse with no load on dirt I have seen 0.20 on the trans slip. I have Forscan but have not logged any temps yet....
Ford 7.3L Power Stroke (1999-2003) :: Check Engine Light While Towing
2001 F350 290,000 no mods other than 6637, 2WD
Towed our new to us RV home last, only 15 miles from the dealer and yes its a big 5th for my truck at 12,000lbs. Anyhow, about 2 mins from home as I'm pulling off the freeway I got a SES light come up, then it disappeared. I checked codes this morning using forscan and nothing shows to indicate what it may be.
I was wondering if the transmission is getting hot if it throws an SES? It was only a short trip, but I have no real idea of the condition of the trans as the truck is new to us too - fluid looks and smells good.
Only new code is an ABS one c1229, c1233, C1234. I had 2 of them before - think the 1229 is the new one.
Ford 7.3L Power Stroke (1999-2003) :: Shuddering Low Gear Acceleration When Towing Heavy?
2002 F350 7.3, MANUAL transmission ZF6.
Bought this truck used for hauling an excavator, and after fixing damn-near everything engine/turbo/and-cooling-system-related ---- it's finally seeing some use.
Just recently started hauling 12,000lb payloads. When I accelerate hard in Low gear, and then shift into 1st and accelerate hard again, I feel the whole truck shuddering. It's like a shimmy-shaking vibration all through the vehicle.
It doesn't happen in higher gears, only when the following conditions are met...
1) Starting from a dead stop
2) 12,000lb payload (heavy)
3) Accelerating hard (Low, First gear)
I would also like to add that I experienced this shuddering vibration very intensely when I put the transfer case in 4wd LOW (front manual hubs left unlocked) and towed 14,000lb up a steep hill in 1st, 2nd, and then 3rd transmission gears.
^^^ By leaving front hubs unlocked and transfer case in 4wd LOW, I was effectively lowering my final drive ratio even more for extra pulling power in 2wd hill-climbing. I don't do this often, only when absolutely necessary. ^^^
I must also add that I do have slightly taller rims/tires than OEM ford WITH the original ford gearing (3.73) so I'm more like 3.51 final drive ratio.
02 F350 7.3l ZF6