Ford 7.3L Power Stroke (1999-2003) :: 2000 - Power Loss While Towing Up Hills?
I pulled with my 2000 F250 7.3 for the first time yesterday pulling a 12,500 5th wheel and then again today with an 18 ft ski boat weighting around 3500 for both the trailer and boat. I had this same issue pulling both.
Today when pulling the boat/trailer i was behind a slow moving truck and when we hit a hill with a passing lane i merged over and wanted to start passing him. We started off at around 45 mph up the hill and as I started pushing the pedal I wasn't gaining any speed and my rpm's didn't even get over 1500. It felt like a stall and continued that at around 45-50 mph up the hill (about a 65 degree slope). When I'm not towing the truck runs great, plenty of power and averaging around 16 1/2 mpg.
Only mods i have is a 6647 Napa filter, muffler delete and it's running the same 4 position TS tuner from the original owner. During normal operation I run it at the 75hp gain and when towing i use the 50hp gain.
In both instances i could see black smoke coming from exhaust when pushing the pedal but my rpm's wouldn't go up and truck maintained the slow speed going up the hill. Once at the top it drove normal and picked up speed without any problems.
Ford 7.3L Power Stroke (1999-2003) :: Clunk / Vibration When Traveling At Highway Speeds
I'm a mechanic but work only on cars so I'm a little shy on diagnosing trucks. I have a 2001 7.3 f250 4x4 short bed, when I give it gas I can hear a clunk, when I let off of the gas I also hear a clunk. Also when traveling at high way speeds I can feel a strong vibration when I very lightly give it gas but the vibration goes away as I give it more gas.
View 5 RepliesFord 7.3L Power Stroke (1999-2003) :: 2000 - Overdrive Light Blinking Only At Low Speeds
So here's the deal: My 2000 F250 has began to have the overdrive light blink when I am traveling at low speeds <40mph and it is accompanied by strange shifting (lower gear for a longer period of time). As soon as I get up to highway speeds the blinking stops and goes back to normal operation. But as soon as I go back to low speeds it happens again. When I put the truck in to park when it has the light blinking it revs it self to about 1200rpms then goes back to normal idle. This truck has 228k miles and is on the original transmission.
View 5 RepliesFord 7.3L Power Stroke (1999-2003) :: 2000 - Occasional Miss At Highway Speeds / Bucking And Jerking During Even Gentle Acceleration
165k miles 4x4 6 speed, bone stock unmolested
Slowly progressing problem over 6 months. Occasional miss at highway speeds uphill has progressed to bucking and jerking during even gentle acceleration attempts.
I hadn't got my cam sensor recall done but no change after that procedure completed yesterday. Oil recently changed as well.
I have a torque pro but it never finds any fault codes even though 'service engine' light comes on sporadically. I'm not sure I'm operating it properly but it at least reads rpm when its running.
I'm contemplating the hutch mod but I'd like to have an official diagnosis beforehand if its possible in my case.
Ford 7.3L Power Stroke (1999-2003) :: 2001 F350 - No Power Especially While Towing
I just bought a 2001 F350 diesel with 120k miles on it a couple weeks ago. Friday I headed out to Oregon with my 16 foot enclosed trailer filled with jet skis (about 4-5k pounds) for a competition. A few minutes after being on the freeway I noticed the truck did not have good power. About 30 min later while climbing a steep grade the truck almost went dead.
I started at 60mph and by the time I got to the top i was at 15mph with the throttle pinned. the motor sounded funny and shook the truck more then normal. After wards on the down side of the grade the truck started to act normal. I took it to my buddies house and switched trucks because I didn't trust if for the 13 hour drive.
Today I talked to a mechanic at the dealership and he said that it sounded like injector o-rings to him. I went home, pulled the valve covers and started the motor to see if anything is leaking. steam was coming from the valve area and the down spouts on the injectors was flowing oil. The thing that looked especially abnormal was one of the injectors looked like fuel was dribbling from it. I don't know if that is a problem or not. I couldn't tell if it was fuel or oil but no other injectors had fluid coming out near the wire connections.
Ford 7.3L Power Stroke (1999-2003) :: 2000 F350 - Noise Like Exhaust Rattle Or Vibration At Idle
I have a 2000 Ford F350 7.3 with the auto and 262,000 miles on it. As far as I know everything is stock on this truck. It has been a great truck but lately its been making a strange noise. It almost sounds like an exhaust rattle or vibration but it is intermittent. Its not really loud it can be heard best in the cab at idle. I've looked all over on the truck and haven't found anything. I can't pinpoint where it is coming from. I tried starting the truck with the serpentine belt off no change.
I took the inspection plate off the bell housing and couldn't see any cracks the torque converter bolts appear tight, and the starter is not engaged while running. I've read a few forums on the torque converter going bad. It looks to me like its more the 99 trucks that had trouble with that. Did the torque converter issue carry over to the 2000's? Would a torque converter/transmission problem be intermittent?
Ford 7.3L Power Stroke (1999-2003) :: More Black Smoke When Towing?
Normally I run around sea level at home but Iam on road trip in Wyoming at over 5000' elevation I am noticing alot more black smoke when towing. I run a DP tuner with 40 and 60hp tow mode. I also notice alot more black smoke in 60HP Econo Mode when not towing? Would this be typical due to the higher elevation?
View 2 RepliesFord 7.3L Power Stroke (1999-2003) :: F250 Overheating While Towing
Alright I got a '99 7.3 Superduty F-250 I have been overheating while pulling my 1985 Camper weights around 6K. I put a new thermostat in still overheated.
Scenario, Rpms 2500-2700 top end trying to keep fluids moving. OD to D to 2 to 1. Run in between 1 and 2 basic on the up and flat of the road.
6-8% grade engine gets hot pull over and let it cool put it in 4 wheel works a little bit 4 wheel at least keep the tranny around 180. I only have a tranny gauge, I'm using the dash temp gauge for the engine.
What I'm I doing wrong or over looking.
Ford 7.3L Power Stroke (1999-2003) :: Truck Has Lost Power Towing And Is Now Starting To Miss A Little
I want test my fuel pressure. What is a good gauge or kit to buy? My truck has lost power towing and is now starting to miss a little. I'm wandering if i my problem is in the tank. Is there a good scan tool that would diagnose things too?
View 14 RepliesFord 7.3L Power Stroke (1999-2003) :: Some Gauge Reads Towing Light
Towed 3 axle trailer loaded with a 73 VW bug, two implement bars, plows and a small boat. I would guess total weight at 7,000 max. The ambient temp 97 degrees and very humid. I have a 2000 dually.
The following are from the ScangaugeII
TFT trans temp 175 max
EOT end oil temp 205 max
SLP trans slip 0.20 max and 0.0 in high gear
From glow shift
Water temp 196
The one I am worried about is the trans slip, from a stop taking off always went high 0.15 to 0.20 and then drop quickly. Once the TC locked 0.0 down the road. Also, when I reverse with no load on dirt I have seen 0.20 on the trans slip. I have Forscan but have not logged any temps yet....
Ford 7.3L Power Stroke (1999-2003) :: Check Engine Light While Towing
2001 F350 290,000 no mods other than 6637, 2WD
Towed our new to us RV home last, only 15 miles from the dealer and yes its a big 5th for my truck at 12,000lbs. Anyhow, about 2 mins from home as I'm pulling off the freeway I got a SES light come up, then it disappeared. I checked codes this morning using forscan and nothing shows to indicate what it may be.
I was wondering if the transmission is getting hot if it throws an SES? It was only a short trip, but I have no real idea of the condition of the trans as the truck is new to us too - fluid looks and smells good.
Only new code is an ABS one c1229, c1233, C1234. I had 2 of them before - think the 1229 is the new one.
Ford 7.3L Power Stroke (1999-2003) :: High Pitched Squealing / Scraping Sound - Loss Of Power Towing Uphill
Towing a 5th wheel at about 10,000 lbs total. Towards the end of out 9 hour trip home and going upgrade the truck begins to loos power and the engine starts making some bad sounds. Although its hard to hear it starts about 45 seconds in and continues later when going uphill. the truck also made a very high pitched squealing/scraping sound (not a belt) like it may have been coming from the turbo. Oil temp was about 220, trans temp at 170 at the time of the event.
Truck has 216k, stock, upgraded trans cooler, original fuel pump.
Here is the video : YouTube.....
Ford 7.3L Power Stroke (1999-2003) :: Shuddering Low Gear Acceleration When Towing Heavy?
2002 F350 7.3, MANUAL transmission ZF6.
Bought this truck used for hauling an excavator, and after fixing damn-near everything engine/turbo/and-cooling-system-related ---- it's finally seeing some use.
Just recently started hauling 12,000lb payloads. When I accelerate hard in Low gear, and then shift into 1st and accelerate hard again, I feel the whole truck shuddering. It's like a shimmy-shaking vibration all through the vehicle.
It doesn't happen in higher gears, only when the following conditions are met...
1) Starting from a dead stop
2) 12,000lb payload (heavy)
3) Accelerating hard (Low, First gear)
I would also like to add that I experienced this shuddering vibration very intensely when I put the transfer case in 4wd LOW (front manual hubs left unlocked) and towed 14,000lb up a steep hill in 1st, 2nd, and then 3rd transmission gears.
^^^ By leaving front hubs unlocked and transfer case in 4wd LOW, I was effectively lowering my final drive ratio even more for extra pulling power in 2wd hill-climbing. I don't do this often, only when absolutely necessary. ^^^
I must also add that I do have slightly taller rims/tires than OEM ford WITH the original ford gearing (3.73) so I'm more like 3.51 final drive ratio.
02 F350 7.3l ZF6
Ford 7.3L Power Stroke (1999-2003) :: 2001 F250 - Black Smoke When Towing Uphill
I have always seen other trucks blow black smoke with towing up a hill but mine for the most part has not. I pulled my 5er to CO this summer and notice my truck starting to blow black smoke. I consider myself a very conservative driver. I always stay around 65 MPH while towing and never push my truck up the hills. I always try to keep the RPM around 2000 and let the MPH fall where they may until I reach the summit. With the black smoke I'm starting to see what is my truck trying to tell me? It's not bad but would like to fix now before it becomes something more.
2001 F250, 4X4 crew cab, 7.3 with 205,000 miles.....
Ford 6.7L Power Stroke Diesel :: Truck Downshifts To 4th Gear While Towing A Trailer At Interstate Speeds
2013 CCLB, 33,500 miles, stock emissions
While towing a 9000 pound trailer at interstate speeds (75 to 80 in Wyoming), when pulling a hill, the truck downshifts to 4th gear, boost is about 18psi, eng and transmission temps in the 230F range, EGTs around 500C or 935F. RPM increases normally to 3000 then the turbo gets very loud and boost drops to about 10psi. The truck shifts to 5th gear, noise decreases but is still present, shifts to 6th and noise goes to normal after a couple seconds and boost builds normally.
This just started today. I have about 8000 miles towing this trailer and never had this before. I have about 350 miles until I'm home so I'm headed back out. Will play around with manual mode and see what it does. I also took a video of the gauges while this happens. Audio is difficult to discern. I will try to get better audio and post when I get home.
Ford 7.3L Power Stroke (1999-2003) :: Shaking At Higher Speeds - 40 MPH And Above - Loss Of Power
I have a 2000 Excursion 7.3, 6 position tune, and exhaust as far as mods (on truck when bought). Last couple of weeks I get no power while on the throttle, foot on the gas and the whole truck shakes at higher speeds - 40mph and above. At first it wouldn't go above 60 or so, would hit the gas and Rpms would just stop not be able to generate any further power. Changed the IPR, ICP, and CPS.
I still get the high/low range ICP codes, P1280, P1281. First night the IPR was changed I got it up to 90mph and thought it was all solved but got a little shake right at the top and I let off the gas. Next day back to square one and has seemed to get progressively worse, almost wasn't able to make it up a hill by my house not even going 20mph, but it's like intermittent. I have a scan tool, here is at idle and at around 60mph ....
Ford 7.3L Power Stroke (1999-2003) :: Tires Sound When Under Load At Speeds Above 37 - 40 MPH
The issue: when I reach 37-40mph I have a new sound which I believe is the transmission 4R100. It sounds like a flat spot on a tire, or the sound tires make when they leave the sticker on them. The cadence of the sound is slower than the rotation of the wheels.
If I let off the accelerator, the sound stops, as soon as I add load by pressing the accelerator the sound returns. If I shift to Neutral the sound is gone.
If I coast at any speed the sound is gone. It is only audible when under load at speeds above 37-40 mph. The cadence does increase as I speed up, but it doesn't sound as fast as the motor is turning (~1900 rpm's).
I monitor the truck with torque pro using the PIDs defined here on FTE. I can see lock-up in 3rd and the shift to overdrive. When in lock-up, I see 1-7rpm TCSlip.
Watching transmission temp as reported by torque, the hottest I see is 183* pulling an enclosed 6x12 @ 75 mph. Ambient temp is 95*. Excursion currently has 240k miles on the clock.
This sound was first heard by my wife two weeks ago. I thought I had tire issues and they needed to be rotated. The sound is still present, and now identified only when the truck is in drive, and under load, regardless of me pulling a trailer.
Yesterday on my 500 mile trip, the truck hiccuped several times which I believe was around the time I was either moving in or out of overdrive. Details in a different thread: [URL] .....
Anyway, I've looked at all culprits and can't find anything with the motor, or electrical system. I can't get to a transmission shop until Monday, and won't have my AE until I get home Sunday night. I have a 500 mile run tomorrow. I checked the transmission fluid and it's at a good level, pink, and doesn't have a bad smell.
Ford 7.3L Power Stroke (1999-2003) :: Little Vibration From 42 - 45 Mph
I'll get right into it, when I put the mud grips on my truck it always had a little vibration from 42-45 mph and it wasn't to bad. Recently from 30-65 I have a bad shuddering vibration that I get mainly in the steering wheel but I also feel it everywhere else and can see it on the mirrors. Well the front sway bar has a bushing that is broken. But also I notice recently at low speeds from my rear drivers side tire there is a noise that isn't right, maybe a bad bearing? I have a long list of stuff I gotta do on the truck and I just want to stop the Shake so I can get to everything else.
View 14 RepliesFord 7.3L Power Stroke (1999-2003) :: F250 - Bad Vibration And Under Power
As I'm cruising once I hit about 50mph I start getting a vibration in the peddles and floor board. It's not real bad but noticeable for sure. When I hit 70mph it's worse and the truck even sounds like it's vibrating. As soon as I let off the peddle and coast everything is golden.. Smooth.. So it seems to be a problem only under power..
A little back story : About a year ago I was getting bad vibration and loosing power. I put it in the shop and the mechanic said the filter or screen in the gas tank was clogged so he cleaned it. I went to Korea for a year so the truck sat in government storage for a year. When I got it back in March I put in back in the shop to have the front passenger side hub replaced.
I don't know if any of that has to do with the vibration I'm getting now.
Truck
2003 F250 ext cab
7.3l
179k miles