Ford 7.3L Power Stroke (1999-2003) :: Surge During Hill Climbing
Decided to try a new wheel to see if I can stop the surge during hill climbing with our 5er. Old wheel looked great with no dusting or nicks. New wheel sure has a whirl when it spools up, but sounds cool. Haven't pulled trailer since swap yet. Truck still only has 85k on the clock.
View 7 RepliesFord 7.3L Power Stroke (1999-2003) :: F250 - Code P1211 - Service Engine Light Pops Up Going Steep Hill
I have 2003 f250 7.3 automatic 181,000 miles completely stock. Never had chip,tuner or anything on it. I am second owner and got it when it had 70,000 miles on it. Ok here we go I live on top of a mountain and soon as i start up the mountain or any steep hill, or pull or tow something my service engine light pops on. First time it came on I took it to diesel shop they hooked it up to scanner and said it was code p1211 said icp sensor was bad so they put new one on. Couple days later light started popping back on so i decided to order a auto ingenuity after doing some research.
Hooked up to truck started up mountain while scanning at wot light pops on code p1211 and think it was live data I remember seeing icp pressure at 1922 and duty cycle at 63% i was trying to drive and read it at same time and my lap top went dead. What does this reading mean 1922 pressure/ at 63% cycle done little research but dont really understand. Year and half ago replaced all orings on all injectors, new rebuilt hpop pump. New ipr valve, glow plugs, past month 2 different icp sensor new,and new ipr valve new pig tails on both and light still popping on.
Ford Excursion :: Rumbling Vibration And Noise While Climbing A Steep Paved Hill At 5 - 10 MPH
Ok...not sure were to go with this or how to explain it, while climbing a steep paved hill at 5-10 mph I get a rumbling vibration and noise. If I were to guess almost like axle wrap is causing the U Joints to bind or something. Runs and drives fine other then that. If I put it in 4x4 it does not happen, only seems to happen when wheels cant slip while climbing hills at LOW speed.
Don't notice it if climbing a dirt hill. There is a hill at the kids baseball fields that is steep and paved that its really bad on, way to busy right now to play on it to see what's happening. Tranny was looked at and oil changed.
New BDS 4" lift - had same issue prior to lift, though stock springs were worn.
Searched the form but really didn't come up with anything at this low of speed. While in Wisconsin the resort we were at the paved hills were so steep it felt like something was going to break. Put it in 4x4 and it was fine. This was with stock leafs.
Ford 7.3L Power Stroke (1999-2003) :: Slight Creaking Sound Coming From Front Driver Side
Tonight on my way home I noticed a slight creaking sound, coming from front driver side, opening the window it was more noticeable. So when I got home I have tried to locate the source, it is the same with or without the engine running & you can hear it by rocking the steering just a little left to right. It sounds like a dry bush, I had my good lady rocking the wheel while I climbed underneath but couldn't pinpoint it, so I climbed up on the fender with my weight on the radiator support & the battery cover, when she turned the wheel the sound was almost gone but as soon as I jumped off it was back! I then tried rocking the truck from the driver side fender & the sound is there but not quite so pronounced, Any other way before I spray everything with WD40 (don't know if you have that over there but it usually quietens things like this!) There is no play on anything anywhere & the truck has only around 32k miles.
View 4 RepliesFord - Explorer :: 1999 - Air Stops Coming Out Of Vents When Get On The Gas Or Climbing A Hill
I have a 99 explorer that stops blowing air when I get on the gas or climbing a hill. The motor is still blowing but it stops air coming out the vents. What could be causing this? It works fine other than that.
View 3 RepliesFord - Explorer :: 2003 - White Smoke After Long Steep Hill
I have a 2003 Ford Explorer with around 93,000 miles on it. I got the oil changed just before going on a long trip. It had been about 4,000 miles since the last oil change. My trip was about 3.5 hours in each direction with mostly highway driving where I was cruising at around 65-70 MPH but some long steep hills mixed in as well. On the way to my destination after cresting over one of these long steep hills, and going about 60 MPH while heading up the hill, white smoke started billowing out of the exhaust every time I hit the gas pedal.
I pulled over and white smoke was creeping off the muffler as well. I'm not very mechanically inclined, but opened up the hood anyways, and no smoke or anything in there. I let the car sit for about 5 minutes until the smoke stopped creeping off the muffler then drove the rest of the 30 minutes or so to my destination with no more problems.
On the return trip, the same thing happened (different hill) with about the same timeline. I was about 30 minutes out from home, had just crested over a long steep hill going around 60 MPH and the white smoke started coming out again every time I hit the gas. Pulled over again, waited for the smoke to dissipate and for no more to be coming off the muffler and finished my drive home with no problems.
I've only owned the car for about 6 months. I haven't encountered anything like this up to this point. And in the month or so driving it since the trip and incident, I have not seen any white smoke . There are no warning lights on, the temperature gauge looks completely normal. From what I have read online it seems like coolant would be causing this white smoke, but I can't figure out why it only happened on these two occasions. What is going on or what I should do?
Ford F-150 - 1997-2003 :: CEL Came On When Coasting Down A Steep Hill - Code P0174
I was coasting down a steep hill yesterday when the CEL came on. I pulled the code this morning and got code P0174, system too lean bank 2.
I cleared the code. Should I just wait to see if it happens again? The truck is running great. There is no sign of a problem. BTW, it's 99 F150 5.4.
Ford Super Duty (1999-2016) :: Vibration Mostly Noticeable While Under A Load Like Climbing A Hill
My current 08 duty was bought with what I believe to be a procomp 6" lift modified to an 8" lift. The 100 mile drive home after buying the truck showed a tiny "hop" in the rear. I ditched the 37s for some new 35s. Still a tiny hop, mostly noticeable while under a load like climbing a hill. I pulled the rear driveshaft and had it fully rebuilt with a new carrier bearing as well. Still gots the hop? The truck has a carrier bearing drop bracket but I think it may be insufficient for the lift.
The rear driveshaft still has a slight bend in the middle of where the two driveshaft pieces connect. Are the 2 piece driveshafts on your 8" lifted trucks sitting straight with each other or do they have this bend as well?? I am thinking if I get a bigger drop bracket it may cure this slight hop I have? Lots of lifted trucks where I live but they are dam near all shortbox with 1 piece rear shafts so I haven't been able to find one to compare. By the way, my truck also has pro comp rear traction bars..
Ford 7.3L Power Stroke (1999-2003) :: Noise Started While Pulling A Hill At 65 MPH
99.5 7.3. 201,450 miles, Just developed a new noise. Was on interstate, in cruise, 65 mph, started while pulling a hill. Kicked it out of cruise and noise went away. I have found it will repeat just pulling a hill at highway speed.
Now for the noise....it almost sounds like lightly opening the secondaries on a gasser 4 barrel. I don't see anything unusual under the hood.
Ford 7.3L Power Stroke (1999-2003) :: Truck Will Hit About 22 Psi Then Drop Off Slowly When Pulling A Hill Hard
I just got my new up pipes put on as well as a 38R and pulling a hill hard my truck will hit about 22 psi then drop off slowly I have an electronic boost fooler wich has been on the truck since new pretty much but I don't get a CEL at all is this what I should be getting and I was on the 80hp tune? I ordered new boots and plenum inserts they just haven't got here yet. I know I had a leak before on my old up pipes because they rattled every now and then and I could see exhaust coming out of them when it was cold out but I could hit about the same 22 boost with my old setup. So pretty much nothing changed boost wise except it gets up to boost faster now. I would say it's defueling but I was always told the CEL would come on if that was the case.
View 13 RepliesFord Super Duty (1999-2016) :: Transmission Not Shifting Into Tow Mode When Pulling To A Steep Hill
I have a 2006 f-250 super duty with a 6.0 and auto trans. I was pulling a trailer with about 5k of vehicle on the trailer.
Problem : after a long trip on good roads, I had to pull a steep hill. climbing the hill i did not shift into tow mode and all of a sudden my engine raced up to about 3k rpms and seemed to either shift to low or ( maybe ?) the Governor may engaged ?
Anyway I made it to the top of the grade and it seemed to be fine from there.
Question Is the trans broken, or did the computer maybe try to protect the trans ? It seems to work fine still?
Nissan - Sentra :: 2003 - Burning Smell When Started Up A Very Steep Hill And Went Into 1st Gear
My 2003 Nissan Sentra was doing fine a few days ago until I started up a very steep hill and went into 1st gear. There was a burning smell for about 2 blocks so I shifted to 2nd gear. The smell went away. When I was in 1st gear it did not sound or feel like I was trying to go too fast for the gear. I just smelled the burning. Same hill in 2nd, no smell. How much should I worry?
View 2 RepliesHyundai - Sonata :: Cylinder Misfire / Power Loss While Going Up On Steep Hill
I am not a mechanic by any means, but have picked up a lot of stuff over the years. I drive a 2003 Hyundai Sonata with a 4 cylinder engine. Several days ago while going up a steep hill I lost power and my check engine light came on. This has happened before when my coil went bad so I figured it would be a breeze fixing it. I limped it home and ran the code. Sure enough it came back as cylinder 1 misfire. This vehicle uses 2 coils so I swapped them to try and get the problem to follow, but it did not. I have tried a new spark plug, new wires, and swapped injectors without success. There is still no activity on cylinder 1.
I ran a compression test. I get about 60 PSI on cylinder 1 and between 180-210 on 2-4. This would point to head gasket, so I am told. I do burn about a quart of oil every 500-1000 miles, but I do not seem to have any coolant leaking issues. I have not noticed any smoke from the tailpipe. The spark plugs were generally good looking, except for number 3 which had a hard white substance all over the electrode. There does not appear to be any oil in the coolant or coolant in the oil. This seems strange to me as everything I have read said that one of those would happen.
Is there anything else I should look into or is my engine toast?
Ford 6.0L Power Stroke Diesel :: 2003 - Slight Popping Sound Coming From The Top Coil Area
I blocked off the hpop discharge tube to test for leaks, shop air. I am plugged into the oil rail drivers side, and keep getting a slight popping sound. The first time I did this it took ten minutes to start, so I replaced the top injector seals. The second time it did this after about four minutes, so I took the oil rail to the local shop and they did the ball tube orings in the rail, now I went to put it back on and it does it almost right away.
Am I just pushing the oil out of the injectors? is this normal or should I have NO air noise period? I guess I am not sure how these injectors work, where does the oil go after it enters the top of the injector? It seems like it's coming more from the top coil area, more so perhaps than under the oil rail.
Prius (2004-09) :: Complete Loss Of Power On A Steep Hill Climb With Cold Engine
A few days ago I posted a thread about losing power on a steep hill climb with a cold engine. I replaced the hybrid battery and all seemed well. A few days later, the problem occurred again--bummer. (The car has 120K miles and has spent most of its life in a hot and mountainous environment, and I knew the hybrid battery was failing, so that's not a problem.)
The car starts the climb OK, gains a few hundred feet in elevation, still has some charge left in the hybrid battery, then loses power, surges a couple of times, then comes to stop. The engine continues to run at idle and I get no warning or check engine lights. The "ready" light stays on. This time, the second time it happened, I turned off the car, turned it back on again immediately, and all was well. The remainder of the 1000' climb went fine. As did several other similar climbs on the same drive. Since then I've climbed this hill with a cold engine without a problem, so it's intermittent.
I hesitate to pay Toyota for a code scan since the check engine light did not come on. Should I do this anyway? My local auto parts store will scan for free, but I know that their scanner will not read Toyota-specific codes, just industry standards.
Passat (B5) :: Hesitation And Occasional Deceleration When Climbing On Steep
For no apparent reason, my 2001.5's 1.8T, with less than 67,000 mi on it, suddenly began "hesitating" when power was called for. I first noticed this while the car was climbing steeply one side of the (very tall) Newport Bridge. I could feel the occasional deceleration as I tried to maintain constant vehicle speed (with and without using cruise control), but could see no change in vehicle speed or engine rmp on either the speedometer or tachometer. It felt as if fuel flow to the engine had decreased a bit for a second or two and then returned. This occurs consistently and is most noticeable when accelerating from a dead stop as I'm climbing through the gears (manual transmission). Also, there's no apparent turbo boost. Are these classic symptoms of a failed turbocharger (or something else)?
View 11 RepliesFord 7.3L Power Stroke (1999-2003) :: Slight Roar At Low Throttle
Ok, still working out some issues: It may be normal, but I hear (not feel) a slight roar when I'm pressing throttle petal very lightly. Seems to do it as we'll when I'm backing off throttle but it stops when I let off pedal completely. Not there when I get into the pedal. Not the tires because it stops all together when I get off throttle and let it roll. Turbo maybe ? Rear end (wouldn't it do it even when rolling)? No vibrations at all....just a little roar.
View 9 RepliesFord Excursion :: V10 4r100 Transmission - RPM Dropping When Climbing The Hill
Today I was 160 miles into a 250 mile drive and things were going well. I was cruising at about 75-80mph and approaching a fairly long hill of moderate grade. As I climbed the hill, my rpm was dropping, as expected before a downshift. The downshift never happened. I kept pushing more pedal and eventually, at maybe 40mph, it downshifted, but still no power. Engine being held at around 2500 rpm. No power no matter how much I pushed. Down hill I was able to resume speed but as soon as the next uphill, same thing, no power, no shift. Pulled over, it was raining hard. Checked for wet fuse box, control modules, pcm, wiring harnesses, everything dry. Checked all fuses. Disconnected battery in hopes of forcing reset, no change.
Checked trans fluid, it was clean, red, full, and unburnt. No visual wires broken or chafed. No odd smells or sounds. Nothing noticeably hot. Truck hits 45mph max on flat ground. I limped it this way for 20 miles. If I push my foot to the floor to really force a downshift, engine will rev freely up to redline with no resistance once it downshifts. If I let the rpm drop down, it will catch and lock back in. Now when I come to a stop the truck has a very lopey and rough idle and will stall once I come to a complete stop. It will stay running if I give it gas. In neutral and park the engine still has a lopey idle and is rough. Will possibly die at times. Sounds smooth and perfect when you rev it in neutral or park. Reacts as it should with no hesitations. No check engine light and no flashing OD light. Will shift into all gears, just moves through them with no power. Let truck sit for 3 hours, issue remains.
Ford 7.3L Power Stroke (1999-2003) :: Slight Vibration And Front End Noise
Recently I have a vibration that I can feel slightly through the steering wheel. If I'm driving down the highway doing 70mph + I have a noise coming from the front end. Also while driving let's say 40mph and below and I let off the pedal to slow down I can here a vibration in the front that kind of sounds like a small Jake break. And when going over anything bumpy I hear like a popping metal sound. This popping sound has been going on for a long time and still can't figure it out. I replaced all my shocks thinking my old set was bottoming out. Nope, still have the same problem.
I jacked up the front end yesterday and checked for movement top and bottom and side to side thinking maybe the wheel bearings or ball joints were going. Everything is solid. Spun the wheels and no noise, no grinding, nothing. I can't figure it out. I have not removed the wheels to check and see if a caliper is loose. I will be checking that next. I did notice while looking around that I can push up on my pitman arm on the steering box. It's not a huge amount of movement but I can still move it. I can also see teeth marks between the box and the arm, not sure if that is normal or not. When I do move it up and down it sounds a lot like that metal popping sound I have been hearing. So, I know this is a lot.