Ford - Explorer :: 2004 - Loud Knocking Noise Coming From Under The Dash
When you turn the interior ac temperature from cool to warm there is a loud knocking noise coming from under the dash. I am new to working on explorers but it seem like its coming from the black box nearest the firewall above the transmission tunnel. When you turn it to cold the noise almost completely goes away. The noise gets even louder when you mess with the selector for "max ac" "head and feet" "feet" etc.
View 2 RepliesFord F-150 - 1997-2003 :: Dash Brake Light Not Coming On When Turn The Key On
98 F150. Failed inspection for the dash brake light not coming on when you turn the key on. It comes on with the park brake set. Should it come on with key on as a bulb test?
View 7 RepliesFord F-150 - 1997-2003 :: 2000 - Loud Noise From Dash Area?
2000, F-150, 35K +original miles. 4.6L V8
Some weeks ago a noise started that sounded like fan blades striking against heavy plastic fan guard. At first I thought it was coming from the transmission/Transfer case area but after a few weeks of listening to I now believe it's coming from behind the dash area, however, I can't find any reason for it be from there.
The noise usually starts around 45 MPH
I checked the heater fan and it appears to be Okay. I don't know of any other fans in that area.
Ford F-150 - 1997-2003 :: 2001 - Occasional Knocking Noise Coming From Engine
I have a 2001 F150 4x4 4.6L Auto trans. 96,000 miles... I purchased it in Jan with 93,000. About a month ago it started making and occasional knocking noise coming from the engine, this noise was heard at idle in park and in drive. when I revved the motor it would go away but as the idle settle back down you could hear it again. the noise would go away as I was driving and come back with no rhyme or reason, I put a stethoscope on the engine and it seemed loudest under the oil pan. The oil gauge is up between 5/8 to 3/4. Fast forward to now, When I start it I hear a scraping almost grinding noise that resonated thru the cab it has the same intermittent characteristics. I think I am going to remove the serp belt, remove the trans inspection cover next and see what happens. Oh I did put a scan too on it, no codes but did notice 1 long term 02 sensor trim was staying around -.618 if I remember.
View 11 RepliesFord F-150 - 1997-2003 :: 4wd Not Working - No Noise Or Lights On Dash When Turn The Key
I am working on this 97 F150 with the EOTF. It is not doing anything. When i turn the key on, no light on the dash comes on. When i operated the 4wd switch, nothing happens, no lights on the dash, no relay clicks or transfer case noise, etc. It has a new t case motor, the switch tests out good. I have researched for a while, and either find people with different symptoms or the original poster never updated with what the fix was. I am unsure where to go at this point, i am suspect of the GEM or the t case relay, but don't want to go replacing stuff without a basis for going so. Ive tested for voltage at the switch as well and it has 5 volts at pin 3.
View 13 RepliesFord F-150 - 1997-2003 :: Loud Grinding Noise When Braking Coming From Back Tires?
I have another issue. I just started having problems when braking. Every time I brake there is thing loud grinding noise that sounds like it coming from the back tires but there isn't a squeaking noise like there is where you need new brakes what else could this be??
View 2 RepliesFord F-150 - 1997-2003 :: Loud Popping Noise Almost A Clunk When Making A Slow Sharp Turn
Lariat stepside, 5.4L with 150k miles. Loud popping noise, almost a clunk, when making a slow sharp turn. Put it on jackstands and did the normal tire grab and shake and found no issues there. Tie rods, ball joints and sway bar links all seem tight. Looked for signs of unusual rubber to metal and metal to metal wear and found nothing. The only thing I did see was the rubber boots on the upper control arm ball joints were split. What I have checked or if I am missing something?
View 9 RepliesFord F-150 - 1997-2003 :: Starter Turn Over Strongly For Half A Second Then Makes A Loud Noise And Stops
Ford F150 truck, when starting, the starter will turn over strongly for half a second then just abruptly makes a loud noise and stops. It won't ever fully crank. Is this just a bad starter?
View 2 RepliesFord F-150 (2009-2014) :: Loud Knocking Noise - Oil Pressure Light Coming On And Off
2012 F150 6.2L V8... I am at a loss and I know that loud knocking is not a good sign. Two days ago my truck's low oil pressure light started coming on and off, so I pulled over and immediately turned my truck off. I called a friend at a Ford dealership and he asked a mechanic what I should do. He said it could be something as simple as low oil, bad oil sending unit or maybe something serious. So, he said check my oil level if low top it off and see if that fixes the problem. It was low and I topped it off, but the light kept doing the same thing.
Here's my dilemma; my truck wasn't making ANY noises (knocking, whining, etc...), 2 days later which was yesterday I was en route to get new oil/oil filter changed and 24 miles later I'm in a turning Lane and it dies! Will not start, but it tried, so I did not try anymore. I was able to get it into a parking lot and left it for about 4 hours and went to check on it and it started right up and that is when the knocking noise started. I turned it off and checked the oil and the level reads full...
Ford F-150 - 1997-2003 :: Loud Knocking At The Passenger Side Valve Cover - Camshaft Not Getting Oil
I have a 98 F-150 which has a loud knocking at the passenger side valve cover. I am not a mechanic but thought it was a rocker arm knocking. I dropped some oil from the oil pan and did not see and metal shavings. I added some mystery oil but the knocking continued.Loaded the truck on a trailer and hauled to a mechanic to check for the problem. He said the oil ports are clogged and oil can not get to the cam shaft and the cam shaft bearings are probably causing the knocking. He said there is no way to fix this problem and I will have to replace the motor.
I called another mechanic and described what the other mechanic described. The 2nd mechanic said it would require a complete tear down of the motor and would be cheaper to replace the motor. I recently bought this truck just to use for hunting and around town since it already has 198k miles on it.
Is there any way to clean the gunk from the oil ports? The truck will still run but just has the loud knocking so I don't let it run for more that a couple minutes. I have been reading many opinions for sludge blocking the oil passages and am considering removing the valve cover gasket and filling with diesel and let sit for 24 hours then repeat then put in fresh oil and filter. Maybe this will clean the blocked passages.
Ford F-150 - 1997-2003 :: No Restart / Clicking Noise Coming From Behind The Fuse Panel When Turn The Key
I have a 1999 f-150 and am having a problem that I cannot pin down . After starting the truck and running it for 10 min or so I shut it off and it will not restart again for approx. 3-4 hrs . When you turn the key there is a clicking noise coming from behind the fuse panel . Also the truck will not start if temp outside rises above 80 degrees . Is there a replaceable relay under there or is it the computer module ? Battery is new .
View 9 RepliesFord F-150 - 1997-2003 :: Loud Click From Under The Dash
I have a 97 F-150 v6 with 62K miles on it. I went out the other day to start it and all I got was a loud click from under the dash. I figured it was the battery. Late for work already, I just drove the wife's car. This morning I tried to jump it, nothing, just the same loud click. Headlights are good and bright. I'm no truck mechanic so I was maybe thinking solenoid or starter.
View 5 RepliesFord F-150 - 1997-2003 :: Knocking Sound Coming From The Top Of Engine
New to owing a ford pickup. I bought a 2002 Ford F-150 lariat 4x4 as a project truck. I've always wanted a truck to mess around with, but once I got the truck home I noticed it had a knocking sound. It didn't sound like it came from the top of the engine so I checked the muffler first and found it had a 3" slit in it. I replaced it but the sound remains. I heard it could be lifters? Is that something I should mess with or not?
View 8 RepliesFord F-150 - 1997-2003 :: Rod Knocking Sound Coming From Bell Housing
I have a 2003 F-150 4.6 4X4. I had a knocking sound that sounded like a rod knocking but was coming from the bell housing. After some research, I found that it could be a cracked flex plate or bad torque converter. I bought and installed a new torque converter with no change. The flex plate didn't appear to have any damage but went ahead and replaced it with the same results. I actually started the engine by jumping the starter (with no transmission) and the sound was coming from the flex plate/dust cover. My question is do I need the dust cover? Or is it a bearing or something else inside the engine causing the flex plate to hit the dust cover?
View 3 RepliesFord Super Duty (1999-2016) :: Loud Knocking Noise Coming From Left Valve Cover Area Occasionally
I just picked up a 2001 F350 with the 5.4L with 200k miles. When I test drove the thing the engine sounded fine. I got it home and noticed that it occasionally has a loud knocking noise that is coming from the Left Valve cover area. It sounds like an old Chevy 6.5L Diesel ...
It comes and goes, Hot or Cold. It seems like it usually goes away when driving with RPMs above 1500 or so, however I took off with it yesterday and the noise would not go away, it seems like it might be low on power when the noise comes on, but then again it always feels low on power, so who knows.
I have changed the plugs, oil, and verified there are no exhaust leaks at the manifolds.
Here is a video of the noise: YouTube....
I dont think it is the timing chain, as it seems like its coming more from the center of the cover, when placing my hand on the cover near the timing set there is no vibration or anything that would lead me to believe its the chain.
All of my searching so far turns up 3V stuff, and little info on the 2V engines. The valve cover looks like a nightmare to get off, who have to work on these things (including me).
Ford - Explorer :: 1997 - Loud Banging Coming From Front When Turn Left Or Right
1997 Limited SOHC auto.
I just replaced the transmission with a known good one from my XLT but the reverse doesn't work now and there is a loud banging coming from the front when I turn left or right.
It feels like the tyres are slipping on the road, like axle wind up. This happens in auto and 4wd high. What the banging is?
Chevrolet - 1500 :: 1993 - Knocking Noise Coming From Passenger Side Dash
1993 chevy silverardo ... There is a knocking noise coming from passenger side dash i turn the key on it starts tell maybe i get down the road, when i turn the truck off it knock for like 25 secs. I just got the truck didn't find out until I took it home.
View 8 RepliesFord Wiring/Electrical :: F250 - No Power / Loud Buzzing Noise Coming From Under The Dash
Tried to start my truck after sitting for 2 days in sub zero weather. wouldn't crank. pulled the batteries and charged them over night. Tried to start it the next day-wouldn't crank but the starter relay clicked. Was going to pull the starter and check it but decided to replace the relay first. replaced it and tried to start but now have no power to the cab-nothing comes on. I've checked the batteries with a load tester and they are ok. I've checked the fuses and they seem to be ok. when I tried to start it and the relay clicked there was a loud buzzing noise that seemed to be coming from under the dash. it has done this before but this time was louder than usual. I live out in the sticks so taking it somewhere is a last resort. It is a 1999 7.3 with 290000 miles.
View 14 RepliesFord 7.3L Power Stroke (1999-2003) :: Loud Knocking Noise - Failed Cylinder 8 Contribution Test
My truck is currently stock and recently started making a knocking noise louder than it usually does. I researched and have found the injectors can make a knocking noise when not performing correctly. I took it to a local shop who hooked it up to a snap on scan tool and ran some tests. It passed the Buzz test but continually failed the contribution test on cylinder 8. I'm going to go home and remove valve cover and unclip the injector to see if the noise goes away. I'm sure hoping it does as an injector by the looks of things is definitely the cheaper option. I'm scared because if I was listening to a gas powered truck and heard the sound my trucks making I would assume it was a lower end noise. My truck only has 148,000 miles....
View 14 Replies