Ford F-150 - 1997-2003 :: No Crank / Won't Turn Over Or Even Make A Click Noise
I have a 99 f150 2wd v6 4.2 liter engine. Im going to sum up what happened and what I've done so far. One morning truck wouldnt start. Wouldn't crank, turn over, or even make a click click noise. I tried jumping it just to be sure but it didnt do anything. Battery is fine, interior lamps, displays, and radio all work fine.
I took the starter off, had it tested, it was bad so i got a new one. Still had the same problem. Finally, i got underneath the trunk and bridged the positive and negative on the starter solenoid and it fired right up. So the starter is not the problem.
Next I looked into the starter relay, if I bridged the positive and negative on the starter relay it fires right up just like the starter. But since that is only bypassing the starter relay, it didnt tell me whether the starter relay was good or bad. So I got a new starter relay and it worked! It started with the key with no problem 3 times! I thought the problem was fixed but when i tried to start it an hour later, nothing... Same problem as before.
I checked all my fuses, none were blown.
I'm under the assumption that either something leading to the starter relay is making the starter relay go bad OR there isn't enough power going to the starter relay. Maybe something in the ignition, even though my accessories are all still working.
It is the only vehicle I have to and from work. For now I am getting by with bridging positive and negative on the starter relay to start it but that is only a temporary fix.
Golf IV / Jetta IV :: No Crank Just Single Loud Relay Click From Engine Compartment
So I drove my car about a mile to a friend's house and when I went to start it back up 10 minutes later, I got no start and no crank. Just a single loud relay click from the engine compartment. Tow truck tried jumping it and then thwacking the starter solenoid to try and get it going. No dice. Battery seems all good.
Had some interesting things go wrong the day before which may be related to it. First, I was tracking my MPG and fuel trim on a highway trip and the trim and fuel consumption data just stopped coming in. Speedo and RPM data was still coming down the OBDII but I just assumed that my reader took a ****. Later that night I noticed that the lights on my climate control (the manual kind) went out. Tapped on it and it came back on, but only briefly. The bulb looks shot.
No engine strangeness on the drive over or earlier in the day. I drive it most every day. Has 215,000 miles on it.
I'm guessing either a short or bad starter. FWIW, I've also been experiencing the typical starter whine after starting. Was meaning to take it off and grease it. Not sure that has anything to do with it. I also tried rotating the crankshaft to make sure the engine wasn't locked up and it does turn, albeit not incredibly easily. It does have oil on the dipstick.
Saturn - SL1 :: 2001 - Intermittent No Crank Or Start / Single Audible Click Occurred When Key Turned
2001 Saturn SL1, 143,000 miles; well maintained. For about a week, I had intermittent no crank/no start. Lights and radio worked. A single, audible click occurred when I turned the key. When I was able to start the car, it ran fine. I suspected a failing starter.
The next time I tried to start the car, however, it roared to life only to run like an asthmatic locomotive. It idled low, at about 500 rpm, and shook badly. When I stepped on the gas, the engine smoothed a bit and the headlights flickered. There was no CEL or battery light, except for one brief moment when I revved the engine to about 2000 rpm.
Now, when I try to start the car, it starts just fine, but runs for about 2 seconds before stalling out. I installed a new battery in September 2012 and I changed the plugs in early 2013 – both routine, preventative measures.
Any chance I flooded the engine while trying to start it, even though it's a fuel-injected engine? If so, how do I "unflood" it?
Camry :: 2002 - When Turn The Key It Makes Single Click But Won't Start
My camry suddenly won't start. when i turn the key it makes this single click but won't start. Battery seems to be good. bad starter?
View 10 RepliesFord F-150 - 1997-2003 :: 2002 V8 - Click In Dash When Turn The Key - Bad Relays?
I have a 2002 F-150 xlt 4x4 5.4l V8, 96k miles. been sitting about 3 weeks i went to start it and nothing.. thought ok jump. We tried jumping/charging the battery nothing. then we switched batteries from running car same thing when i turn key just hear a click in dash. battery light remained on even when we swapped out. The theft light was off as well.
View 1 RepliesS-10 :: 1997 Blazer Leading Up To Crank But No Start Condition
Wants to crank. I notice when I turn the key switch on (not start) the gas gauge pegs out as if a super full tank and no fuel pump noise. At times, leading up to the crank but no start condition, I would turn the key on, hear the fuel pump and the gas gauge would indicate proper fuel level. When this happened, the vehicle ALWAYS started.
Here what I know now;
1. Fuel pump works. As indicated by the red auxellery jumper lead inside the engine well.
2. Good fuel pressure.
3. Starter checks good.
4. Battery hot and leads are cleaned.
5. Grounds in engine compartment and at fuel tank are cleaned.
6. Vehicle does have gas.
7. Air bag light stays on, even after pulling battery leads, letting set, and reinstalling.
This ABS light would come on and go off independently before the "crank but no start condition". So I'm assuming that the ABS might be its own problem; but not contributing to the crank but no start condition? There were problems leading up to the no start condition. Vehicle began to become hard to start (but would start). After starting (at idle) if the gas pedal was pressed aggressively, the "service engine" light would flash on and off rapidly and the "ABS" light would come on. At this point the vehicle wanted to die. No apparent codes were given.
Now the "crank but no start condition". Before this problem, the vehicle was sending the code for 3 o2 sensors. But a new fuel filter corrected this problem completely with no further apparent problems. Then (about 4 weeks later) the "crank but no start". I do not think the fuel filter and the "crank but no start" problems are related.? No other maintenance has been done to this vehicle that might cause this problem. At this point the manual I am using is useless...
Ford - Explorer :: 2002 - No Crank Just Click
2002 explorer 4.0l. No crank just click new starter in and cables hooked to battery...
View 1 RepliesFord F-150 - 1997-2003 :: 2002 - Shuts Down While Driving And No Crank
Having problems with the truck - either a no crank situation and now a complete shut down while driving at any speed.
Dash is blank with no power when truck shuts down, here is the hitch with the no crank, I pulled and replaced the PCM module and the truck fired up without hesitation. I had to do this a few times over the course of today to get home. I can live with having to do that for a while but it is unnerving to have the truck shut down with 0 notice.
Throttle body was just cleaned, and all starter/battery connections cleaned and protected. Brand new PCM relay. What does this relay have to do with reset, for clean start up after removing it and then just putting it back in it's place? Would there be any solutions for the dies completely while driving, or fails to crank?
Ford F-150 - 1997-2003 :: 2002 - Crank But No Start Or Spark
I have a 2002 F150 5.4L (VIN-L) that has been sitting in the driveway since February. I have been a mechanic for 30 years for large commercial trucks, and my own truck has me stumped. I'm sure I've forgotten something but I'll try to list everything I have tried so far. It started with crank no start, no check engine light, checked for trouble codes got a trouble code for the CHT(cylinder head temperature) sensor.
- Replaced the CHT sensor. Cleared codes.
- Dash lights up fine, shows mileage, and anti-theft is not flashing while cranking.
- Fuel Pump does not seem make any sounds. Hit the tank with a hammer. Nothing.
- A little fuel comes out of the schrader valve on the fuel rail when I push on it. I have not checked it with a pressure gauge.
- Attempted to start with ether, nothing, so I'm assuming no spark.
- Fuel pump inertia switch isn't triggered.
- Checked several ground connections to the frame and checked ground connections in the PCM harness. All have less than 5 ohm resistance.
- Unplugged and plugged back in cam shaft sensor.
- Checked voltage on the TPS(throttle position sensor) I'm unsure about the results, if the TPS was bad wouldn't it just idle funny and/or stall?
Fuel Pump and PCM relays in the underhood fuse block appear to be good. All other fuses and relays appear to be good. I have been swapping the relays with one I think is good, although. Searched all over for additional relays, and found 3 inside the cab behind the passenger air-bag. Can't seem to find anything in the Haynes/Chilton manual that lists what they do. They are about half the size of the fuel pump relay.
Manually grounded the fuel pump relay, relay clicks but I don't hear a buzz from the fuel pump. Id like to run 12V to the fuel pump directly to see if that's my issue, but I'm not sure where to connect it without frying something important.
I bought the alldata.com DIY guide for my truck and it hasn't worked much. I have read extensively about others with similar problems and I just don't know what to do next. My main question here is, if the fuel pump is bad, would that stop the spark plugs from working? I'd rather not replace the fuel pump without being absolutely sure.
Ford F-150 - 1997-2003 :: 2002 V6 Will Not Crank But Engine Turns Over
After short trip, 02 f-150 v-6 will not crank every time but engine turns over. When it does crank, it runs fine the entire trip. 189,000 miles on motor and is a 4x2 extended cab.
View 1 RepliesFord F-150 - 1997-2003 :: 2002 - Starter Did Not Turn Or Crank The Engine
I have an 02 f150 5.4 4x4, drowned it a while back, thought i had hydro lock, crank can be turned by hand though as far as i can with a wrench, so internals seem to be fine, no bent or broken rods that i could tell, ripped everything apart cleaned it up put it back together, new fuses, new ignition relay, new starter, alternator and battery as well, turned the key to on and got all my electronic stuff back up, turned to start and it all goes dark, which i assume is because at that point its sending power to the starter, but the starter didn't turn or crank the engine...
So question being when i put my new starter on is it possible that i might have crossed a wire or something that would cause it to not crank? and due to the fact that I had water in it, and had hydro locked it, all my plugs are out, now I know that spark is needed for the engine to run, but shouldn't be needed just for the crank to turn right? question being is that once i fix the wires on my starter, I am looking for initial crank before start up, so do i need to put a plug or two back in and hook them up to make it crank? or will it crank without them? and yes I did replace all my fluids as well.
Ford F-150 - 1997-2003 :: 1999 - Intermittent No Start Condition
The Truck...
1999 F-150 Supercab
170K miles
4.6 Litre
Automatic Trans
The Problem... About every other day, I try to start the truck, and it doesn't fire at all. It cranks fine, everything seems right, but no start.
What I've done...
Replaced Fuel Pump Relay.. (no luck)
Sprayed Starting Fluid In and Cranked... It Fires On Fluid.
Other info...
This problem never lasts long, and the problem mysteriously fixes itself after no more than an hour.
This problem has occurred both when the truck was warm and completely cold.
Ford F-150 - 1997-2003 :: 2000 - No Start Condition In The Morning
I have a 2000 f150 4wd 4.6. It wouldn't start this morning. A few years ago I had to change the inertia switch so my first move was to bypass that, which didn't work.
After that I gave it a shot of ether to see if it would hiccup and tell me if I had spark or not. It started up, ran rough while the air cleaner was off, then cleared up and ran fine, and is now starting/running fine again.
The problem is that I have to take the truck on a trip Saturday, and I can't figure out what the problem was if the truck is starting. What it could have been? No check engine light or anything either.
Passat (B5) :: 2002 GLX Stalled - Small Click Inside Relay Panel But No Crank
B5.5. Here is what happened: Was driving as usual, running low on gas. Cluster was showing zero miles left for last 10 miles. I successfully made it to the gas station. Trying to open lid - maybe on third press it popped. I thought I'm just imagining things. Drove home another 5 miles. Trying to open trunk - same as gas lid, eventually opened. I turn engine off. No dome light. None of the dome lights working. Everything else appeared still has power. Trying to open trunk again - it's dead. Trying to start the car - does not start. Trying to go home and lock with remote - not working. Lock manually and went home.
Next morning went to check fuses - all OK. Everything still not working just the way I left it. When ignition key turned - cluster comes up. When starter should crank I can hear small click inside relay panel and lighter power turned off momentarily as usual, but no crank. No messages on cluster. Dome lights, door locks by remote and starter/engine don't work. Gas lid and trunk don't work even from driver's door. If I press power lock on driver's door it will lock and immediately unlock all doors.
I did check power on fuses. Three engine related fuses don't have 12V on them. The fuses are 28, 29 and 34, or second and third up from bottom left and fourth up in second column from bottom left. Fuses itself are good.
Here I Got my first suspect: power for all 3 fuses above coming from same relay. I thought if I jump these fuses to live 12 Volts I might be able to start engine. I did jump one fuse at the time. I've heard fuel pump came up but nothing else happened. I understand that it can also be Motronic control for this relay. I pull my OBD reader, but found no codes or freeze frames. I don't have WAG reader.
But Motronic should not affect doors and dome lights (I think so but not sure), unless CAN bus shorted or something. Lights and doors can be related to Central Control and Convenience module, which supposed to be under driver seat. I had rear driver side carped wet few times when I just bought the car, but not lately, not in 6 months. I still think water damage can occur much later after exposure.
So here are mu suspects: Engine power relay, Motronic or Convenience module. It might be something else.
Ford F-150 - 1997-2003 :: 1997 - Click Sound From Converter After Reinstall Engine?
I have just finished changing head gasket. I started up the engine works fine. But I hear a little clik sound form the converter. I put it in gear, but it can't move either forward or backward. It ran 2-3 liters of oil out of the converter when I took the engine out. I have filled new oil in the gearbox but not in the converter, dosnt it came form the gearbox into the converter?Is there air in the converter or what's wrong?
it is a F150 4x4 4.6 1997 automatic.
Ford 7.3L Power Stroke (1999-2003) :: Relay Click When Turn The Key To Crank - No Start
Alright so I have a 99 7.3l. One day I went to start my truck and when I turn the key to the on position all is normal and then when I turn it all the way to crank it nothing happens. I hear a relay click ann thed that's it. Me and a buddy of mine spent quite some time on going through the entire truck. The starter was replaced, the neutral safety switch was replaced and the ignition switch was replaced yet the problem is still there. We then discovered that fuse #20 under the dash keeps blowing with every turn of the key. The manual states that this fuse is a starter motor relay coil PCM ( gasoline only). So if it's gas only why is it even in there. Let me just say that I can jump the fender mounted relay and the truck starts.
View 7 RepliesFord F-150 - 1997-2003 :: Loud Single Knocking Noise Coming From Behind The Dash When Turn Key On
The last couple days my truck (1997 f150 4.6l) has been having starting issues. At first it would just turn over and not start then the battery would die. So i bought a new battery and yesterday now its starts sometimes but when trying to start it while its ttuning over it stops then starts turning and starts up. Then i drive wherever I am going when i get back in to start there's nothing.
Its not turning over at all but when i turn the key there is a loud single knocking noise coming from behind the dash near the passenger floor vent. Actually there ate two noise from the same area, one when i initially trun the key and another when i release the key. But after just sitting there doing this it will finally turn over and start. What this is, there are no codes being thrown besides my dreaded P0401 which i cant seem to get rid of either. Ive changed every part that has to do with the egr system and cleaned the throttle body replaced vacuum lines and still the code.
Golf/GTI VI :: Single Click On Front When Turning Right
Last year I had a bad accident and my front passenger side tire completely ripped off. State Farm fixed it and all was fine. But About 2 months ago I've been hearing this single click on the right front when I was turning right and on the left front when I was turning left. Took the car to different dealerships, one barely looked at it and tried to charge me $300 for jacking up the car and tightening 10 bolts, the other said that my axle is cracked and leaking and recommended replacing my strut mount and sway bar links. So after those were done I drove it home and on the way back I heard the same noise but somewhere underneath my seat a couple of times when I accelerate and decelerate. The dealer took my car away for a week and a half to figure this whole thing out with state farm and forced me to pay for part of the rental car.
View 5 RepliesElantra MD (2010-15) :: Single Click From Front Of Car When Turning
My click sound is inconsistent, but typically, it's when I make a hard right or left turn. This being said, there are times I've was making a slow turn and my car still made the click noise. The turn can be a small one while in the lane for the off ramp of the freeway or a sharper turn around the corner. My impression is that when there is more force towards one side of the car, my steering wheel shaft is clicking. I also notice there's a click sound when I turn into a dip like when I drive out of a driveway onto a street that's lower than the driveway. The sound is also typically paired with moderate braking and turning. Someone who was in the car and heard the click and mentioned that it might happen when I make a sudden turn.
The single click is coming from the exterior of my car (I can hear it clearly when my windows are down) and around the engine area. I don't physically feel anything when I hear the click but I'm afraid that something may become an issue in the future. The click is also slowly driving me insane!!!
I've already gone back to my dealership and I bought this car brand new. It started happening almost immediately after I bought the car. When I took it in, they said they tightened a bolt (didn't specify which).
I've asked so many individuals and they can't think of anything. It's definitely not a CV issue because the car is brand new and the sound is a single click rather than a continuous knocking.