Ford F-150 - 1997-2003 :: 1986 - Shuts Off While Driving Intermittently?
My dads f150 shuts off intermittently while driving it. He has to pull over and wait about 5 minutes until it restarts again. We have tried replacing the fuel filter, still shuts off! Some one pointed out the coil!? I am thinking that it might be the switch. It might be bad, shorting out and shutting down the truck?
View 6 RepliesFord 7.3L Power Stroke (1999-2003) :: 2002 - Suddenly Shuts Down While Driving
This started about 6 weeks ago. While sitting at a stop light the motor cut out. After some research I replaced the cps. Truck ran fine for about 3 weeks, then shut down again while pulling into the driveway of a store. Replaced the cps again (this time with a ford one). Ran fine for another 3 weeks, then shut down again on the freeway. No CEL on any occasion.
It's just like someone turned the key off. No rough idling at all. No smoke during starting or driving. When it shuts down, it will not start again for 20-30 minutes, no matter how many time you crank it. It will just turn over, no sputter. When it fires up again there is no air in the lines either, it runs like nothing happened.
I'm now thinking it might be a ipr issue...is there a way I can check myself or does it need to go to the mechanic? Or is it something completely different? This is my mother in laws daily driver, 178k. She does not drive on the freeway, 80% of the mileage is city driving. What could be going on?
Ford F-150 - 1997-2003 :: 2001 V8 Shuts Off While Driving / Steering Wheel Locks Up
I have a 2001 ford f150 lariat 5.4 L Trition it shuts off while driving the steering wheel locks up when the truck shuts off I tried everything and it doesn't seem to help the problem. I changed the Iacv idle air control valve,I had a bad o2 sensor changed that, changed the crank sensor, cleaned the throttle body and changed the Tps sensor, got a new battery, changed the vacuum lines.i really don't know what else to do this truck is becoming a nightmare and is dangerous to drive I never know when it's going to shut off and when it does shut off sometimes it starts right up and other times it doesn't.
View 2 RepliesFord F-150 - 1997-2003 :: 2002 - Crank But No Start Or Spark
I have a 2002 F150 5.4L (VIN-L) that has been sitting in the driveway since February. I have been a mechanic for 30 years for large commercial trucks, and my own truck has me stumped. I'm sure I've forgotten something but I'll try to list everything I have tried so far. It started with crank no start, no check engine light, checked for trouble codes got a trouble code for the CHT(cylinder head temperature) sensor.
- Replaced the CHT sensor. Cleared codes.
- Dash lights up fine, shows mileage, and anti-theft is not flashing while cranking.
- Fuel Pump does not seem make any sounds. Hit the tank with a hammer. Nothing.
- A little fuel comes out of the schrader valve on the fuel rail when I push on it. I have not checked it with a pressure gauge.
- Attempted to start with ether, nothing, so I'm assuming no spark.
- Fuel pump inertia switch isn't triggered.
- Checked several ground connections to the frame and checked ground connections in the PCM harness. All have less than 5 ohm resistance.
- Unplugged and plugged back in cam shaft sensor.
- Checked voltage on the TPS(throttle position sensor) I'm unsure about the results, if the TPS was bad wouldn't it just idle funny and/or stall?
Fuel Pump and PCM relays in the underhood fuse block appear to be good. All other fuses and relays appear to be good. I have been swapping the relays with one I think is good, although. Searched all over for additional relays, and found 3 inside the cab behind the passenger air-bag. Can't seem to find anything in the Haynes/Chilton manual that lists what they do. They are about half the size of the fuel pump relay.
Manually grounded the fuel pump relay, relay clicks but I don't hear a buzz from the fuel pump. Id like to run 12V to the fuel pump directly to see if that's my issue, but I'm not sure where to connect it without frying something important.
I bought the alldata.com DIY guide for my truck and it hasn't worked much. I have read extensively about others with similar problems and I just don't know what to do next. My main question here is, if the fuel pump is bad, would that stop the spark plugs from working? I'd rather not replace the fuel pump without being absolutely sure.
Ford F-150 - 1997-2003 :: 2002 V6 Will Not Crank But Engine Turns Over
After short trip, 02 f-150 v-6 will not crank every time but engine turns over. When it does crank, it runs fine the entire trip. 189,000 miles on motor and is a 4x2 extended cab.
View 1 RepliesFord F-150 - 1997-2003 :: 2002 - Single Click / No Crank Condition
back story but may have nothing to do with problem. battery terminal bolts were rusted solid so i cut them off and replaced. truck stated fine the last time i started it before doing this.
I turn key and get a single click. i tried jumping 2 large poles on fender solenoid and still one click no crank. i had taken off the starter and autozone tested and it passed. i checked voltages everywhere i could think of and all were as to be expected.
could it be the starter even though it passed?
Ford F-150 - 1997-2003 :: 2002 - Starter Did Not Turn Or Crank The Engine
I have an 02 f150 5.4 4x4, drowned it a while back, thought i had hydro lock, crank can be turned by hand though as far as i can with a wrench, so internals seem to be fine, no bent or broken rods that i could tell, ripped everything apart cleaned it up put it back together, new fuses, new ignition relay, new starter, alternator and battery as well, turned the key to on and got all my electronic stuff back up, turned to start and it all goes dark, which i assume is because at that point its sending power to the starter, but the starter didn't turn or crank the engine...
So question being when i put my new starter on is it possible that i might have crossed a wire or something that would cause it to not crank? and due to the fact that I had water in it, and had hydro locked it, all my plugs are out, now I know that spark is needed for the engine to run, but shouldn't be needed just for the crank to turn right? question being is that once i fix the wires on my starter, I am looking for initial crank before start up, so do i need to put a plug or two back in and hook them up to make it crank? or will it crank without them? and yes I did replace all my fluids as well.
Ford F-150 - 1997-2003 :: Truck Died While Driving - Crank But No Spark / No Fuel
My Truck : 1999 Ford F-150 Extended Cab 4x4 5.4L V8
So the other day I was driving the truck and it just dies on me. Tried starting but it just cranked and cranked. Got it pulled over to a parking lot and then tried to start and I got it to run again. Died a couple mins later uo the road and it will not start at all anymore. I got it towed to my driveway and I've started diagnosing some things.
I dropped the tank thinking it was a pump I replaced awhile back. The pump wasn't running but jumped to conclusions and took it back to the auto parts store. They bench tested and it works fine. I checked for voltage at the pump connector. NOTHING. So I'm not getting power to Fuel pump. Then I checked the fuse and relay for the fuel pump. Everything was okay.
I did some research and decided to check for spark. NO SPARK. Another thing I noticed the other day was that the odometer is displaying all dashes. So I'm really unsure on what to really troubleshoot. I am going back to the truck tomorrow to check a few other things. I'm not sure if the Theft light is blinking or not so I will check that tomorrow and get back to you.
What to check? Any other relays or fuses besides the fuel pump? What about any modules to check like PCM, GEM, etc. Or I've heard the crankshaft sensor could be an issue.
Ford - F250 :: 2002 - Shuts Down While Driving
My '02 F250 Diesel shut down and would not start while I was pulling a 20' gooseneck trailer in August of 2012. After approximately an hour it started and I drove it home. Took it to repair shop and I had them change the fuel filter (although no lights came on in truck) and they told me they couldn't find anything wrong with it. Then for a couple of months while driving it would shut down while driving and as soon as I released the pedal it would run again. In November 2012 it again shut down while I was driving and would not start. The next day it started and I took it to another repair shop. They checked it and said they couldn't find anything wrong. I drove it home (30 miles) and it shut off briefly a couple of times, but we made it. I've driven it a few times over the winter and it had no problems. Then yesterday, the first day over 50 degrees since last fall, I drove it and it shut off, would not start, and I had it towed back home. It appears there are multiple posts about this issue (on the internet) with these trucks and their stories are very much the same. I'm about to give up on this truck.
View 14 RepliesFord F-150 - 1997-2003 :: 2002 4.6L Dies While Driving Randomly
My 02 F150 4.6 4x2 shuts off while driving - usually when I am coasting, but also at varied speeds, even highway speeds. The motor dies, the gauges all go to 0, and the odometer shows ------ I have to shift to N and coast...if I try to re-start it just turns over and over...gauges still all at 0.
I have determined that if I reach behind the fuse panel and wiggle the wiring harness, my gauges will come back and I will be able to re-start it.
I noticed yesterday, that after it did this and I got it re-started, the red 'Theft' light was blinking rapidly. A clue, perhaps?
I have tightened the 10mm bolt that holds the two wire bundles into the back of the cabin fuse box (by driver's door).
Where to start? I have crawled under the dash, looking for loose, chaffed or otherwise odd looking wire, but so far no good.
Ford 7.3L Power Stroke (1999-2003) :: F350 Will Crank And Run But Shuts Off When Gets To 150 Or 180 Degrees
I have a 99 f350 Ford 7.3 service truck. It will crank and run but when it gets to 150 or 180 degrees it shuts off and will not crank back until it cools off. I have change the ECM I have change the IDM still same thing it runs till gets hot and then it cuts off. I have changed IPR valve IPC sensor .check the high pressure oil pressure it is around 800 900 at an idle it is around that pressure but when first starts up it is higher once it starts and runs it idles around that pressure 800 900 psi....
I have hooked up my scanner and it shows around 150 degrees oil temperature it shuts off . The high pressure oil stays the same as it was when you first crank it the low pressure crankcase oil is 60 psi ... Once the oil temperature reaches around 150 ~160 degrees the engine will shut off . Once you let it sit overnight or for several hours it might crank up ....
Ford F-150 - 1997-2003 :: 2002 Truck Shut Off On Interstate When Driving At 65 MPH
Truck in question is 2002 F150 4.6 with 150K miles. Crew was on interstate tonight driving 65 MPH and truck shut off. They called me out to trouble shoot. Engine had oil (was a quart low) and will not start. Starter engages but will not turn motor over. Had truck towed back to my shop. I removed belt just to see if it may be a locked up pulley i know, long shot)... it was not.
Employed called a shade tree mechanic he knows and trusts. He said was likely a broken timing chain and that is a common problem in 4.6. Said locked engine is probably because broken chain is wrapped around shaft. When I turn key fan does move about 1/4 inch.
1) Does this sound like a possibility or even a plausible explanation? Just trying to verify the information.
2) If this is the case, would a repair be advisable, or is engine likely shot and i should just replace it?
Ford F-150 - 1997-2003 :: A/C Works For 12 - 15 Miles Then Shuts Off?
2003 F 150. 5.4 motor. 4x4. 270,000 miles. Climate control.
The A/C is ice cold.. For the first 12-15 miles, and then it shuts off and is warm.
I had it recharged at the shop just to be sure. When it works, it blows out the vent at approx. 42 degrees.. nice and cold.
This problem happens every time. Turning the climate control off and then back on doesn't work.
Shutting the truck off and then back on doesn't work. Wait a while.. Not quite sure how long, but the next time I drive it, it will work again. For about 12-15 miles and then blows warm again.
A bit of funky , moist smell to it when it blows warm.. Typical A/C smell I think.. The box could prob use a cleaning.
Grand AM :: 1997 Pontiac - Shuts Off While Driving When Weather Is Hot
We have a 1997 Pontiac Grand Am 2.4L. Recently it has begun to shut off while it is being driven. We will have to pull over and wait X amount of time before it will restart. An interesting addition to this is that it only happens when the weather is hot. If it is a cold or wet day, this will not happen and the car will run perfectly.
We have tried several things on this car to try to fix this problem. We have replaced Computer
Fuel pump
CPS or Hall sensor
Water pump
Control module
Cam sensor
Both coils
Throttle Sensor
Thermostat
New Radiator
Volvo :: 1997 - While Driving After Start Up Engine Shuts Off
1997 Volvo 850 Engine Problem? My customer question is, during the times my customer drive, When my customer start the car & when my customer put it on drive, the engine shuts off. My customer was wondering what was the issue of the problem , ALLDATA 10.53 & what's causing it to happen.
View 2 RepliesOldsmobile - Engines - Eighty-eight :: 1997 - Shuts Off While Driving
Three weeks ago my 1997 Oldsmobile eighty-eight (75K miles) shut off while I was driving. I was able to pull over and restart it immediately. This morning it happened again, same exact way. It shut off without warning, nothing seemed out of the ordinary, except for the shutting off! For the past few months my check engine light has gone on and subsequently turned off two-three days later. Most of the time when it turns on, I have been driving on the interstate for an extended period of time:at 70 or 75 mph.
I had it looked at once and they said the light was triggered by the transmission- they serviced it but I didn't notice much difference. Occasionally, I feel the car stutter while slowing down, almost like it might stall-but it never actually has. Finally, ever since I got the car-two years ago from my grandparents, there is a pull occasionally when I am going about 40-45mph and speeding up-almost like it is having trouble shifting. I don't know if all these issues are related...not sure who to trust to take it to. What could be going on?
TrailBlazer :: 2002 - Powering Down Message While Driving And Engine Shuts Off
I have a 2002 trailblazer with the V6 engine. while driving it will say on the message center POWERING DOWN. the engine shuts off and after coasting to a stop its like the battery is dead. It wont shift into park and the key cant be removed from the key switch. thinking that it was a battery or alternator problem I had both replaced. And it done the same thing the last time it was driven. Had it towed home, connected a battery charger to it to boost it and it allowed me to cut the ignition to the off position and remove the key. What could be wrong with it?
View 10 RepliesSuburban :: 2002 - Car Shuts Off While Driving, Takes Time To Restart
As of yesterday evening my 2002 Chevrolet Suburban 1500, shuts off while im driving. Takes about two to five minutes to get it going again (has shut off a couple times) Starts up fine idles great, problems start about a mile or two of being driven.
View 1 RepliesChevrolet - 3500 :: 2002 Quits While Driving / All Electrical Shuts Off
02 Chevy 3500 quits while driving, all electrical shuts off. This is my work van, I am a Honda mechanic and can't figure it out. I need my truck for work on Monday! Think it might be ignition switch??
View 3 Replies