Ford F-150 - 1997-2003 :: Water Pump Pulley Shims
Is it common to have to shim the water pump pulley? I don't know why but mine seems to have moved back a fraction of an inch. I loosen the belt tension and slide the belt back and as soon as I start the motor, the belt slides forward again. And as I rev the motor, the belt moves even further out onto the edge of the water pump pulley and starts to squeal. All other pulleys are aligned and the belt spins fine on them. I thought about buying a shim kit, but I ordered a new Motorcraft water pump since I have 154k miles on my truck.
View 7 RepliesFord F-150 - 1997-2003 :: Adding Water Pump Lube?
Is there any benefit to adding water pump lube to a 4.6L engine? There's smelly, old looking coolant in my friend's "new" 1997 F-150 so a flush is in the immediate future. I'm going to suggest using G-05 coolant over conventional green due to its longer life. Should water pump lube be added?
View 10 RepliesFord F-150 - 1997-2003 :: Replaced Water Pump - Overheating Occasionally - CEL On
We had my son's water pump replaced in his 97 F150. It is now occasionally jumping to completely hot. If you turn it off and back on it returns to normal. The power to the engine is cut when it shows to be overheating. The check engine light has now come on.
View 9 RepliesFord F-150 - 1997-2003 :: 2002 - Stumbles - Hesitates During Acceleration - Fuel Pump?
My 02 F150 4.6 has 84K miles on it, and started stumbling/hesitating during accellartion about three weeks ago. Before this problem started (about 2,000 miles ago), I installed a new fuel filter and air filter. Since I noticed the problem, I installed new plugs. The problem didn't go away, so today I checked the fuel pressure. At idle the pressure is 32psi with the vacuum line left on the fuel pressure regulator (30-45 is normal as per Chilton's), and 42 with the vacuum line off (40-50 is normal as per Chilton's). I also had someone else rev the engine so I could observe, and found that the fuel pressure went as low as 28 when the engine speed was quickly increased. The standing fuel line pressure is 30 (30 is normal as per Chilton's) Does this sound like a fuel pump problem, or is there something else that I'm missing.
View 10 RepliesFord F-150 - 1997-2003 :: Rebuilt Starter Fires When Battery Connected
My husband's starter went, so he took it in to be rebuilt. After my husband reinstalled it, as soon as he connects the battery up, the starter engages without the ignition on (not even a key in the ignition). Did the guy who rebuilt it screw up, or is there something my s/o might have done wrong when putting it back in?
View 11 RepliesPrius (2004-09) :: Turn Off Red Triangle After Control Valve And Inverter Water Pump Installed
I had the red triangle pop up on my Prius. I codes I got P0A93 and P1121 I needed a new control valve and inverter water pump. I installed both the valve and the inverter pump filled it with new coolant and bled both systems.
I went into maintenance mode so I could run the motor and bleed out all the water. My question is the red triangle is still on in my car when I start it up.. Is there some way to clear the red triangle or does it just go away on its own? Not sure what to do.
Passat (B5) :: 2002 GLS Wagon - Brake Booster Valve Filled With Water And Frozen
Our brakes froze the first cold day this winter. My mechanic says that the brake booster valve filled with water and froze. Also, last winter our tiptronic just quit working. We never fixed it. Should we bother to fix it?
View 3 RepliesPrius (2001-03) :: 2002 - Water Pump Is Leaking?
I have an 2002 which I bought new. It's got low millage, just over 92,000. I took it into the dealer for a free state inspection and was told that the water pump is leaking. Given the age I'm not too surprised although I don't know what the reliability is like on that part.
I want to verify myself that the water pump is actually leaking before having it replaced but don't know where it is or what to look for. Googling hasn't been too useful - I get lots of hits about the inverter pump, not the water pump.
I have not seen any signs of leaking on the ground under the car. There was no mention of the water pump leaking when I took it to the dealer at 90,000 for an oil change, with my original service advisor.
Is the water pump something that I can fairly easily inspect? Where do I find it and what do I look for?
Ford 7.3L Power Stroke (1999-2003) :: Water Pump Went Out?
My water pump went out. Besides the obvious replacing the pump is there anything else I should do while making the repair?
View 14 RepliesFord 7.3L Power Stroke (1999-2003) :: 2001 F250 - Fuel Leak - Not Water Separator Valve O-Rings
I have a very small fuel leak in my 2001 F-250. I was going to just let it go until I needed to do other work (since I get 20mpg city and 25mpg highway), but I went to a "new" inspection guy, and he flunked me. So now I have to fix it. And for all I know, my mpg and fifteen other things will break when I try to fix this.
Today I spent 4 hours in the heat putting in two new o-rings on the water separator valve. But the truck still leaks fuel. Climbed up on top of motor while it was running and looked, but I don't see where the fuel is leaking out.
Online research suggests to me that the next most-likely culprit is a steel fuel line that wears through from vibration and chafing. Is that correct?
This truck is so eaten up with rust (came from salt belt) that I bought a LOT of fuel line stuff a year or so ago, so that when things started falling apart from rust, I would have the parts on hand.
Now I'm wondering whether I already have the part I'm likely to need.
So far, I have bought:
1. Dorman Fuel Supply and Return Lines
2. Riff Raff Diesel High Pressure Crossover (HPx)
3. Riff Raff Diesel Fuel Rail Crossover (FRx)
So my question is, am I likely to have something to replace the part that commonly leaks on these trucks due to vibration/wear/chafing ... or will I still need to buy another part?
I'm thinking that one of the two lines in item #1 above is the problem child...
Elantra XD (2001-06) :: 2002 GT Not Starting After Water Pump Replacement
Just finished installing a new water pump on my 2002 Elantra GT when...
I went to start it, and it started for half a second and died. Further attempts to start were strained.
The battery is showing 12.58 volts on the multimeter so this was likely not the cause. I checked the fuses under the hood which all looked good. I don't know if it could be a relay or anything else electrical.
Other than the electrical side, there are two things I can think of that may be the cause.
First, being in a hurry to finish(which is probably the biggest mistake of all) I reconnected the battery too soon and wound up connecting the ground(I thought) wire to the alternator for a second causing an arc. I immediately removed the wire and followed proper procedures to reinstall it.
The only other thing I can think of is that one of the water pump bolts required removal of the idler pulley. The idler pulley demands the loosening of the timing belt tensioner in order to be reinstalled. Before removing anything I marked the position of the timing belt on the camshaft sprocket as well as the crankshaft sprocket so I'm really hoping I haven't lost timing.
Could it be something electrical? Did I over-tighten a belt or pulley? Is it timing?
Golf IV / Jetta IV :: 2002 - Replaced Water Pump And Thermostat Still Overheating?
My son has a 2002 Jetta, we just changed the water pump and the thermostat. The car will sit at idle and the temperature will stay around 190. When you drive down the road the temerature will rise and when you let off teh gas the temperature goes back down. What this could be, I have tried everything I can think of to fix this car.
View 13 RepliesFord 7.3L Power Stroke (1999-2003) :: Water Pump Removal As A Unit
I have a 99 SD 7.3 with 210K miles. It has the OE water pump, clutch and fan. I am replacing every thing from pump to fan including pulley, thermostat and sensor. The question is can every thing be removed as a unit? I don't see why not but never did one that way.
View 14 RepliesFord 7.3L Power Stroke (1999-2003) :: F250 - Water Pump Replacement
How hard is the water pump to replace on 1999 f250 7.3 ...
Any thing special i need to know before tackling this job ...
Also is there any step by step instructions ???
Audi - A4 :: 2002 - Still Overheat After Replacement Of Water Pump / Thermostat And Timing Belt?
I have a 2002 Audi A4 1.8T with 85,000 miles. Recently my car started overheating, I replaced the water pump, thermostat, and timing belt. The mechanic also ran tests to make sure there were no issues with the head gasket, those tests came back saying the head gasket was a-ok. Yet, my car is still overheating but only on days when the outside temperature creeps above 90 and I am in stop and go traffic. I have to re-fill the coolant tank about once a week depending on how much I drive. I find no coolant puddles under my car when it is parked, so I do not believe it is leaking. What else could be causing my car to overheat?
View 2 RepliesDodge - Intrepid :: 2002 - Overheating After Replacement Of Timing Belt / Water Pump?
I have a 2002 Intrepid ES with a 3.5L V-6 with 264,000 miles on it. I have recently had the timing belt and water pump changed. Three weeks later I am driving home and the temperature gauge starts climbing. This is the first time this car has ever overheated. Well, I call my buddy who is a certified mechanic and he tows the car to his shop. I have him check the water pump to make sure it hasn't prematurely failed. He tears the front of the engine down and inspects the pump. He finds nothing wrong with the pump but he discovers the timing belt tensioner has failed and it has caused the engine to jump time, I tell him to go ahead and replace the tensioner.
After he put the engine back together he started it and it ran cool while it was sitting at idle for about 45 minutes. Then he took it for a test drive and it overheated again. He checks the thermostat and finds that it has also failed; he replaces that also, still overheating. New radiator hoses, upper and lower, new radiator, new thermostat, new water pump and it still overheats. He put dye into the coolant to check for a blown head gasket and it tested negative for a blown gasket. The exhaust doesn’t smell of burning coolant or producing white smoke. My mechanic friend and I both have run out of solutions…
LeSabre :: 1997 Buick - Small Drip Of Coolant On Driveway Under Water Pump
Lately I have been noticing a very small drip of coolant on the driveway under the water pump. Most would assume this to be coming from the water pump, right? Problem I have, is I can drive the car say 10-15 miles, return the car to it's parking area on the drive (previous spot cleaned and dried) and monitor thru out the day, some 10-12 hours, NO DRIP! I can forget about it, return the following morning only to see it has dripped overnight! I have visually inspected the coolant elbows at the tensioner and dry as a bone. I see no damp areas near the water pump pulley area. You might ask if the upper and LIM work has ever been done and the answer is yes, the local Buick dealership did that a few years back.
The coolant levels rise and lower normally depending on engine temp and it's hard to see any loss of coolant when looking at the reservoir when cold. I have read there is a small weep hole near the output shaft of the water pump which allows a release of coolant to protect the bearings of the water pump. Could this be where the coolant is coming from? I wouldn't mind replacing the water pump and even the coolant elbows while I have every thing apart, but I would hate to do that only to find it was something else, maybe an easier fix!
Ford F-150 - 1997-2003 :: 2001 - EGR Valve Location?
2001 5.4l Windsor... I have been reading up on some post, and I'm wondering where the EGR VALVE is located on these motors?
View 5 RepliesFord 7.3L Power Stroke (1999-2003) :: 2001 F250 - No Start After Changing Water Pump
I have a 2001 F250 Super Duty V8 7.3 L. I removed the water-pump then waited five days for the oring for the new pump. I installed it and now the truck will not start. I have drained the fuel water separator and replaced the filter. On the passengers side through the kick panel I found that button popped out so I pushed it back in and still it will not run. It acts like its not getting fuel but if my fuel water separator is filing up I'm assuming mu fuel pump is working??
View 7 Replies