Chevrolet - Cavalier :: 1998 - Overheating After Installation Of New Water Pump And Thermostat
I had a leak in my water pump so we had it replaced and a new thermostat. Now it is overheating in just about 2 minutes and my heater is now not working. I was told that it is most likely an air pocket in the coolant. I have let the car heat up, not to the point of hot but over half way and shut it off, taken the cap of let it sit for a while and then trying it again. No luck so far. Is there another way to get it out of there? and would the cap have anything to do with it? it has been hard to take off in the past and now its coming off easy. It is the plastic kind. I am at the end of my rope here . the car runs like a dream, its just this one thing.
View 12 RepliesMustang :: Replaced Water Pump / Thermostat / Underdrive Pulley But Still Overheats?
My son has a Mustang GT 5.0 that is overheating. I replaced the radiator with a heavy duty 3 core radiator. It had underdrive pulleys so I replaced them with stock pulleys. I put dual electric fans on it. I flushed the block and put a new thermostat and replaced all the hoses (made sure the bottom radiator hose had wire in it so it wouldn't collapse). I put a new water pump and drive belt but it still overheats when sitting in traffic and overheats when driving with the A/C on.
View 14 RepliesFord A/C :: 1994 - Replaced Thermostat / Heater Core And Water Pump Still No Heat?
the only thing that is left to replace would be the radiator?my truck is a 1994 f150 and it is not overheating!i get lukewarm heat only on the highway,everywhere else it is cold air!!this new england weather is killing me
View 10 RepliesGolf IV / Jetta IV :: 2005 - Water Pump Is Very Loud - Overheating?
My aux water pump was acting up and started leaking a year or two ago. I replaced it and it seemed to be doing fine. Recently it has started buzzing very loudly right when I turn the car off and keeps buzzing loudly for a few minutes (5-10) after the car is shut down. I know that is when it is supposed to be running, but why would it be so loud? Is it being over-heated or something?
View 1 RepliesGolf IV / Jetta IV :: 2001 GLS VR6 Engine Lag After Water Pump Replaced
My girlfriend has a jetta and I work at a DODGE dealership in service. I recently replaced the water pump and flushed the coolant twice and replaced the coolant with G13 coolant from the local VW dealership. After I finished burping the coolant system of air bubble. After I finished I took it for a spin and being the speed demon I am, I don't hold back on the throttle. I noticed immediately the engine lagging and being extremely sluggish. I ran my shops snap on code scanner on it and I came up with cylinder 1 fuel injector open circuit. Cylinder 6 fuel injector limited power. And last but not least o2 sensor 1 open circuit. If your facing the motor I undid the left motor mount from the frame, lifted the car on a hoist and took the bottom side motor mount off of the motor. I took the cv shaft off of the transmission and lowered the car and jacked the motor up by the oil pan to expose the water pump for removal and replacement. I'm wondering if possibly the o2 sensor could cause the ECU to seize power to two of the cylinders to ensure no engine damage or if its 3 separate problems.
View 3 RepliesGolf IV / Jetta IV :: 2004 1.8T Overheating - Water Pump Or Blockage In The Radiator?
First off new jetta owner. I changed the thermostat. There is no heat coming into the car upper radiator hose hot lower hose is cold & seems there is no pressure. I bought the book to repair the car but it doesn't give me troubleshooting directions other than it might be the water pump or a blockage in the radiator.
View 9 RepliesFord F-150 - 1997-2003 :: Replaced Water Pump - Overheating Occasionally - CEL On
We had my son's water pump replaced in his 97 F150. It is now occasionally jumping to completely hot. If you turn it off and back on it returns to normal. The power to the engine is cut when it shows to be overheating. The check engine light has now come on.
View 9 RepliesAudi - A4 :: 2002 - Still Overheat After Replacement Of Water Pump / Thermostat And Timing Belt?
I have a 2002 Audi A4 1.8T with 85,000 miles. Recently my car started overheating, I replaced the water pump, thermostat, and timing belt. The mechanic also ran tests to make sure there were no issues with the head gasket, those tests came back saying the head gasket was a-ok. Yet, my car is still overheating but only on days when the outside temperature creeps above 90 and I am in stop and go traffic. I have to re-fill the coolant tank about once a week depending on how much I drive. I find no coolant puddles under my car when it is parked, so I do not believe it is leaking. What else could be causing my car to overheat?
View 2 RepliesFord - F250 :: 1976 - Replaced Hoses / Belts / Water Pump / Fan Clutch - Flowed The Radiator Still Overheating?
I have a 76 f250/460 engine. I have replaced the hoses, belts, water pump, fan clutch, flowed the radiator and it still overheats.
View 4 RepliesGolf IV / Jetta IV :: Replaced Thermostat Now Alarm Going Off All The Time?
So I replaced my thermostat today... to do that I unhooked the negative terminal of the battery, removed the hose off the thermostat housing (I think that's what it's called) and disconnected the switch to the alternator as well as take off the 13mm jam nut holding the wire to the side of the alternator. I reconnected everything up, put the key into the ignition and just turned it before starting the car and the alarm started going off. I disabled the alarm from controlling the lights and horn by unplugging the electrical connector just behind the fuse panel so I could do some errands today. I then disconnected both terminals on the battery and touched them together to reset the ecu.
After reading that holding the key into the door lock until the windows roll down would reset the alarm; this weekend I'm going to hook up my driver side door lock mechanism (been a little lazy) and give that a try.
Sonata NF (2006-10) :: Engine Overheating (Thermostat Replaced)
My engine started overheating, and because I was stuck on a bridge during rush hour (George Washington Bridge in NYC), I couldn't get stop the car. I drove it for approximately 30 min (slow crawl), and this happened: [URL] .....
Yes, I know how stupid it is, but there was not even a shoulder to pull over to the side. The only good thing is that this happened pretty much soon as Igot off the bridge, and not on the bridge.
Hose by the radiator cap (is that the overflow hose?) popped out and spewed steam for good 5 minutes. The car did not start at this point. I left the car by the gas station after the bridge, and came back later on in the night. It started and I was able to drive it home (about 10 min away) at crawl speed without it reaching the red zone.
Today, I just did the oil change, topped off on the coolant, and also replaced the thermostat. But the engine still overheats (to the red). The upper radiator hose is burning hot and the bottom radiator hose is not. Also, the fan is working, but it blows out pretty hot air.
Dodge - Intrepid :: 2002 - Overheating After Replacement Of Timing Belt / Water Pump?
I have a 2002 Intrepid ES with a 3.5L V-6 with 264,000 miles on it. I have recently had the timing belt and water pump changed. Three weeks later I am driving home and the temperature gauge starts climbing. This is the first time this car has ever overheated. Well, I call my buddy who is a certified mechanic and he tows the car to his shop. I have him check the water pump to make sure it hasn't prematurely failed. He tears the front of the engine down and inspects the pump. He finds nothing wrong with the pump but he discovers the timing belt tensioner has failed and it has caused the engine to jump time, I tell him to go ahead and replace the tensioner.
After he put the engine back together he started it and it ran cool while it was sitting at idle for about 45 minutes. Then he took it for a test drive and it overheated again. He checks the thermostat and finds that it has also failed; he replaces that also, still overheating. New radiator hoses, upper and lower, new radiator, new thermostat, new water pump and it still overheats. He put dye into the coolant to check for a blown head gasket and it tested negative for a blown gasket. The exhaust doesn’t smell of burning coolant or producing white smoke. My mechanic friend and I both have run out of solutions…
Subaru - Legacy :: 1998 - Overheating After Replaced Thermostat - Gasket?
problem is the my 1998 Legacy (142K) overheated this past weekend. It shut off and I had it towed to a "new" mechanic around the corner from my house. He diagnosed the problem as being a faulty thermostat. He replaced the thermostat and returned the vehicle to me. Two days later my wife was driving home and the car had a major overheating incident with resulting serious mechanical failure. I did a little research and within about five minutes found that this problem is quite common for this car and is more commonly related to a head gasket issue. My question is should this mechanic be held responsible in any way for the misdiagnosed problem? If so, what would be the best course of action? The car was otherwise running fine and in fact I recently had the transmission rebuilt.
View 3 RepliesFord Ranger / B-Series :: 1997 - Replaced Thermostat Still Overheating?
Bought this truck at auction a few days ago. Started drive home and noticed temp gauge almost pegged full hot. Stopped and left it and pickup up later that day with trailer. Got home and started and ran it. Will not overheat at idle. Gauge fluctuates between full cold and 1/2 at idle. Rev up and temp drops to full cold. Drive around town under 35 and it stays between 1/2 and 3/4. Get on the highway and Pegs full hot. Replace thermostat and flushed system. Lots of rusty water and chunks of rust/mud poured out.
Upper rad hose is firm and hot. Lower rad hose is warm soft. Bypassed heater core and still over heats. I can run water hose from top hole on radiator and water crosses threw radiator and pours out the bottom so I don't think it's clogged. It's not the head gasket, I have no smoke, no milky oil and no oil in coolant. Fan clutch seems fine, I can spin it with the engine off and feel resistance. Truck hasnt boiled over while running hot so the gauge may be wrong. If it means anything the truck runs very rough and pulled up a misfire on cylinder #1 and had a iac code.
Golf/GTI VI :: 2011 - Clutch Isn't Slipping At All - Weird Noise After Water Pump Replaced
The car is a 2011 GTI 2dr w/6 speed, 12,000miles, cat back exhaust and that's it. Recently when I get into my car in the morning when it is cold (social not that cold) and either put it in reverse or just take off from first the clutch makes a really loud whining noise. Generally, it will go away after a few minutes but sometimes it doesn't go away even after the car is warmed up.
The thing that is weird to me is the clutch isn't slipping at all, even on a hard pull. I know that VW's clutches don't have reputation for lasting that long but I would be pissed if they said it was my fault seeing I drive it nice 9 times out of 10. On another note, I had my leaking water pump replaced a couple weeks ago, ever since then after the car warms up something is making a loud noise that sounds exactly like when your ears are ringing. I popped the hood and it sounds like it coming from the rear of the engine bay but its really to hard to pinpoint exactly where.
Chevrolet - Venture :: Running Hot With New Thermostat And Water Pump
I have a new thermostat and a new water pump. Why is my car still running hot?
View 4 RepliesFord :: 1995 - Coolant Leakage - Changed Thermostat / Water Pump
1995 Ford Van E150. So I've been trying to solve my overheating problem for months now. One morning I walked out of my house and all of my coolants was on the street. I could not completely detect the source of the leak after running more coolant through it. I also checked the dip stick and coolant on the ground for any sign of oil/coolant mixing. I started by replacing the thermostat.
I did a more thorough inspection and found a crack at the bottom of the radiator that I replaced less than two years ago. I replaced the radiator again and while I had the belt, intake and fan disassembled I switched out the water pump as well. The old water pump was gunked and the gasket was almost completely worn off. The van is still overheating and spitting out coolant at a much higher rate. I'm guessing because of the new water pump. A friend said it could be the intake manifold because of where the steam was coming from the motor.
Ford 7.3L Power Stroke (1999-2003) :: Thermostat Housing Broken Bolt - Replace Water Pump?
So I tried to replace my thermostat and housing and the housing bolt snapped off. Ok so I tried to extract that bolt off and the extractor bolt snapped off inside. I am guessing it might just be easiest to replace the water pump now? I am pretty much at the end of my mechanical rope which is short anyhow.
View 6 RepliesGolf IV / Jetta IV :: Coolant Leak On Passenger Side - Water Pump?
So my coolant system woes have continued! I recently replaced my thermostat ,thermostat housing, thermostat cover and all of the rings and gaskets. I finally stopped the leak on the driver side which seem to be the thermostat now about seven days later I am experiencing leaking on the passenger side. I walked out from work today and noticed I pool of coolant under the car. I can't tell exactly where it's coming from but it's coming from one of the components that runs off of the large belt. I snapped a few pics from the bottom of the car I don't think this is the actual component that's leaking. I think the leak is just falling off of it . I was wondering where the water pump is located.
View 5 Replies