Ford F-150 - 1997-2003 :: 1999 - Radiator Hose Have No Pressure?
this winter i have found that my truck's heater core isn't flowing, meaning i have hot on the upper hose and the lower is luke warm and there is no heat while running down the road. I have changed the t-stat and the heater core and radiator are new as of four years ago. last year i could roast a chicken with the heat. i also have no pressure in the radiator hose at all, engine runs at normal temp, no over heat situation and i don't smell any loss of antifreeze.
1999 f-150 4.6 150k
Golf IV R32 :: Hose Popped Off And Yellow Fluid Spraying Out Under Hood?
i was a few mins early for work so I was just sitting in my car with the engine off...out of nowhere I heard a noise from under the hood...it sounded like a loud spraying noise with a lot of pressure. I opened the hood and finally found the problem. A hose popped off and yellow fluid was spraying out along with a lot of air. I clamped the hose back on to where it belongs and it was secured right away. There is, however a crack in the hose.
I know it's not coolant because the coolant is pink. I saw a thread that suggests it could be power steering fluid, but I haven't noticed any problems with my steering. I also saw a threat that suggests an AC leak.... What this is?
Ford F-150 - 1997-2003 :: 5.4L - Lower Radiator Hose
Is it difficult to replace the lower radiator hose on a 5.4L? I'm mainly thinking about access to the connection at the water pump.
View 13 RepliesFord F-150 - 1997-2003 :: 2000 5.4L - Top Radiator Hose Comes Off
I have a 2000 F150 with 5.4 L motor. The last two trips I have had the top radiator hose come off while under heavy load (pulling a long hill) after 5 hours of driving. So far I have flushed the radiator, checked the thermostat, and refilled with G05 Gold and distilled water 60/40 ratio. I do not hear any gurgling in the heater core. Heater seems to work great.
The stock temp gauge shows it right in the middle range between Hot and cold, right before it blows the hose off. I have replaced top and bottom hoses and put new stainless steel clamps at all end except the top, where I am using the OEM clamp that came with the truck. I thought about replacing the top clamp as well but did not want to blow out my radiator, if in fact it is developing high pressure.
Do these clamps get weak with time? Should I use a vacuum attachment on the fill/overflow tank to remove all air before refilling?
Ford 6.0L Power Stroke Diesel :: Blown Upper Radiator Hose And EOT Temps
This weekend while towing a light load I noticed my FWT and EOT starting to climb rapidly, EOT reached 260 FWT I think about 240. I exited the interstate to find I had a busted radiator hose. I replaced the hose and filled the system with distilled water, but didn't add antifreeze at this time. The system wasn't completely empty.
I noticed once back on the road my EOT seemed to be higher than normal but FWT seemed to be normal. Could the lack of antifreeze cause a greater delta between FWT and EOT? I have seen articles which state do not use Ford Premium Gold Coolant, but to use CAT EL-1 coolant instead. Which should I use?
Ford F-150 - 1997-2003 :: Radiator Fluid Is Of Orange / Red - Change It?
I just bought a used 2000 Ford F150 with the 4.6L V8 engine and I have a question about radiator fluid.
In the owner's manual it says that if the radiator fluid is green is should be changed every 30k miles, but if it is orange color it is only changed at 150k miles. I look at the radiator fluid and from outside the plastic case it is in it has a dark'ish orange/red look. When I shine a flashlight down the hole where you would add more fluid it looks orange/red, but also has a green tint when the flashlight shines directly onto the fluid.
How do I know which kind I have forsure? The truck was bought at a Ford dealer, but I never thought to look at it while I was there.=
Ford 7.3L Power Stroke (1999-2003) :: Lower Radiator Hose Replacement
I'm going to be replacing my lower radiator hose so figured might as well switch over to the extended life stuff going to probably go with the Delo ELC.. Supposedly it's good for 750k.
View 14 RepliesFord F-150 - 1997-2003 :: Radiator Seems To Be Leaking But Not Taking Fluid From Overflow Tank
I have a 97 F-150 and my Radiator fluid has been leaking very bad but hasn't been taking the fluid from overflow tank. Actually the new fluid that I put in the overflow has now turned a rusty color....
View 3 RepliesFord Ranger / B-Series :: 2000 V6 - Blown Head Gasket / Radiator Fluid Goes Straight To The Oil Pan
I have a 2000 Ranger, V6 4L, and I believe my head gasket is blown, my radiator fluid goes straight to the oil pan. It has probably been leaking for a while, I did not realize it was leaking internally, I had been adding coolant for a few months but thought it was my radiator leaking because it had a crack in the housing, so I had that changed, but then a few weeks after that It gave out. I drained, and flushed the engine twice, and just parked it. My question is, should I just have the head gasket changed, or does it need a new engine because it had been leaking for a while and not sure what kind of damage it has done internally.
View 3 RepliesFord 7.3L Power Stroke (1999-2003) :: Washer Fluid Hose Dropped In Cylinder
Like the title says I dropped about a 2 inch piece of small washer fluid hose in my cylinder while evacuating the oil from it . Will it damage the valves If I ran it? Any way to remove it without removing the head?
View 14 RepliesFord Ranger / B-Series :: 1999 - AC Compressor Spraying Air And Green Fluid
I am in the process of removing the lower intake on my 99 Ranger 4.0. I was unscrewing the AC Compressor to get it out of the way and also started to unscrew a bolt on the backside of the compressor because it wasn't moving well due to the metal tube on the backside. I think this is the tube to the condenser? Anyways it started spraying air and green fluid everywhere. I got it to stop for now but if I tighten or loosen the bolt it seems to spray. Also it looks like a green o ring or gasket of sort is showing now which I don't remember. What is it and what should I do?
[URL] .....
Ford Aerostar :: 1997 - Bottom Radiator Hose Connector Leak
I've noticed a spring of coolant shooting out of a connector that I'm assuming is connected to the bottom radiator hose via a smaller hose. Is there a hose that splits off the bottom radiator hose that is smaller. The leak is not coming from the hose, but the connector it's hooked to. Is this a replaceable part? What is it for?
97' Aerostar... 3.0 V6 with AC
Ford 7.3L Power Stroke (1999-2003) :: ELC Coolant And Water Mixed In Trans Fluid - Bad Radiator?
I've got a 7.3 tranny that has had ELC Coolant and water mixed in with tranny fluid because of a bad radiator. I drained the fluid from the tranny a week ago and when I pulled off the pan today there is still junk in there. I'm planning on putting in a new filter, gasket and Mercon V but how do I clean the old stuff out of there? Picture.....
View 14 RepliesFord Super Duty (1999-2016) :: Hose Coming Through Radiator Fan Shroud?
Just picked up my truck from the dealer after a trans flush. While it was there I had them replace both windshield wiper nozzles. They called and told me the hoses needed to be replaced as well--- OKAY fine do it.
Come home and decided to "make sure" the trans fluid was at the correct level.
Open the hood to discover a loose black hose approximately 1/4" or so in diameter coming out of the radiator shroud directly at center of the top. The end of the hose was somewhat towards the passenger side battery.
I figured okay the tech probably just left my old windshield wiper hose on top of the motor and forgot to discard it...
I follow the hose and it appears to go in between the rubber seal for the shroud and the plastic housing. I looked back behind the fan and can see the hose twirled around an aluminum or stainless steel pipe coming up just in front of the fan but behind the numerous condensers...
MY question is two fold: Should this hose be here, or is it indeed the wiper hose that got sucked into the fan?
if it is supposed to be here, what does the end that was leaning towards the passenger battery connect to? it certainly appears to have been previously connected to something whether the washer or some other barbed fitting....
Ford Super Duty (1999-2016) :: 2008 F250 - Coolant Leak Above Lower Radiator Hose
I'm trying to troubleshoot a leak on my 08' F250 with a 6.4 powerstroke. It's been dripping coolant when cold pretty aggressively. Once the truck heats up, the coolant leak seems to mostly go away.
Here's a picture of the drip, it's marked by a dart, so you can see the location from the top (second pic). The radiator house connection around the engine seems dry.
Pic from Top ....
What's hidden here that could be causing the leak?
Ford Super Duty (1999-2016) :: 2008 F250 - Oil Leak Form Radiator Hose At 122 K Miles?
Where this small leak coming from. Under my radiator hose. Took a pic of the leak.
View 8 RepliesFord F-150 - 1997-2003 :: 1999 - Type Of Fan Clutch Fluid?
What type of fan clutch silicone fluid is used in case you need to replace some during removal?(99 ford f150 5.4 vin L)
View 5 RepliesCavalier :: Radiator Fan Starts And Within Few Minutes Engine Radiator Fan Stops - Fuse Blown
I start the car, with AC on, radiator fan starts and within a few minutes the engine radiator fan stops working, idles rough since the AC compressor pump keeps cycling on and off and engine starts to overheat. After shutting down I check the engine cooling fan fuse and it sure enough is blown.
How do I determine as to where the short is? Is the short in the wiring somewhere or can the actual motor short out?
Ford F-150 (2004-2008) :: 2005 XLT - Wipers Washer Fluid Not Spraying
I have an 05 F-150 SuperCrew XLT 4x4. I just went to use my wipers and its not spraying anything. The driver side nozzle drips a little bit out, the passenger side does nothing. I can hear the motor engage and there is fluid in the reservoir. I can't see any leaks.
View 10 Replies