Ford 7.3L Power Stroke (1999-2003) :: HPOP Hose Leak At Cylinder Head
I have an oil leak where the HPOP hose attaches to the cylinder head. I have the removal tool for the hose. I assume I need a new fitting. What's the torque spec for this fitting, and any additional tips I need for doing this repair?
View 11 RepliesFord 7.3L Power Stroke (1999-2003) :: Hose Lengths For 2 HPOP And Cylinder Head Oil Crossover Line?
What are the hose lengths for the 2 HPOP and cylinder head oil crossover line? How about what size oring boss fittings you need into the head?
View 1 RepliesFord 6.7L Power Stroke Diesel :: 2011 - Sudden Power Loss - Cylinder 5 Dropped
My 2011 6.7 suddenly lost power, started making noise and then stalled out.
After finding out that there are zero 24 hour service companies available in the LA area, I was able to get it towed to the local Ford dealer.the next day they told me it had dropped the #5 cylinder and that they would have to tear into it to find out what happened.
While I realize that any thoughts on the situation would be primarily idle speculation, what would cause this to happen at only 125,000 miles.
Ford 7.3L Power Stroke (1999-2003) :: Dropped Bolt Into Motor
So I was in the process of doing a turbo swap to the borg warner sxe366 and the freeze plug that plugs the old mechanical fuel pump in the valley had to be removed well needless to say, it as well as the safety bolt I had attached to it fell into the motor, seperatly. I'm already getting the motor ready to be pulled but what are the odds that they made it to the oil pan or if they didn't any way to make them fall out?
View 10 RepliesFord 7.3L Power Stroke (1999-2003) :: Clunking Noise After Speed Dropped To 20 MPH
2001 ford excursion 7.3l diesel.
So I tried to go to work today but the truck said no. it started out fine then out of no where it felt as if someone slammed on the back brakes engine still revved up like normal just didn't want to go. speed dropped to 20mph then i heard a clunk. after that it was fine until it hit 20 mph again. it did the same thing again.
So I got mad at it thinking the trans went out gave it the beans and it shifts into all gears but did not feel like it had power. i did pull over and check the fluid looked a little orange. when got back in the truck i did notice the od off light blinking?? drove the truck home was shifting fine but hear this awesome sounded like a hand grenade rattling around underneath. when i got home notice fluid coming from the bell housing(out of the bottom).
Ford 7.3L Power Stroke (1999-2003) :: P0269 Cylinder 4 / P0284 Cylinder 8 Running A Little Rough
So I did a cylinder contribution test and a buzz test today. It buzzed evenly on all cylinders. Then when I did the cylinder contribution test I got these codes,
P0269 cylinder 4 contribution balance
P0284 cylinder 8 contribution balance
It has been running a little rough lately but not smoking. Seems to be chattering more than it was too. I did the FRx, HPx, CVDs and banjo bolt mods about 500 miles ago and it was a lot quieter and ran better. Just recently started running rough and a little louder. Could these injectors be bad? I did new injector O-rings about 800 miles ago. I ran the test with the engine cold and with it warmed up and got the codes both times. It seems to have a little bit of throttle flutter when holding it about half throttle while driving.
As far as I know the injectors haven't been replaced and they have 186K miles on them.
2001 F-350 Lariat Dually Supercab 6-spd manual 7.3 Powerstroke Turbo Diesel 186,000 miles....
Golf IV / Jetta IV :: Windshield Washer Fluid Hose Broken?
During the removal of my hood. I've broken my fluid line for the windshield washer. Not sure how to replace or if this is able to go back in my hood, I've searched and have fallen short to a decent answer.
View 4 RepliesFord 7.3L Power Stroke (1999-2003) :: High Pressure Power Steering Hose
My high pressure power steering hose just blew at the "B" nut at the pump. Meaning, the fitting is still in the pump but the line is out. Do I need to replace the whole line or is there a retainer I can swap out?
View 14 RepliesFord 7.3L Power Stroke (1999-2003) :: Hose Seal Leaking At Power Steering Pump
Looking for a write-up on replacing the seals on the hose that leaks at the power steering pump? I replace them once but may of over tightened them. I pour in atf and see it dripping on drivers side of power steering pump. Can I just use regular o rings?
View 5 RepliesFord 6.0L Power Stroke Diesel :: 2006 F350 - Washer Fluid Is Not Pumping
If it can go wrong, it seems like it does.... Washer fluid is not pumping. The other day I am almost sure I heard the pump running but no fluid came out. Yesterday I filled the reservoir and now I don't even hear the pump. It's been very cold so I thought maybe the fluid had frozen? I can't find the fuse listed for the washer fluid pump and was going to check that first. Where is the pump even located? 2006 F350
View 6 RepliesFord 6.0L Power Stroke Diesel :: 2006 - Installation Of Washer Fluid Pump?
I am a new owner of a 2006 F 250 6.0.
I need to install a new washer fluid pump. My question is what is the best way to get the old one off and the new one on? Should I go from under the wheel well? Or is there another easier way to get to it? The truck didn't come with an owners Manuel and I cant find anything about how to do this.
Ford 7.3L Power Stroke (1999-2003) :: Lower Radiator Hose Replacement
I'm going to be replacing my lower radiator hose so figured might as well switch over to the extended life stuff going to probably go with the Delo ELC.. Supposedly it's good for 750k.
View 14 RepliesFord 7.3L Power Stroke (1999-2003) :: Hose From The Pump To Hydroboost Leaking
Had a lot to do yesterday and had stock trailer hooked up and loaded with debris.
Got 120 miles away, stopped and got the groan from hydroboost/p/s system.
The hose from the pump to the hydroboost was leaking but it was the actual seal on the fitting that gave up rather than the rubber.
Could not find the seal but luckily the Irish place had the line in stock for a reasonable place.
Transmission got hot too backing up and puked out the front seal. I was doing a lot of twisting to get the trailer in the hole.
Ford 7.3L Power Stroke (1999-2003) :: Rear-End Vent Hose Clogged
Mine was clogged again, and I check it every month.
View 14 RepliesFord - Explorer :: 2003 - Windshield Washer Fluid Pump Not Getting Power
I have a 2003 Explorer Sport and the windshield washer pump is not getting power. Owners manual does not show fuse or relay locations.
View 2 RepliesFord 6.7L Power Stroke Diesel :: Washer Fluid Cutting Out Or Not Even Working When Push The Button
1993 ford ranger ... Having issues with washer fluid not working. Mine has started cutting out or not even working when I push the button. But if bang it on the end of the handle with something hard it will work just long enough to clean the salt off the window.
View 14 RepliesFord F-150 - 1997-2003 :: 1999 - Radiator Hose Blown Out - Fluid Spraying Out?
I blew some hose in my engine and radiator fluid was spraying out of it like crazy. It's on a 1999 f150 4.6 on the passenger side near the rear of the engine but about even with the top of the engine...
View 1 RepliesFord 7.3L Power Stroke (1999-2003) :: Coolant Flow - No Pressure In Cooling System By Squeezing Upper Hose
Well I was fueling the truck today and I opened to hood to check it out and noticed that there was no pressure in the cooling system by squeezing the upper hose. I did have a spare degas bottle cap and removed the old one slowly and replaced. I have been driving over 30 minutes and it is close to 100 degrees.
I then drove on down the road, the truck is not getting hot. I stopped to look at some running boards and the truck was running and then I came home and still no pressure, the truck is still running, I removed the cap and no pressure, I then removed the small hose going to the top of the degas tank and no coolant came out. I turned the truck off and disconnected the upper hose and some coolant did come out.
Is this normal? The truck runs just fine, just has me worried. I just bought the truck and the previous owner recently replaced the water pump, T-stat, hoses, etc. All parts were bought at O'Reilly. So everything looks good.
Ford 7.3L Power Stroke (1999-2003) :: Power Steering Fluid Spurting In Left Tire Well
While turning very slow and sharp on the farm, I heard a pop under the hood. I then lost power steering and brakes. I saw power steering fluid spurting in the left tire well behind the tire. Look under hood and saw fluid coming from a fitting on the side of the power steering pump. I have attached a photo....one photo with nothing and then other with a screw driver tip on the fitting.
It appears that the the pressure fitting blew out the side when I turned sharp. It has a nut from which it came (compression of some sort?). I can push the nipple of the fitting back into the nut but I guess the pressure is gone.