Ford - Explorer :: 2002 XLT - Loud Squeak At Higher RPM
I have an 02 Explorer XLT with 164K miles. I am the original owner. Recently the passenger side of the engine compartment has developed an annoying squeak. The pitch is associated to the RPM of the engine. The higher the RPM the higher the pitch of the squeak. It seems to be louder near the underside of the front then near the top. I replace the serpentine Belt Tensioner and that did not fix it. The belt looks good, no cracks or frays, and I sprayed some belt dressing on it but it made no difference. What do you recommend I try next ?
View 8 RepliesFord - Explorer :: 2002 - Loud Clunk Noise When Put It In Reverse
2002 ford explorer 4x4 150k miles when i put it in reverse a loud clunk noise but when put in drive no clunk noise. But on highway when its shifts a very loud clunk and like a real hard shift !!!!!o/d light is flashing also .transmission shift solenoid ? rear ?
View 8 RepliesFord - Explorer :: 1997 - Loud Banging Coming From Front When Turn Left Or Right
1997 Limited SOHC auto.
I just replaced the transmission with a known good one from my XLT but the reverse doesn't work now and there is a loud banging coming from the front when I turn left or right.
It feels like the tyres are slipping on the road, like axle wind up. This happens in auto and 4wd high. What the banging is?
Ford - Explorer :: 2002 XLT - Front Differential Diagram?
I am looking for 2002 explorer XLT front differential diagram.
View 1 RepliesFord - Explorer :: 2002 XLT - Front Wiper Failure
My 2002 Explorer XLT recently experienced a front wiper failure. Initial indications started a few months ago. When trying to turn the wipers on to the intermittent position, nothing would happen. Turning the switch to low or hi then back to intermittent would allow the intermittent to work OK. Issue seemed to be occasional (trying not to overuse intermittent).
A couple days ago, daughter takes off to meet pals, comes back saying wipers died completely, won't move, won't park, no response to any switch position. I checked it out and researched some of the relevant threads here. My findings thus far:
Front wiper int/lo/hi positions do not work
Front washer pump works fine
Rear wiper switch positions all work fine
High beam, low beam and flash-to-pass work fine
Left and right turn signals work fine.
I am figuring the MFS is probably not the problem.
Looking in the owners manual it seems that fuse #8 protects front and rear wash pump relays and front wiper motor relay. Since front and rear wash pumps actuate fine, I figure fuse #8 is OK and the pump relays (#4 & #6) are OK.
Fuse #20 protects the GEM and Memory Module. Since I am not experiencing any issues with dash lights, idiot lights, chimes, locks or other GEM associated items, I am guessing fuse #20 is OK and the GEM is OK.
This leads me to relays 54 (run/park) and 59 (hi/lo). Since the wipers will not run or park, I am guessing that the run/park relay is having an issue. I presume that the intermittent function is cotrolled by the GEM based on the Intermittent switch position
Am I missing anything or overlooking some complexity that should change my logic? Is it likely for the MFS to fail only the front wiper portion of the controls?
Ford - Explorer :: 2002 - Unable To Remove Front Sway Bar?
2002 ford explorer XLT. Here is a pic of the issue. have a broken right front sway bar link that has broken on the top however the bottom is still attached. I am unable to remove it. The top portion is gone and I am unable to grip what is left enough to loosen the bottom bolt. I have tried pliers as well as vice grips to keep it from spinning as I loosen the bottom bolt. Nothing has worked. The outside plastic OEM piece is stuck in there so well I am unable to break that loose either. I have sprayed PB blaster hoping to loosen things up but here I am writing this.
View 4 RepliesFord - Explorer :: 2002 - Front Right Side Damaged From Running Off Road
My son ran off the road in a neighborhood and hit some large rocks along side the street. It punctured the front right side and obvioulsly damaged the steering because now it drives terribly and instead of the steering wheel handles being side to side it is 90 degrees perpendicular. The service station I use said it has a bent frame and will need to be taken to a body shop. Will the cost to fix it be worth it especially due to its age?
View 2 RepliesFord - Explorer :: 2002 - Front Driver Side Brake Grinding
I have a 2002 Ford Explorer Sport and after a brake job I noticed that while under braking at slow speed there would be a grinding sound on the front left. I replaced the brakes and wheel bearings the first time. After a while I ended up replacing the caliper itself but it still grinds. I don't notice any wheel shaking, pulling and it hasn't locked up although once I did notice a some smoke under hard braking but only once. I also don't hear any grinding while not braking.
View 5 RepliesFord - Explorer :: 2002 - Left Front Brake Is Pulling Ever So Slightly
At my wits end on this. Left front brake is pulling ever so slightly on my '02 RWD Sport Trac. Just enough to annoy the crap out of me. Sometimes I hardly notice it. Over the past year or so I've flushed and bled the lines after replacing rear wheel cylinders, rebuilt the front calipers and replaced the rotors and pads. It's still pulling. Is there some electronic adjustment for the module that the brake lines come out of? Does the ECM control the pressures?
View 5 RepliesFord - Explorer :: 2002 - Front End Is Howling / Wheel Bearing Noise?
I'm working on a 02 explorer. The front end is howling so I replaced the left side and no change. The howl goes away when braking. Is it the right side then or something else? I replaced both front brakes pads so it's not that.
View 2 RepliesFord - Explorer :: 2002 V8 - Noise Coming Front Right Maybe Middle Axle Area
2002 ford explorer v8 4x4, ok I had some noise coming front the right maybe middle axle area so I pulled the driver's side tire and inspected all the bushings ball joints and hubs. The hub had a little play and so did the upper ball joint. So I replaced the hub thinking this could be the problem and the steering stabilizer bar (all the bushing on the bar where toast). Ever thing was tight but the upper ball joint still had a little play but not enough for me to spend the $ to replace the whole control are (as I am told you cannot replace just the ball joints you have to replace the whole control arm). Any way got it all back together and still same nose. What it could be? Also the four wheel low will not engage could this be part of the problem or one more thing un related ( the four high engages just not the low)...
View 14 RepliesFord - Explorer :: 2002 - Front End Howl Starts At About 10 Mph And Continue Till Highway Speed
I have a 2002 Explorer. Front right howls. Local shop put new tires on, said wheel bearings are good, it Starts to howl at about 10 mph & keeps howling up to hi-way speed. While driving 55 cornering makes steering wheel vibrate a little, then straight it just howls. I have put on over 15,000 miles while this noise is happening. now seems to be getting worse...
View 1 RepliesFord Ranger / B-Series :: 2002 4X4 - Loud Bang / Pop Comes From Driver Side Front Tire
Bought a 2002 ranger with a four liter in it. Didn't notice until actually going off-road there is something wrong with the four wheel drive. In 4 high it will drive good for a random distance then a loud bang, pop, comes from what feels like it's the driver front tire. The faster you're moving the worse it is. It's not consistent at all.
Replaced the transfer case shift motor and both CV axles. Still does it. Walked next to the truck while it's moving and the front tires look like something is in a bind and it's causing the bang. Beating my head against the wall at this point.
On a side note it has something wrong with the tranny. Taking off it feels like someone bumped the rear, and after about twenty minutes of driving od light starts blinking and it shifts hard from first to second. Kill it, cures that specific problem just not the takeoff problem. Not sure if this is all related. Pulled the pan and refilled with as much fluid as came out. Which was a dark red. Still having same issues.
Hyundai - Elantra :: 2002 - Loud Noise From Front Tires
I bought an 02 Elantra last August with 128,000 miles on it. The front tires make a noise at almost any speed that reminds me of a 4X4 with mud tires going down a highway. I have replaced the axles, front struts, outer tie rod ends and one irregular rim, and I will replace the rear struts this weekend. Varying the tire inflation has no effect on the noise. When I got it aligned, the mechanic told me they had to swap the front tires to get the alignment within spec, and the uneven wear should cancel out. That was 3,000 miles ago and the noise level hasn't changed. The front tires still have 5/16 of tread on them. Should I keep waiting it out, get new tires, look for some other cause, see if there's a hole in the firewall I can soundproof, or what?
View 2 RepliesCamry :: 2002 - Loud Hum And Violent Shaking On Front Left Side Over 70 Mph
My car begins to shake violently and hum loudly at anything over 70mph. It used to be 80mph but it has slowly gotten worse. I have checked the motor mounts and none appear to be cracked or broken. I have also had tires balanced and replaced, rims replaced, and the problem continues to persist. I was curious if the right axle could be warped? or this issue may be caused by damage wheel bearings. At any rate it has gotten unbearable decided to finally extinguish the problem.
View 10 RepliesBuick - Rendezvous :: 2002 - Loud Noise Coming From Front Of Car When Driving Faster
I have a 2002 Rendezvous. I keep on hearing a loud noise coming from the front of the car when I am driving and it gets louder when I drive faster. My mechanic says its because of a brake rotor that's hung up on something in the car.
View 7 RepliesMercury - Mountaineer :: 2002 - Loud Clicking Noise From Driver Side Front
2002 Mountaineer, suddenly started making a loud clicking noise driver side front. Seldom in reverse. Struts and axle look good, nothing hanging down.
View 3 RepliesPrius (2001-03) :: 2002 - Loud Grinding Sound Coming From Left Front As Car Stopped
I applied brakes while car was moving slowly, less than 10 mph, and heard loud grinding sound coming from left front as car stopped. Shifted to reverse and car barely moved, less than 1 foot, which was accompanied by the loud grinding sound, then stopped. I could find nothing interfering with the wheels but did find pieces of brake pad on the ground along the path the left front wheel had followed. The left front wheel appeared as if the calipers were holding whatever remained of the brake pad and/or backing tight against the rotor. brake pad fell apart on 2002 at 43,561 miles...
View 19 RepliesFord - Explorer :: 2001 - Front Wheels Seem To Stay Engaged With Front Differential
We have an 01 Sport Trac as a backup vehicle and it has the 3 position rotary switch on the dash for 4wd.
The transfer case engages and disengages but the front wheels seem to stay engaged with the front differential.
There are no manual hubs and I really don't think it should ALWAYS be engaged like that.
What is the probable issue and ALSO can manual hubs be installed on this truck?
Someone mentioned vacuum engagement? but I didn't see any vacuum hoses near the spindles. Didn't see any wires either other than ABS...