Ford - Explorer :: 2002 - Temperature Gauge Not Working After Replacing Engine Coolant Temp Sensor
2002 ford sport trac.I have been having an ongoing issue that started with the engine cranking but would not turn over until an hour passed. After replacing multiple parts (cam shaft sensor, crankshaft sensor, ignition pack) I am now down to poor fuel economy as the last of the issues (roughly 12 in the city and 15 highway). I was told the issue may be the engine coolant temperature sensor going bad so I decided to replace it. I found this was very difficult due to it being a plug and locking pin design and in a very tight spot in the engine.
I tried to purchase a replacement and the parts store kept trying to insist on selling me a part with threading. I finally found someone that figured out the issue and found the part for the 2001 sport trac had the same plug style with clip that did fit but was shaped a little different on the sensor end which I assume was due to being aftermarket. I noticed that there were two plugs side by side and the one easiest to access was on the left and I was told the one on the right was the sensor that gave the temperature reading to the gauge.
After installing the engine coolant temperature sensor I found the temperature gauge on the dash now will not respond and is sitting below the cold end of the gauge completely off. Is it possible this is because the part was for a 2001? Is the sensor on the left (passenger side) the engine coolant sensor?I would hate to put the old sensor back in just to test if that's the issue due how difficult it was to put that locking pin back on. What to check that could resolve the gauge issue before pulling this sensor back out?
Ford 7.3L Power Stroke (1999-2003) :: Coolant Temperature Gauge Not Working
Basically my coolant temperature gauge either reads as the hottest it can be, or the coldest. It doesn't jump around a whole bunch, but it's always all the way to one end or the other. From what I've read there seems to be a lot of different temperature sensors, so I get a little confused with all of the abbreviations, but I'm fairly certain I checked the correct one, next to the thermostat housing.
Using a multimeter I checked the resistance of the sensor, and it was around 600 ohms about 30 minutes after it had been driven. I'm not sure if this is where it should be or not, but it was rising as the truck cooled off.
Anyway, I'm not sure if I just tested the sensor incorrectly or if there could be another issue. A friend of mine suggested that the thermostat may have gotten stuck or something, but it doesn't seem like the gauge would switch at all if that were the case. What I should check to try and fix this.
Ford - Explorer :: 1997 5.0 - Running Hot - Temperature Gauge Goes Past Middle And Nears The Red
I have a 1997 Ford Explorer with 5.0, I have replaced the thermostat and the radiator cap, I drive the truck to work in the mornings (12miles) and it is fine. We live on a mountain and on the way home after getting to the top of the mountain the temperature gauge goes past middle and nears the red but does not overheat completely. Once home I open the hood and the overflow is steaming or sometimes boiling, and I have checked thermostat again to make sure and it is operating normal, I have been told fan clutch, water pump, and I don't want to just throw money at guesses.
View 1 RepliesFord Super Duty (1999-2016) :: Temperature Gauge Pegs And Dinger Goes Off - Check Gauge Light On?
Just about every trip i take my temp gauge pegs and dinger goes off and check gauges lights up in the message center. It eventually will go back to normal or if i shut key off and restart truck it goes to normal. im guessing it is the temperature sensor for the gauge but not sure?? If it is, where is the gauge sensor located?
View 14 RepliesFord Aerostar :: 1992 - Temperature Gauge Not Working On Dash / Does Not Move At All
I have a 1992 Aerostar 3.0L end my temperature gauge on the dash doesn't move at all. Stays all the way to the left. I read on other forums that to make sure the gauge and the wiring are ok, i need to connect the wire that goes to the sensor unit to the negative of the battery. Gauge should go all the way to hot when the ignition switch is put to on position. That was exactly my results. So, i replaced the temp sensor unit but still gauge doesn't move. I didn't use any sealant on the threads when i installed the sensor. Connector looks ok. The engine warms up fine. I really don't know what else to think or do.
View 11 RepliesFord A/C :: 1997 - Temperature Gauge Quit Working After Changing The Thermostat And Coolant?
Temperature gauge quit working after changing the thermostat and coolant.
With the engine off, I disconnected the single wire from the temperature sending unit and switched on the ignition without starting engine. The gauge pointer stayed in at the Cold mark. Using a Jumper wire, I grounded the sending unit wire and the needle on the gauge went to the Hot mark.
I quickly turned off the ignition, and replaced the sending unit with a SW-2328 (F1SZ-10884-A) Temp Sender. Warmed up the engine, but still no reading on the dash gauge.
Malibu :: 2003 Chevy Temperature Gauge Not Working
2003 Chevy Malibu 3.1 temperature gauge stopped working last night, this morning having trouble starting, no check engine light fans do turn on have heat, replaced the coolant temperature sensor but gauge still not working?
View 1 RepliesPrius (2004-09) :: Outside Temperature Gauge Not Working Properly
I have a 2009 Prius. Last summer I noticed that the outside temperature gauge was not working properly. I asked at the wonderful dealership I go to and no one knew anything.
View 10 RepliesPhaeton :: Outside Temperature Gauge And Park Distance System Not Working
The outside temperature gauge and park distance system on my Phaeton isn't working. In place of the temperature reading on the dash it just says --.-C I've had it scanned at my local Bosch diagnostic garage and it showed a fault on all six front parking sensors. I can't recall whether he mentioned the temperature sensor as well but I put a new one on anyway as they are cheap and easy to get at. It made no difference. They were very busy so didn't have an opportunity to do any further investigation or dis-assembly and I was in no rush so am taking it back next week.
I have checked the two block connectors which the wires from the parking sensors and temperature sensors go in to and that seems properly connected. Is there another connector somewhere or is there a fuse that protects these somewhere as there isn't a fuse described in the manual as being related to these?
Nissan - Altima :: 2005 - Engine Temperature Gauge Isn't Working
My sister drives a 2005 Nissan Altima. I am not real familiar with Japanese OEMs but I do most of my own repair work on my car (which currently has issues of its own). What's wrong and how do I go about making the repair...
View 8 RepliesToyota :: 1987 - Fuel And Temperature Gauge Won't Working Suddenly
I borrowed a friend's small Toyota truck for a few days of easy chores, and made a point to check the fuel at the beginning: the gauge showed 3/4 full. Four days and only 25 miles later, when I got in to return it, I noticed the fuel gauge was not working, I'm certain there's no fuel leak, I would have noticed that: the truck had been parked on my property the entire time, driven only a few hundred feet from one spot to another moving firewood around, so I would have smelled the gas if there was a leak.
When I added a couple gallons of fuel, the gauge didn't budge. Once on the road, I realized that the engine temperature gauge was also dead - no change on the gauge after 10 miles. So I have two non-functioning gauges which failed on my watch. This may not be directly my fault, but as my friend is kind enough to lend the truck whenever I need it, my contribution is to provide maintenance.
Is there anything in common between the two gauges which would explain the synchronized failure? Or is this total coincidence? This one is outside my experience, so don't know where to start. It's a 4 cylinder, 5 speed manual, base model truck, about 150k, generally runs just fine. There are no other gauges, and I don't recall what warning lights there might be, but I didn't see any after I realized there was a problem. Would the whole instrument cluster die at once, or could this be something like a bad ground for the cluster? I don't mind investing effort into tracking down and solving a problem, but if it needs a new cluster, that will cost more than I'd like to contribute, yet the problem occurred while I was using the truck (gently). My total use of this truck for all the times I've borrowed it is certainly less than 300 miles, so I'm reluctant to fund the entire repair if this is something that just comes with age.
Pontiac - Montana :: 2004 - Temperature Gauge Not Working Properly?
I have a 2004 Pontiac Montana with about 107500 kms on it (VIN: 1GMDX03E24D183870) and the coolant temperature gauge is not working properly. Sometimes when I start my van, the temp gauge is pinned at MAX temp and stays there the whole trip...other times it's pinned at MIN temp...and other times it seems to work OK.
When it's pinned at MAX temp, I check the actual temp that the on-board computer is seeing, by using my OBDII scan tool...and I get about 87 degrees C when I'm halfway into my trip (i.e. - when the van is at operating temp), which seems OK. All the other analog gauges are working perfectly.
I read a lot about the issues with "connector C305" on the Internet on the Montana vans...could this be the problem?
Golf IV / Jetta IV :: 2005 - Engine Temperature / Fuel Gauge Not Working
I have a 2005 mk4 gli and the other morning I went out to start my car for work and all I got was crank no start. I then realized my fuel pump wasn't priming when I opened the driver door. After work I came back and checked the fuel pump fuse and swapped the relay with another I had, still nothing. A buddy of mine decided to check the connector at the fuel pump for power, using a power probe I believe he hit all or the majority of the wires with 12v of negative and/or positive power. He then unplugged the connecter and plugged it back in and the car fired right up. But I noticed that my fuel gauge, engine temp gauge, and outside air temp readout were all not functioning. I've searched and searched without being able to narrow down a solution.
View 19 RepliesFord 7.3L Power Stroke (1999-2003) :: 2002 F350 - Outside Temperature Gauge Reading Wrong
I have an 02 f350 7.3 power stroke...Yesterday I noticed the outside temp was reading wrong,it was jumping from 67 to 86 to 92 back to 67..Temp was prob around 90 with high humidity and my a/c was on..So I got to where I was going and when I restarted my truck to go home the fuel gauge dropped to empty(I just fueled the day before) and fuel light came on and outside temp still wrong on the overhead digital display...Are these two things related???
Stopped the truck restarted it and fuel reads correctly again....Went out today and fuel light back on and on empty...Outside temp wrong again,a/c is on .....I disconnected the batteries when I got home to "reset the system"if there is such thing, fuel gauge working but outside temp wrong..?? Where is the outside temp sensor ?could condensation be running onto the sensor and throwing off my temp gauge? Just strange that both these things happened at the same time......I don't think its a fuse or they wouldn't work at all. I should mention all the other gauges work correctly...
Century :: 1999 - Coolant Light Blinking / Temperature Gauge Inside Is Ok
I have replaced radiator and thermostat, awhile back.. I checked and there is antifreeze in the radiator and the reservoir. I don't drive it unless i really have to. and not to far,lots more work to do on it. But the coolant light started blinking the other day. Temperature gauge inside is ok. What could this be? what should I do? Still haven't got the blower working, heater / ac / defrost.
View 5 RepliesPassat (B5) :: 1999 - Coolant Temperature Gauge Reaches At 190 Within 5 Minutes And Stays?
I have a '99 1.8T Passat. The coolant temperature gauge normally reaches operating temperature of 190 degrees within about 5 minutes and stays there. For some reason, after reaching 190, it sometimes drops by 20-30 degrees and is running cooler than normal. Once time it dropped down, then came back up again, while driving a steady 65 mph. The coolant level is full and nothing else has changed.
I guess there are a few possibilities: a thermostat stuck open too far, a failing temperature sensor, bad gauge, or loose connection at the sensor. The car has 145K miles and the thermostat and water pump were replaced at about 100K miles. What is going on? If it runs a little too cool, is that a big deal? How would I diagnose it? Where is the temperature sensor?
Toyota - Tercel - Radiators :: Heat But No Indication / Temp Gauge Barely Nudges
Got a 1995 Toyota Tercel. As the temps have dropped, I have started to use the heat again.
The heat comes on, but not nearly as warm as I remember. And now the temp gauge barely nudges - but does seem to nudge - above stone cold.
I checked the coolant today while the engine was cold. The reservoir is empty but the radiator is filled to the brim.
This isn't the first time this season it has been cold. My best recollection is that, until this week, the heater and the temp gauge had both been working fine.
Ford Super Duty (1999-2016) :: Fuel Gauge Not Working
Everything was working fine, getting down to about 1/4 tank. I do the usual, fill up, startup, reset the trip, and look at my level and it hasn't changed, neither has the 'km until E'. What would cause this? Failed Sender? No check engine light (yet). I guess I'll be watching the trip meter for a while.
View 8 RepliesFord Transmission :: 4R100 - Temperature Gauge Installation
How to install a temperature gauge for the 4R100 transmission in my 1998E350 w/ V10 engine Van? what's the normal temperature for this transmission?
View 8 Replies