Ford Aerostar :: 1987 - Draining Trans Fluid From Torque Converter?
How to drain the tranny fluid from the torque converter , I am dropping the pan and installing new filter and fluid, I want to get as much of old fluid out as i can It has a 3.0 engine with overdrive...
View 11 RepliesFord Excursion :: Trans Line To The Cooler Leaking Fluid
This line is rusted out on my V10 and leaking fluid.
How hard/expensive is this to fix?
I'm in the middle of doing my exhaust manifolds right now, so I'm hoping it's a simple bolt-on fix.
Ford Excursion :: 2003 V10 - Trans Fluid Spitting Out Of Vent On Top
I just got my 2003 excursion v-10 gas and its bad but when I'm towing my camper it weighs 8500 lbs empty and I'm trying to back it up on the beach the tranny ( when I'm in reverse ) starts spitting trans fluid out the vent on top ! went on fire twice ! the trans temp gauge never gets hot tho and other than that it works perfect, I was told this was a big problem?
View 14 RepliesJeep - Liberty :: 2008 - Power Steering Fluid Into Brake System
I had a line blow on my steering rack, and I was taking it to the garage well I decided to add some power steering fluid but instead I added it to my brake system , (yes I know it was bonehead move on my part when I do know the difference). Any ways I drove my 2008 jeep liberty about 5 miles to the garage, they are changing my rack and pinion because the initial problem, but my question is do I bite the bullet and change the master cylinder, brake lines and calipers??? I do a lot of driving on highways , and I am been getting mixed answers yes change it all and no just flush it out.
View 9 RepliesFord Transmission :: 2000 Excursion Overheated And Leaking Trans Fluid
2000 Excursion 7.3 unk transmission
Quick run down on the situation. It has been terribly hot here bumping 105 degrees. I was told by a man he could see fluid leaking and it was trans fluid. I checked it and filled it up and got it to the shop.
Next day they said it was not leaking and that it probably overheated. They recommended an after market trans cooler. They put it in and off I went. 60 miles later I got fluid all over the rear of the truck. I filled it up again and got it home. Shop says I need a new trans.
Ford Excursion :: Smoke Started Coming Out From Under The Hood - Trans Fluid Leaking
I have a 2000 2wd with the 5.4 in it. I tow a travel trailer and loaded is 6500lbs. Today leaving the campground I had to climb an extremely steep hill as soon as you left the campground. No time to build speed. The old Ex made it, but I was definitely worried. The truck ran fine the rest of the 2 hours home. I went to back my camper into its spot to store, and smoke started coming out from under the hood. When I crawled under it, tranny fluid was leaking on the ground. A pretty steady drip. I let it cool down, added fluid and drove around. Didn't leak anymore. Did the tranny just get hot and had to burp? The drip was coming from where the tranny connects to the motor.
View 8 RepliesFord Excursion :: Trans Fluid Leaking Out Of Bell Housing Onto Y-Pipe / Smoke Coming From Under The Hood
A little background info...up until about 6 months ago my 01 Ex V10 was a grocery getter for the wife; only got a few thousand miles a year for the most part. Since we moved from Washington state to Texas it has turned into my daily driver (after a 2500 mile drive towing 8k trailer).
A couple of weeks ago we were running errands and after we got home there was smoke coming from under the hood, but I couldn't pin point it. I let it be because I figure it would let me know when something was really wrong. A few days later it did it again but this time I found the problem; transmission fluid was leaking out of the bell housing onto the y-pipe. I did my research and come to find out it is most likely the front pump seal that got soft from overheating. So my buddy and I drop the transmission and replace the seal. Put it all back together and everything seems great.
Another week goes by and we have driven the Ex fairly extensively around town and even took a couple short day trips and everything is great. Then as we are turning onto an on ramp to get on the highway I give it gas to speed up and all of a sudden the RPMs climb like it dropped into neutral. I had enough momentum that I got over onto the shoulder and started to check thing under the hood. Looked like I was low on trans fluid; ok so I added a quart. Put it in "D" and still nothing. Then I try "1", "2", "R" and they all work fine.
Ford 6.7L Power Stroke Diesel :: Fluid Leak On Top Of Trans
I was spraying undercoating yesterday and noticed a trans leak, it looks like its coming from the top of the trans. Not a lot of fluid just enough to coat the trans on top. I tried using an inspection mirror but i still cant see the leak.
View 4 RepliesFord 6.7L Power Stroke Diesel :: 2011 F350 - Trans Fluid Leaking?
Took my '11 F350 CC 6.7 Lariat with 31k miles on it into the dealer to have the tranny fluid leak looked at. I noticed this leak a few weeks ago as the bell housing was damp with fluid and the bolts heads on the underside of the poly engine oil pan were pooled with fluid. It is a very slow leak as I have parked it for 3 days and there were no drips of fluid on the ground, just collecting on the grid like pattern on the oil pan. Checked Fluid level and it is also full.
Anyway, the dealer put dye in the tranny fluid and told me to drive it for a few days. I took it back in on Monday and called this morning for an update. The mechanic informed that they ordered a new torque converter and some other parts to be "proactive" because he believes the TC is the issue. I asked if the cab would have to be pulled and they informed that all the work could be done from underneath. Glad I noticed this before the B2B warranty expired because this would have been expensive. I will be THOROUGHLY inspecting the entire vehicle from top to bottom before I hit 36k.
Ford F-150 - 1997-2003 :: 4R70W Trans Fluid Leaking - Puddle Of Fluid Under The Truck
I have a 1997 Ford F-150 XLT 4x4 with the 4.6W and a 4R70W trans. For the past year is has been leaking trans fluid and has slowly got worse and worse. At first the truck would only leak at high speeds (when driving on the interstate for extended periods of time) and now It has gotten to the point where I am adding close to a quart of fluid a week. ( roughly about a quart every 300 miles!). I thought that it was the pan gasket leaking at first, so I flushed the trans fluid (dropped the pan and drained the TC and put on a new filter) put a new gasket on and torqued it all down and added some new Valvoline max life fluid. The first trip in the truck I noticed a puddle of fluid under the truck again.
The pan looked like it could have been a little warped, so I ordered a new pan and a new FoMoCo gasket (the one the came with the new filter was the cheap felt type). I thought I for sure had fixed the truck this time, but I drove it and once again it was still leaking. I checked all that I could before replacing the pan and gasket. I checked the trans cooler lines and fittings (no leaks) I pulled the inspection plug and it was dry (so I ruled out the front pump or TC leaking). The whole underside of the truck is covered with fluid so it is hard to pin point the leak, but most of the fluid drips down on the transmission cross member.
Ford 7.3L Power Stroke (1999-2003) :: Front Driveshaft Locked Again - Soak Them In Trans Fluid?
Re packed / cleaned my hubs. Did a 600 mile trip and front driveshaft is locked again. Am trying for first time soaking them. They are in tranni fluid right now. I can't afford warn hubs. Is there any other tricks? Or will I have to soak them every few months?
View 13 RepliesFord 7.3L Power Stroke (1999-2003) :: ELC Coolant And Water Mixed In Trans Fluid - Bad Radiator?
I've got a 7.3 tranny that has had ELC Coolant and water mixed in with tranny fluid because of a bad radiator. I drained the fluid from the tranny a week ago and when I pulled off the pan today there is still junk in there. I'm planning on putting in a new filter, gasket and Mercon V but how do I clean the old stuff out of there? Picture.....
View 14 RepliesFord 6.0L Power Stroke Diesel :: 2003 Excursion - Trans Would Not Budge In Any Gear
After doing some hunting/wheeling with my son, got back to town and 2003 Excursion w/ ~145K miles would not budge in any gear. No codes with Scangage. After 30 minutes I finally thought to rev it up and it shifted hard into gear, and drove normal home. What do do now?
View 4 RepliesFord Fuel System :: Light Won't Shut Off After Draining It 3 Times?
I need the torque specs for the bolts that hold the cover on the water seperator. I'm taking it off to see if I can clean the water sensor. My light won't shut off after draining it 3 times.
View 1 RepliesCamry :: 2010 LE Power Steering Fluid Overflow - Steering Very Tight At Low / Parking Speeds
2010 camry LE
A family member did a tune up on the car and did not realize that the power steering reservoir had a HOT and COLD min/max lines. He filled up to the max line for HOT while the car was completely cold. He also filled up with Prestone Power Steering fluid with Stop Leak instead of ATF/DEXIII.
The car was driven a few times for maybe 50 miles in total before I found out about all this and I drained the fluid out to the appropriate levels. However the steering at low/parking speeds is still very tight (tighter than what I used to remember, at least).
Did he royally screw up the power steering system here? What can I do?
Ford Excursion :: Upgrading Sound System - How To Make Steering Wheel Radio Control Harness?
I am in the planning stages of installing / upgrading my X's sound system. This isn't the first time I've done an install like this before, but am running into a bit of trouble with the steering wheel controls.
I know there are options out there as far as interfacing, but my problem is finding the other harness. To be more specific, I know if I pull my radio out, there are 2 harnesses back there. One is the one you get the kit and splice the after market radio into the factory harness. EASY I Know.
Now, need a harness that plugs into the other plug? I'm not a fan of cutting/splicing into factory wires. Most of the steering wheel control kits just require you splice with 2-3 pins on that other Plug and you should be set. I'd really love to just have another adapter that plugs into that harness so I can connect what I need.
Ford 7.3L Power Stroke (1999-2003) :: Power Steering Fluid Spurting In Left Tire Well
While turning very slow and sharp on the farm, I heard a pop under the hood. I then lost power steering and brakes. I saw power steering fluid spurting in the left tire well behind the tire. Look under hood and saw fluid coming from a fitting on the side of the power steering pump. I have attached a photo....one photo with nothing and then other with a screw driver tip on the fitting.
It appears that the the pressure fitting blew out the side when I turned sharp. It has a nut from which it came (compression of some sort?). I can push the nipple of the fitting back into the nut but I guess the pressure is gone.
Ford 6.7L Power Stroke Diesel :: CEL And Exhaust Fluid System Fault Came On
My check engine light just came on and a few miles later the "exhaust fluid system fault" also came on. I plugged in my scanner and these codes came up:
P2479 b1s2
P2033 b1s2
P050E
P0231 b1s2
I'm assuming these mean bank one sensor 2 is bad. Need to verify? I don't remember all these codes when the #4 sensor went bad.
Ford 6.7L Power Stroke Diesel :: 2014 F250 - Exhaust Fluid System Fault
2014 F250 Diesel... I got the msg saying 50 miles until speed limited to 50 mph. None of the earlier warnings re adding def. check def on computer and it said it was ok. I even added def and it only took a small amount until it overflowed. It was more than 1/2 full. The error message did not reset. I drove it around for several miles and it still would not reset. Having it services as we speak, and the tech is still having difficulty running down the cause. He has done a regen,and reset the computer and etc and still has not resolved the issue..
View 14 Replies