Ford Excursion :: 2004 - Dually Rear Installation?
I am considering converting my Ex to a dually. I have located a 2006 dually rearend with the same gears as my rear. My Ex is a 2004 4X4 so I am interested in how easy the physical installation would be to put the 2006 rear in a 2004 Ex.
View 14 RepliesFord Excursion :: Rear Brake Caliper Line Installation?
Routine maintenance gone wrong.
Installing rear brake line and failed to put on the rear washer and stripped out the bolt hole mostly. Will still unscrew and screw back in but not enough to stop a slow drip. Is there an easy repair or time for a new caliper? Thread tape is not brake fluid resistent.
If no repair, what brand should I go with? Are they all similar or MC better? Can get Fenco for $50 and MC for $100. A1 Cardone and ACD for about $75.
Ford Excursion :: 2002 - Installation Of Larger-screen Flip Down DVD System?
I just bought a 2002 Excursion limited. It has a tiny flip-down screen in the roof and a VHS player in the back of the center console. I would like to install a larger-screen flip down DVD system, but do not want to chop things up. In other words, what options are out there for a stock-appearing setup with larger screen?
View 6 RepliesFord Excursion :: 2002 - Heat Not Putting Out
2002 with 7.3 and Auto Climate Control...When the engine temp is at normal operating temperature, there is minimal heat coming out of the floor (on floor setting) and then when I turn on the rear heat there is almost no heat at all. Both fans work properly. I noticed when I turn the temp setting all the way down and then back up to 90* I can get what feels like 65-70* out of the front. Again, almost no heat on the rear. I still need to check the hoses to see what's happening at the heater core. I'm thinking it might be the controller, but not sure how the ACC plays with the rear controls.
View 13 RepliesFord Excursion :: Rear Heat Won't Working?
the rear heat doesnt work, the front heat works and the rear AC works fine.
View 6 RepliesFord Excursion :: Intermittent No Heat In Front Or Rear
I was driving yesterday and had no heat, tried rotating the dial several times, changed the vent setting and such and no heat front or rear. Then all of a sudden while waiting for a train to pass, the heat started working in the front and rear.
This morning I stated her up and had heat, but by the time I got to work (30 minutes) it was barely warm. Due to heated seats! It's 26 degrees out and I'm at work, so it'll be this evening before I get a chance to look at it.
2000 limited v10 4x4 in case it didn't show up.
Ford - Explorer :: 2002 - Rear Heat Thump Noise By Blower Motor?
Started up the 2002 EXP today and thought the fuel pump was failing. Get a consistent thump every 1 second. Later today i looked and noted the noise is coming from drivers rear fender well (i think). I took off the small plastic cover of the rear blower motor and thought it was in that area. Disconnected the motor and still thumps. Disconnected the blower motor resistor block and still thumps. Looked at the overhead consol and the rear blower was on HI. Turned the blower down and as you reduce speed the noise volume is lower. Turned the switch off and i thought the noise was gone. Pulled the cup holder above the fender well looking for a relay or something in that area. I cant isolate the noise but seems to be real close to that area. Later i heard the noise, very faint, and the blower switch was off. Turned it to 1-2-3 and it gets much louder. Turned it off and very slight noise. What am i looking for? My hearing is not accurate enough to find it.
View 2 RepliesFord Excursion :: 2002 - Rear Lights Not Going On When Put It In Reverse
2002 excursion with 7.3 diesel. A while ago i had problems with it not starting, and a buddy of mine worked on neutral safety switch. It was the issue, and it then worked. shortly thereafter, i noticed the backup sensors were not working, and figured it was just my luck. what i also didn't notice was the rear lights were not going on when i put it in reverse.
Just so happened one day when I put it in reverse i was a little off in the shifting and the backup sensor worked. I played around and discovered that when i lightly shifted into R (so that it was much more towards Park) things worked. so we ended up trying to adjust it some more. As of now, still doesn't engage backup sensors or reverse lights, and I have to hold the shifter up hard into park to start it. if i don't it wont start. How do I get it to adjust correctly?
Ford Excursion :: 2002 - How To Get Off Rear Window Struts
How to get the struts off the rear window of a 2002 excursion?
View 14 RepliesFord Excursion :: 2002 - Clunk Sound In Rear?
I did a search and most of what I found is about front end/middle body flex, not rear end "clunk" noises.
Bushings?
I'm already planning on replacing all four shocks.
Dodge - Durango :: 2002 - Rear Passenger Air Blows Cold Only / Heat Failure
I have a 2002 Dodge Durango and the rear passenger air blows cold only - was fine last winter. Neither the passenger or the driver controls will get warm air to the rear via the overhead vents. Warm air comes out under the front seats to the rear only.
View 1 RepliesFord Excursion :: 2002 - Rear Side Window Sag At The Back?
The rear (side) pop-out windows on my '02 X have begun to sag at the back of the truck. They operate just fine, but the glass is actually touching the body when they are closed.
It's hard to get a good picture, but I've included a couple anyway.
Golf VI R :: Heat Shield Noise After TBE Installation
Ordered my TBE couple of weeks ago, installed last week. I have been running the 100 octane tune for an entire week. Decided a couple of days ago to put it back to stock to see the difference. When I was running the 100 oct, I was pretty much on it the whole time. When I went back to stock I noticed some heat shield noise so I took it back to have them take a look. While on the lift I noticed a lot of soot in three different places.
View 19 RepliesFord Excursion :: 2002 - Overhead Console And Rear Heater Not Working
Wife just told me tonight that the overhead console and rear heater are not working in the excursion. Of course, we have a 3 hour drive tomorrow and it is cold outside.. The posts seem to center on either the readout not working or the heater not working, but not both. Trying to minimize time troubleshooting outside in the cold.
View 4 RepliesFord Excursion :: 2002 - Small Clunk Sound Coming From Rear End?
I was running a small errand today, about 10 miles round trip. When I started out, I heard a small 'clunk' sound coming from the rearend. When I was on the return trip and making my last stop, the 'clunk' sound had become quite louder as I accelerated, and could really feel it. When I got home, I took a look and was expecting to see maybe a sway bar link detached or the bushing worn.
I did not expect to see two lug nuts completely gone, including the stud, as well as the holes in the rim no longer round. Big gouges in the rim around the remaining lug nuts, about to be sheared off! The other side had two missing lug nuts, however, the rim is still intact. What would cause such horrific damage? I am lucky that I was not driving on the freeway at 80 mph! This is my 2002 Excursion 4x4.
Ford Excursion :: 2002 F250 - Rear Tire Goes Out Sidewall Blow
So rolling down I29 and its cold and the wind is howling. Rear tire goes out sidewall blow. Thinking load rating of C is not enough for the EX?
Anyways not a big deal cause I'm smart! I checked my spare and all the stuff I need to change it cause i'm prepared. Go to put the tire iron on that I removed from under the hood perfect fit too. Guess what, it is way to small for the lugs. Luckily I had earned some karma points the day before working for a guy with a 02 F250 7.3 who's alternator died. A guy in a suburban stopped and his wrench was close enough to crack the nuts.
So after searching and not finding much my two questions are. Any replacement for the factory tire iron that bolts under the hood? Is there another vehicle other then an Ex I can take it from? I like the idea of it being there bolted down under the hood.
What load rating is everyone running and or recommends. I noticed my spare was an F lol which is far from C. My EX is 7.3 and She was loaded heavy with black friday goods.
Ford Excursion :: 2002 XLT - Passenger Rear Door Handle Is Broken
I have a 2002 xlt excursion. My passenger rear door handle is broken. It is the plastic clip that hold the linkage rod to the assembly (slotted) inside the door. I can't find a diagram to get a part number. Just not very technical looking things up... looking for a parts diagram or a part#?
View 2 RepliesFord Excursion :: 2003 - RAS Installation?
Trying to get myself up for the install of my RAS!
Have to finish watching the first set of games tho. (NFL Sunday Ticket)
Ford Excursion :: Installation Of Horn?
Or to put it another way - Yet another Hadley air horn installation. First up made a mounting bracket for the horns......to mount them on the frame.Then another bracket to mount the air tank, wiring and compressor. Finally fitted an illuminated switch to change from OEM horns to the Hadleys. This switch illuminates dimly with the parking lights and brighter when switched to the Hadleys.
View 12 Replies