Ford Excursion :: 2001 7.3 PSD Extremely Hard To Start When Engine Is Cold
Truck runs great if I get it started. Here are symptoms.
-Extremely hard to start when engine is cold
- It will start fairly quick if plugged in all night
- After running there is no issues with starting unless sits over night
- Batteries good and engine cranks fast
- Tests and parts I have replaced
- Replaced GPM (Glow Plug Module) I do not have the relay as most seem to have on their engines. I did replace this unit.
- Replaced Glow plugs all 8 this morning. Since they where cheap enough it did not hurt the wallet.
- Replaced crank position sensor. Tach moves when engine is cranking.
- Checked the HPOR and it has oil about 1/2" from top.
Now what is left to check besides doing a buzz test to rule out injectors? Also if truck runs fine and does not run rough could injectors still be bad?
Ford Excursion :: No Cold Air Blows Only Heat
I have a 00 Ford Excursion and only heat blows out of the front vents, the temp control doesn't work at all! The back has it's own controls and will come out cold (not a/c just the outside air) when the front is on (blasting heat). What this could be?
View 10 RepliesFord Excursion :: Hard To Shift From Park While Running In Cold?
As it's progressively grown colder (which may or may not be related), my truck has grown all but impossible to shift from park into reverse neutral or drive with the engine running when the truck is cold. I often have to shut the engine off, and once I do it immediately is very easy to shift out of park into neutral, and then I can restart the engine. Once the truck has been driven some, it's not hard to get out of park, but if it's shut off for some time (an hour maybe) it will be difficult to shift out of park again. I don't know how to begin troubleshooting this.
View 8 RepliesFord - ZX2 :: 2001 - Hard To Start / Feels Like Not Getting Gas Upon Cold Start
I've been driving my wife's 2001 Ford ZX2 for the last ~9 months.
Early on in taking over driving it I noticed that it was difficult to start, so I had the battery checked. One place said it need to be replaced, but I wanted confirmation so I had it checked at two other places--it was in the normal range. So then I thought it probably needed a tune up since, as far as I know, it had never had one (has ~50K and I know it should've been done earlier). But, that didn't seem to fix it either.
I then had the fuel filter replaced. Nothing. I generally turn the key over for a few seconds before I actually crank it to let fuel in. It is now taking 3 times each startup to do this. And, right after starting it feels like the car is struggling to get gas (as if the fuel filter is completely stopped up or a fuel link is kinked).
Once the car is warm it cranks over on the first time (as if nothing is wrong). The last time I was at the shop they told me I need to have my fuel injection system cleaned. I have doubts about this--they based it on mileage not any sort of actual diagnostic or inspection. I use quality gas and run a fuel injector cleaner at each oil change.
Ford Super Duty (1999-2016) :: Hard To Start When Cold - White / Grey Smoke At Start Up?
Truck: 1999 Ford Truck F 350 4WD Super Duty V8-7.3L DSL Turbo VIN F
Problem: Especially when it is cold outside . . . The truck takes forever to start and while doing so a ton of white/grey smoke comes out of the exhaust.
My starting schema: Turn the key on have the gas pedal pushed to the floor until the "wait to start" light goes out. Then, I turn the key off and back on while still pressing the gas pedal all the way down. When the "wait to start" light goes out again I remove my foot from the pedal and try to start it. I never leave it cranking for more than 5-7 seconds. If, after trying this process several times I will not push the pedal in at all. Also, sometimes I will leave the pedal pushed in while I am cranking it over.
The truck used to start after a couple of tries but lately it won't start at all, even after 20 tries. Sometimes it will spin up for a second as if the engine gets going but then just doesn't continue running. When it is warm out it will usually start after a few tries but doesn't seem normal to me. After I first bought the truck(used) it would start up within half a second after turning the key.This all started after I had to fix an o-ring that was damaged on the top/back of the motor that was dumping all my oil out of the top/back of the motor.
Ford Excursion :: 2004 - Hard Start When Warm?
I got a new to me 2004 4x4 Excursion v10. 98,000 miles but why it is hard to start when the engine is warm. Starts right up when cold, engine not ambient air temp, idles great once started. In park idles at 1,000 until normal op temp is reach, then down to 750ish. In gear idles right at 650. Drives great. Plenty of power, does not surge, averaging 13.7 mpg over two tanks (70% hwy, 30% city) and no codes. Since it is new to me, and I don't trust people to do maintenance I have:
Replaced spark plugs
Replace downstream o2 sensor (the two upstream were not in stock)
Replaced fuel filter
Replaced belt
Replaced crank sensor (because the belt was already off)
Changed oil (mobile 1 5w20) and filter.
Ford - Mustang :: 1998 - Hard Start At Cold?
Simple question: Is it possible that battery problem/corrosion in battery cables would allow car to crank but not start on first try when cold? (Car normally starts on 2nd or 3rd try). I've read some places that if car cranks its not a battery problem but I'm not convinced.
Background:I have a 98 Ford Mustang (approx 140,000 miles) that occasionally has trouble starting. Car normally takes 2 to 3 tries to start first thing in the morning or if it has been sitting for a while. It always cranks but doesn't turn over. I had it in the auto repair shop, they said it had to do with IAC valve being stuck open. They recommended to replace throttle air by-pass valve. The repair was done and when I came to pick up the car I heard it take three tries to start before they brought it to me from the back. I asked about it, so the service advisor said he would go and talk to the tech, he said he talked to the tech and that there was a lot of carbon that he had cleaned out and maybe remaining carbon in the system caused problem, I got the idea that they seemed to think everything was fine if I had any problems I could bring it back. The car became even harder to start, now taking up to 8 tries. I brought it back and they said that the new IAC had to be adjusted to allow more air. I picked up the car, they said it was fine, but now it still takes 2 to 3 tries to start it first thing in the morning.
In the past, I have had trouble with battery and battery terminal corrosion, have had new terminal ends put on my battery a few times, last time was probably about 6 months ago. Terminal ends look very corroded again. I'm thinking about just asking them to replace the battery cables and see what happens.
Ford Excursion :: Stumbles On Cold Start?
In the mornings my 6.8 gasser stumbles when started cold ('cold' could mean an overnight temperature of 50-70 degrees F). This stumble lasts anywhere from 2 - 5 seconds and then it revs on its own to ~1,500 rpm. I'm not giving it any throttle upon start-up. Other than this the truck runs fine (~110k miles on OEM engine). Any thoughts on what may be causing this?
View 1 RepliesFord F-150 (2004-2008) :: 2005 STX Hard To Start When Cold
I have a 2005 STX with 107,000 miles on it. When it is cold you have to turn the key on for 5 seconds twice then start it. When it is warm it will start like it always did. When the temperature outside is 60 or above you have to do the key thing about 5 times. I think it is my fuel pump...
View 4 RepliesFord Ranger / B-Series :: 1990 Truck Won't / Hard Start When Cold
My 1990 4.0 refuses to start when the air temperature outside is at approx 40 degrees or below. It will crank until the battery runs dead if I let it. At approx 50 degrees farenheit the truck takes forever to start and always backfires out of the tailpipe and intake manifold (blowing off a hose on the vacuum tree) before it starts. If I can get it to backfire, it will start eventually. If it does not backfire, then I can run the battery dead and the truck still refuses to start. This condition has grown from a little problem to a huge problem over the past 6 months. Here is what I have done so far, including regular maintenance items.......
KOEO test checked OK
KOER test returned code 77 multiple times (TPS).
Replaced Throttle pos. sensor
Replace Idle air bypass valve
Subsequent KOER test came back with no more codes except 11 - OK
Load tested battery
Made new heavy gauge battery cables for + and -
New plugs, wires
newer starter
Changed coil pack for known good one off my explorer
Visually inspected hoses for vacuum leaks, replaced 1 cracked hose
1990 Ranger ext cab 4X2 4.0L, K&N air filter in stock airbox, Pacesetter headers, single 2 1/2" exhaust, stock cat no muffler, 260K on truck, 104K on good used engine from my 1994 Explorer. Purchased Ranger brand new in 1990. A4LD w/ shift kit.
Ford 6.0L Power Stroke Diesel :: 2003 - Hard Cold Start?
2003 Excursiom 4x4 Limited
My first Diesel. Runs and drives great. Torque Pro app only showed coolant temp at 188. Would not show oil temp. Hard to cold start. New injectors. Has a programmer. He is asking 12K. It has 209K miles.
It belongs to a friend of mine and he rarely drives it. It stays under a cover most of the time.
Ford Excursion :: 2000 - Hard Start - Clunking Noise When Pedal Pressed?
The vehicle is a 2000 Excursion 7.3 Diesel. I have never owned a diesel before....
First issue is that I have developed a hard start. It started last Saturday, and went from sporadically starting hard, to starting hard every time. I have 146,000 miles on her. She cranks strong, but will not turn over the first time, sometimes takes 2, 3, or 4 times. (Foot on gas pedal) I don't know if it's an issue of not getting enough fuel or what. Occasionally, even after she starts, it's very rough (shaking the whole vehicle, and acting like she wants to die) until I rev the engine and she smoothes out. After she smoothes out, there is no problem with wanting to drive, she's strong. If I kill the ignition, and start up immediately, she starts the first time, it's only after 10 minutes or so of being off.
My next issue is a clunking noise when I press the gas pedal. I don't know if it's the tranny, because she shifts pretty smooth for the most part, doesn't miss gears, etc. I could be travelling say 50MPH, press the gas pedal very little, and I can hear the clunking, and actually feel it every time I press it. (Don't have to be mashing the pedal, happens on very light presses as well).
I have the TS Performance 6 position chip, otherwise she's stock. I tow roughly a 7000 travel trailer every couple of weeks, never any problems before this.
Ford F-150 - 1997-2003 :: Hard To Start In Cold / Cranks Fine But Does Not Want To Fire
My girlfriend has a 2003 f150 4.6lt pick up its a great truck most of the time. Problem is when the temp gets in the neg double digits it becomes very hard to start it cranks fine but doesnt want to fire. When it does fire it might stall a few times before it stays running. The last cold snap we had I replaced the battery and in the summer the starter got changed. I have heard that this model of truck are known for hard cold starts. I am just wondering if this is true and any other thing besides block heater. It is strange that my 89 gm pickup will start no matter what temp and I'm having problems with the newer truck.
View 1 RepliesFord 7.3L Power Stroke (1999-2003) :: Hard To Start Cold - No Codes
My truck is hard to start when cold and I suspect glow plugs. But it is not showing any codes? If it is a glow plug or glow plug relay at fault , should it throw a code?
View 10 RepliesFord 6.0L Power Stroke Diesel :: Hard Start When Cold - Block Heater?
Don't drive the truck but once a week but since its gotten colder here than usual is been harder to start when cold. Of-course I go thru the glow plug wait and then it kinda stumbles when its about to start. I do it again and most of the time is starts but seems rough for a few seconds. Once the truck is warm, no more problems starting.
I'm wondering if I have a glow plug gone bad and that cylinder is not warming up for me. Today I plugged in the block heater for maybe 2 hours and it started first time. Also, if just leave the block heater plugged in for long periods of time.. would it get to hot?? and wonder how expensive that is, most heater are costly to run. I have a timer but just wondering.
Ford - Explorer :: 2000 Won't Idle When Cold / Hard To Start And Keep The Engine Running
I have a 2000 Explorer W/4.0 SOHC engine. With summer nearly over and fall on the way, I need to figure out what is going on with my engine. This problem has been going on for the past 2 years. As the outdoor temperatures get cooler, the harder it is to start and keep the engine running. This starts happening around 65 ambient temperature, and gets worse as the temps drop. By 30, I can barely keep the engine running.
Odd thing is, all I have to do if the engine starts is, keep my foot on the pedal to keep the engine around 2000RPM, put it in gear and start driving. After about a mile or two, the engine runs normally, and will do so the rest of the day. So far I have cleaned the air flow sensor, replaced the IAC, replaced all the injector "O" rings, and cussed a lot. I smoke tested the engine and the only vacuum leak is a very small one at the EGR valve.
Ford Super Duty (1999-2016) :: F350 7.3 Diesel / Hard Cold Start
i have a f350 superduty with a 7.3 turbo diesel and I pretty much hafta keep it plugged in to get it to start, i have installed all new glow plugs and both relays have been changed and the problem is still there, only other option i have not tried yet was changing the pcm controller but unsure if that is the problem ..
View 14 RepliesFord 7.3L Power Stroke (1999-2003) :: Hard Start When Cold / White Smoke
When it is cold out side like 20 degrees I'm having problems starting my 2000 7.3 I'm cycling it about 5 times and misses smokes white for a bit then stays running I was thinking of changing out the fuel filter. What it could be?
View 6 RepliesFord 7.3L Power Stroke (1999-2003) :: Hard Cold Start / Now EBPV Not Working
It's been a while but thats because the truck has been performing well.
Current problem: The truck has been hard to start this year as if the glow plugs are not working or are bad. It will start right up if I use the block heater.
Just recently, I also noticed that the EBPV is not coming on when warming up the truck.
Also, This winter season, the engine temp is not coming up to normal. the engine temp needle is more on the low side towards the C and definitely less than 1/2 way up where is normally is. When driving on the highway, the temp comes up more. but sitting at idle it barely gets warm.
So not sure if all 3 are related or not, but looking for a starting point.