Ford Excursion :: 2001 - Cruise Control Won't Working?
Looking for any pointers on fixing my cruise control Have looked around under hood but what it looks like. I've got the air working again,put Warn hubs on and have ordered the Hellwig rear sway bar,adjusted steering box i/2 turn....
View 14 RepliesFord Excursion :: 2001 - Cruise Control Not Working
The cruise control in my recently purchased '01 Excursion isn't working. I've done a lot of searches and discovered there was a recall for a wiring harness: 2001 FORD EXCURSION Recalls
I called my local dealer and they stated there aren't any open recalls for this vehicle, so the previous owner must have taken care of it.
Is there any way I can verify that the warranty work was done? Can I visually inspect the harness? What else I can check to fix the cruise control? The lights on the steering wheel are illuminated.
Ford Excursion :: 2001 V10 - Cruise Control Not Working
I have a cruise control issue. I tried the self diagnostics test, and the "cruise" light would not come on. (Also read that 2001 did not have a self test, so maybe that's why it didn't work? Also, when I first start it, all the other lights turn on except for cruise.) I checked the brake master cylinder and it has the double fuse wiring with 2 good fuses. Not quite sure what else to test. I just bought the X knowing it had this problem, but didn't know how much I would miss cruise control until driving without for a week.
View 12 RepliesFord Excursion :: 2001 - Cruise Control Stopped Working
One day it work and the next day it didn't. I checked the 15a fuse and it was good. What else should I be looking at?
View 12 RepliesFord Excursion :: 2001 - Cruise Control Worked For A Split Second Then Stopped When Get Onto Interstate
My first 2001 Excursion when I bot it had a 124K on it..We took off on a trip to Colorado from OKC and noticed the Cruise didn't work replaced the Deactivation switch with one from Advanced Auto it worked for a couple days. We went to get on to the Interstate and it worked for a split second and then stopped I would try to set the Cruise and the Horn would honk...
So I put it in the shop for two days he changed out the switches in The steering wheel,Which the off & on kind of sticks, Changed out the Deactivation switch on the master cylinder checked all the fuses Lights & Servo. The mechanic could not figure it out...So I brought it home and when I run the self diagnostic and I get as far as holding the off button and turning it to on and it blinks once... press the On button & nothing...I have been working on this for the last two days..
Ford Excursion :: When The Engine Is On Horn And Cruise Control Not Working
Many of you said it was the "ClockSpring" that needed to be replaced. But I already did that. A brand new clockspring on it. The horn only blows when the engine is off and when the engine is on the horn and Curse Control don't work. I have a 2001 Excursion. So What could the problem be? It works with the keyless remote. But just when you driving down the street and some bone head cut you off you can't just it.
View 5 RepliesFord Excursion :: 2000 - Hesitation / Surge And Stumble Over 1500 RPM
I recently picked up a 2000 Excursion with the 5.4 V8. Engine has 150,000. I got it cheap because it has a surging problem over 1500 RPM. This problem is intermittent.
I have 1 DTC. P1000 which is OBDII checks not complete. I cannot clear this even using the factory procedures. FYI..I have a snap on solus scanner. I think this is a voltage problem, If you try to start the engine with the scanner plugged in, the scanner shuts off, so I'm thinking the PCM loses battery power supply when the starter engages, resetting the PCM.
This problem is NOT a miss.... something isn't opening or shutting off above 1500 RPM. This truck doesn't have an EGR system, it has the EVAP system. This may be the problem, thats why I'm here. OK. heres a list of what I've replaced since I started working on it.
Engine oil and filter
air filter
fuel filter
8 COP's
8 plugs gapped properly
cam position sensor
IAC sensor
MAF sensor
Removed throttle body and cleaned.
Vacuum checks. 22" at purge valve,fuel dia, and vacuum canister
Checking with the scanner at 1500 RPM with problem
SFtrim1% bounces between5-15
SFtrim2% bounces between2-0
LFtrim1% bounces between11-13
LFtrim2% bounces between 5-6
O2S11(mv) bounces between 200-781
O2S21(mv) bounces between 200-800
Ssystem is in closed loop holding throttle at 1500 RPM... Note engine surges when at the RPM or above. I'm thinking the engine is lean, not sure how to read the trim numbers...
Idle is fine ... Problem is intermittent ... Also noticed that engine will only advance spark to 30 degrees @2000 RPM during this problem. I have seen it advance to 38-40 degrees when I do not have this problem, so I kind of understand the power loss,knock etc due to the timing, my question is whats causing it to do this?
EVAP question.... The purge valve should open according to PCM command a certain value, correct? I can monitor the duty cycle % but cannot activate and check proper duty cycle through scanner . When I try to I get an error message of module error -unspecified.
Disconnected hoses at purge valve,Full manifold vacumn on one, nothing on other, no flow through purge valve, but scanner shows 30% duty cycle. I would think the should be a little flow at 30% Maybe my problem? Troubleshoot procedure for the EVAP would be good.
Ford Excursion :: Turbo Surge - Cannot Maintain 70 Mph With Small Load Up A Mild Hill
I have a 2002 EX 7.3 and have never towed anything with it since purchased a year ago. This weekend I towed a side by side on a single axle trailer about 400 miles and could not maintain 70 mph with the small load up a mild hill. Also I could here the turbo surging while climbing hills. I have a AFE cold air intake and that is it. Truck had a aftermarket muffler on it when I bought it. New to the diesels but I thought it should tow that Trailer a little easier. I have no boost gauge or anything. Truck runs great other then this issue. Does not burn oil, get hot or anything out of the ordinary.
View 14 RepliesFord 7.3L Power Stroke (1999-2003) :: 2001 - Surge Slightly On Takeoff
2001, 7.3 sometimes surges slightly on takeoff ??
View 1 RepliesFord Excursion :: Cruise Control Does Not Set
I turn my cruise on and then attempt to set it , nothing happens , doesn't set, no light , nothing. I hit coast and the light comes on but still doesn't hold. Should the light come on when cruise is turned on or set? I checked the master cylinder switch and it's not wet. I also did the self diagnostic test and got nothing but the initial first light blink.
View 4 RepliesFord - Ranger :: 1999 - Engine Will Surge Every Minute
When I turn on dial for fan, engine will surge every minute, will also do the same when air conditioner or heater is turned on. Dealer wants to inject colored fluid in air condition line to find problem. Engine runs smooth when dial is in off position.
View 4 RepliesFord Excursion :: 2001 7.3 PSD Extremely Hard To Start When Engine Is Cold
Truck runs great if I get it started. Here are symptoms.
-Extremely hard to start when engine is cold
- It will start fairly quick if plugged in all night
- After running there is no issues with starting unless sits over night
- Batteries good and engine cranks fast
- Tests and parts I have replaced
- Replaced GPM (Glow Plug Module) I do not have the relay as most seem to have on their engines. I did replace this unit.
- Replaced Glow plugs all 8 this morning. Since they where cheap enough it did not hurt the wallet.
- Replaced crank position sensor. Tach moves when engine is cranking.
- Checked the HPOR and it has oil about 1/2" from top.
Now what is left to check besides doing a buzz test to rule out injectors? Also if truck runs fine and does not run rough could injectors still be bad?
Ford Excursion :: Cruise Control Not Working?
Have this problem?
View 2 RepliesFord Excursion :: 2003 - Cruise Will Not Turn On?
2003 Excursion, 6.0 diesel
replaced disengagement switch on master cylinder (was bad)
replaced cruise control switch on steering wheel (had broken button)
cruise will not turn on, and will not enter self-test mode
all fuses good. Illumination to steering wheel buttons is working. cruise buttons are registering with a scan tool, but still cruise will not turn on or enter self test mode
Cruise went down about the same time I started using the power adjustable pedals, not sure if that is relevant.
Ford Excursion :: Cruise Control Does Not Work
Just got my first X(and Ford) a couple days ago. Anyways, the cruise control doesn't work. I checked the CC switch on the master and it tested fine and I installed new switches on the steering wheel.
When I do the self diagnostic test with the steering wheel switches they all test fine, and on the last button(set) it lights up, but no other flashes. What does that mean? In 1 thread it stats that 0 flashes is the speed control servo.
Ford Excursion :: 2001 V10 Not Running On All Cylinders / Check Engine Light Is Not Coming On
Bought a fixer upper 2001 v10 and it's definitely not running on all cylinders. Also the check engine light is not on and the PCM is not saying it's on (per my code reader) and it doesn't come on when I turn the key on.
Is it possible the previous owner had a programmer of some sort to disable the CEL? If the bulb were removed my scan tool would still show it on. Trying to get it to tell me which cylinders I am having trouble with.
Ford Excursion :: Cruise Control Not Working Intermittently?
I had had intermittent issues with the cruise control not working in my excursion. most of the time it was fine though. after a recent 150 mile trip it stopped working half way through. i didnt worry about it too much..got back into town and checked under the hood. i found brake fluid running down the inner fender well! all over everything under the master cylinder. finally tracked it down to the cruise control switch on the master cylinder leaking. I pulled the plug apart and it was full of brake fluid.
Meanwhile the master cylinder was about half full, so i replaced it with the same switch out of a '96 parts explorer which is the same part luckily. also yes i have had the cruise control recall done. So if you have lost CC and you have a leak replace the switch! seems it can leak..and at a pretty good rate..alittle scary! glad i figured it out before my 800+ mile trip later this week/weekend.
Ford Excursion :: 2003 V10 - Cruise Control Not Working
I have a issue with my cruise control not working. The Ford dealer in my home town has had my truck for 3 days now and cannot figure out what the problem is. I finally went by the dealer and wanted to know what the deal is and how can this take so long to figure out when they have to of seen issue like this in the past. The tech that is working on my truck said he has traced wires,etc and think it has something to do with the after market JVC touch screen DVD/backup camera. My question is would this affect the cruise? I cannot find anything on the net that may point in that direction. The steering wheel controls work for the fan and temp controls but not the radio as its aftermarket. Radio adapter for the controls?
View 14 RepliesFord Excursion :: 2000 - Cruise Control Not Activating
The cruise control isn't activating on my 2000 X. The light will come on, on the dash but it never sets. Are there any common issues with this system and is there anything specific I can check?
View 14 Replies