Ford 6.7L Power Stroke Diesel :: 2012 - Radiator Seam Leaking
Read that this is a common issue, leaking out crimped seam on lower LH (2012 F250 King Ranch). I have called Ford customer service twice, they said "we do not have any recall or programs to cover the out of warranty repair". I keep adding coolant and thinking eventually Ford will address this problem. They did cover my bad EGT sensor....
View 9 RepliesFord Aerostar :: 1997 - Bottom Radiator Hose Connector Leak
I've noticed a spring of coolant shooting out of a connector that I'm assuming is connected to the bottom radiator hose via a smaller hose. Is there a hose that splits off the bottom radiator hose that is smaller. The leak is not coming from the hose, but the connector it's hooked to. Is this a replaceable part? What is it for?
97' Aerostar... 3.0 V6 with AC
Ford F-150 (2004-2008) :: Bottom Radiator Hose Removal - How Much Coolant Left In Engine
2004 4.6 V8 Trition ,two wheel drive, STX Pickup. By removing the bottom radiator hose, will that allow all engine coolant to be drained from engine? If not, about how much coolant will remain in the engine in terms of quarts or percentage of total vehicle coolant capacity?
View 1 RepliesJeep - Cherokee :: Coolant Leak / Drip At Bottom Radiator Hose
I have a 1999 jeep cherokee 4x4 four liter inline 6. have a coolant drip at bottom radiator hose, change hose. but still drip. Could water pump be leaking. and it running down on the bottom radiator hose.
View 4 RepliesCelica :: 1991 - Large Water Leak Where Bottom Hose From Radiator Connects
I am new to working on cars. SO i think my water pump went out on my 1991 celica gts, there is a large water leak where the bottom hose from the radiator connects to the what i presume is the water pump or thermostat, need to know if I am on the right track...
View 5 RepliesFord A/C :: 2001 F250 V10 - Lower Radiator Hose Leaking Coolant
2001 F250- V10... Lower radiator hose has coolant leaking - Right now I cannot tell if its the hose or the radiator itself (hoping not) - I tried to take the clamp off and it broke - Any tricks to removing the hose? its on there pretty tight.... I guess if I don't want to save the hose I can rip it off with a pair of pliers but before I do that wasn't sure.
View 2 RepliesFord 6.7L Power Stroke Diesel :: Upper Radiator Hose Leaking?
After chasing the smell of coolant for a couple weeks, discovered that the upper radiator hose was leaking at the engine. Based on my schedule and drive schedule, and unfamiliar location this last week, I took my truck to the last people I wanted to - the Ford dealer, where they attempted to charge for the hose replacement. During this time I discovered the nature of how these hoses work and asked the tech why they don't just replace the O-rings ... "Ford Motor Company wants to sell you a new hose with labor" - a direct quote from the Ford tech. And that is why Ford is the LAST place I want to go for repairs I cannot perform. I kept the old hose - any spot where you can get the O-rings alone?
View 5 RepliesFord Super Duty (1999-2016) :: 2004 - Transmission Line From Bottom Radiator Leaking?
So this is my major problem, leaving for a camping trip tomorrow afternoon. It's just 15 miles away, easy flat drive. What has happened is the trans line coming out of the bottom of radiator is leaking next to the fitting about an 1/8 ' out, So I can't cut off and splice in hose for the trip. I worked on it for about an hour, rusted on, tried some heat and now have some PB Blast on it and all I am doing is starting to round off the head of fitting. Is there any way to bypass this just to get the camper to campground and then get to a shop while we are gone Don't care if I have to splice and cut, will get new lines later.
2004 f250SD 5.4 83000miles
Passat (B5) :: 1998 - Lower Radiator Hose Is Leaking?
I have 98 passat V6 and the lover radiator hose is leaking at the connector between radiator and the hose. Do I need to change the whole hose or is there maybe an o-ring that should be changed? How hard is to remove the hose? Do I have to go to the dealer?
View 2 RepliesElantra XD (2001-06) :: Heater Not Providing Hot Air / Radiator Hose Leaking
I have been encountering issues with my heater not providing hot air when the engine is idling. My Elantra has around 121K miles on it. I have not replaced the thermostat, water pump, timing belt, radiator, radiator hoses, or done any coolant flushes.
I checked the overflow reservoir and radiator. I didn't see coolant at top of the radiator so I topped it off as well as the reservoir. It seemed to have fixed the issue for now but I had this similar issue about 5-6 months back. I also topped off the coolant and things have been fine until now.
I checked the hoses and squeezed them to see if I could see any notable leaks but didn't see anything. I checked the overflow reservoir tank and line and nothing seemed out of the ordinary. I also checked the top of radiator to visually inspect for any notable cracks but didn't find anything. Also to note, the coolant inside the overflow bottle was bright green and not discolored.
I did however notice a lot of white chalky residue on the bypass hose below the upper radiator hose and the engine block. My guess is that my upper radiator hose is slowly leaking? Leaking in the thermostat assembly? And I also noticed a tiny puddle of coolant below the lower radiator hose at the engine block. See the pics below.
Golf IV / Jetta IV :: Radiator Coolant Started Leaking From Pipes?
Recently I started leaking coolant on the driver side area to the right of the engine:
I am assuming I need to replace some part/tubing that has a leak in it, but I am not sure what any of these things are called. How to identify what leaking part here is?
Toyota - Camry :: 1997 - Cracked Seam At The Top Of The Radiator Causing A Small Leak
I have 170,000 miles on this car. This is a 4 cylinder. The seam at the top of the radiator has cracked, causing a small leak. I have confirmed it is not leaking from the cap if you are curious. So it's time to replace the radiator. My question is: is the radiator easy to replace? I have worked on my car before with basic maintenance (oil, transmission, etc) I was thinking it would be straightforward to replace the radiator myself.
View 7 RepliesFord Super Duty (1999-2016) :: F350 - Coolant Leaking At The Front Seam
I recently did the water pump and hoses due to seeping around the water pump gasket. While there, I decided to replace the overflow reservoir as well - old and slightly discolored. I'm now on my 3rd overflow reservoir - they are all leaking at the front seam. I don't think I have a blown headgasket or injector issues - no signs of white smoke ever, and there isn't any oil or fuel in the coolant. I've also tried a new cap, but it's starting to leak before I build any noticeable pressure - I can back off on the cap and don't get much pressure released. So - just bad luck on parts from Ford? All were OEM from different Ford dealers.
Pics - hard to see on here but go to Imgur to zoom in. [URL] ...
1999 F350 7.3 CCLB Dually. Stock except for DP Tuner and Gauges.
Golf V R32 :: Coolant Leaking Around The Center Seam Of Reservoir
Have an issue with the coolant bowl cracking? Just went down to fire up my R this morning and the check coolant light came on. Noticed some coolant around the center seam of the reservoir. Turns out the top nipple was separated from the bowl.
View 7 RepliesPrius (2004-09) :: Water Leaking Into Battery Through Seam Above Right Rear Passenger Tire
I know some others have had problems with water below the aux battery. I noticed this the other day when replacing the aux battery. I tried to pinpoint where the leak was by pouring water over the seams around the hatch and roof but didn't notice any water coming in. Then I tried pouring water in the seam above the right rear passenger wheel. Pictures are posted below. The water comes through the vent on the body that is just next to the battery. How to correct this?
View 9 RepliesFord F-150 - 1997-2003 :: 5.4L - Lower Radiator Hose
Is it difficult to replace the lower radiator hose on a 5.4L? I'm mainly thinking about access to the connection at the water pump.
View 13 RepliesFord F-150 - 1997-2003 :: 2000 5.4L - Top Radiator Hose Comes Off
I have a 2000 F150 with 5.4 L motor. The last two trips I have had the top radiator hose come off while under heavy load (pulling a long hill) after 5 hours of driving. So far I have flushed the radiator, checked the thermostat, and refilled with G05 Gold and distilled water 60/40 ratio. I do not hear any gurgling in the heater core. Heater seems to work great.
The stock temp gauge shows it right in the middle range between Hot and cold, right before it blows the hose off. I have replaced top and bottom hoses and put new stainless steel clamps at all end except the top, where I am using the OEM clamp that came with the truck. I thought about replacing the top clamp as well but did not want to blow out my radiator, if in fact it is developing high pressure.
Do these clamps get weak with time? Should I use a vacuum attachment on the fill/overflow tank to remove all air before refilling?
Ford Excursion :: Lower Radiator Hose Collapsing Common?
I did all the flushing, cap, thermostat, 50/50 antifreeze, etc, fixes but when I floor it going up an on ramp on an 85 degree day it will go into limp mode / fail safe mode. Bottom hose?
View 9 RepliesFord F-150 - 1997-2003 :: 1999 - Radiator Hose Have No Pressure?
this winter i have found that my truck's heater core isn't flowing, meaning i have hot on the upper hose and the lower is luke warm and there is no heat while running down the road. I have changed the t-stat and the heater core and radiator are new as of four years ago. last year i could roast a chicken with the heat. i also have no pressure in the radiator hose at all, engine runs at normal temp, no over heat situation and i don't smell any loss of antifreeze.
1999 f-150 4.6 150k