Explorer :: 2000 Ford O/D Light Start Flashing After Driving 3-8 Miles From Starting Out
My 2000 Ford Explorer O/D off light starts flashing after driving it after 3-8 miles from starting out. After shutting it off, it resets itself. It seems to stick between 2nd and 3rd (automatic trans) because I get a surge on my RPMs. I took it to two places, spent $200.00 and the problem remains. The tranny shop actually changed a "range sensor" and thought it was fixed. Nope - O/D off started flashing before I even got back home. I've been looking on the internet and it seems that alot of explorer owners have been having the same types of problems. The shops I have talked to have no idea other than rebuild my transmission. It only has 46,000 miles on it! It seems to me that the overdrive is not kicking in when needed and the light comes on.
View 14 RepliesFord - Explorer :: Leak Fluid Out Of The Thermostat Housing
My explorer with 4.0 sohc is starting to leak fluid out of the thermostat housing. How hard is this to do and what can I expect in cost to do it myself. I dont drive this explorer but about 2 miles each way to work as I live on a military post. I have been putting it off ( just keep adding coolant and water) every couple of days. I have noticed that the engine temp doesnt not get up to half way like it use too. Maybe 1/4 of the way on the gauge now. I have always flushed coolant system very two years. It is starting to get some rush in the overflow bottle now too. Other then that she runs good and no other engine issues. She does have a 136k on her.
View 7 RepliesFord - Explorer :: P0128 Code - Coolant Temp Below Thermostat Regulating Temperature
2009 Ford Explorer, 6 cyl, 4.0L, 74K. Read code w/scanner - "P0128 - Coolant Temp below thermostat regulating temperature". Assuming this is pretty straight forward but was wondering what the most likely culprit is (?thermostat?). Ironically, this code popped about a week ago, I cleared it and actually got my inspection sticker earlier today and then later in the day, the CEL came on again and once again, the P0128 code. The coolant level is perfect so I know there aren't any leaks.
View 5 RepliesFord - Explorer :: Temp Gauge Rises And Falls After Thermostat Change And Radiator Drain And Fill
I did an engine swap for a junkyard motor my 4.0 ohv had a very bad rod bearing so I got one from the junkyard with 117,000,or so they say.Anyhow, after its all said and done it runs perfect except the temperature gauge seems to not get as high up on the gauge as before after sufficient driving(it used to run about middle of the gauge) it drops low at idle then goes up and stays up then goes down.it still has good heat, doesn't seem as good as before tho.I changed the thermostat also.
View 8 RepliesFord Excursion :: 2000 - Changed Thermostat Still Overheats?
my EX is a 2000 XLT 6.8 4WD I have 146,000 on it. Last week I replaced the expansion tank with a new one, went just fine no leaks, new prestone at 50/50, today she overheated to the red so I changed the thermostat, still overheating, no leaks fluid level good. What am I missing ????
View 14 RepliesPassat (B7) :: Alternator Failure At About 39,000 Miles
Happy owner of a TDI - SEL for just over a year. One week shy of my 40K service, the alternator failed. All repairs covered with my extended warranty. Tech said he hadn't seen another alternator go bad and certainly hadn't seen a 1 year old TDI with 40K miles! Any alternator issues? otherwise been quite happy with the car.
View 2 RepliesTouareg :: Air Suspension Failure At 70K Miles?
Was driving on some segmented highway concrete that send my front end into quite a thrashing. Slowed down quite a bit and it settle down some but nothing like that before. Pain attention to ride but it feels OK, corners, etc. BUT, over the past few weeks, I've noticed that it has become quite sensitive to sharp transitions (BOTS dots a.k.a. line markers, driveways, etc. so I have a suspicion that one or more of the air spring assemblys has possibly failed or a leak.
It's like the equivalent of a worn out strut. The car hold up. Raises and lowers, etc. But I can't push down on the car to test the response of the suspension like a standard strut car. What is the expected life of the air suspension? And cost to replace pair or all four. Not looking forward to the possible expenses.
Ford Ranger / B-Series :: 2000 - Constant Leak From Gasket Between Thermostat Body And Engine?
I have a real problem with 2000 Ranger, after changing the upper radiator hose and thermostat, I now have a pretty constant leak from the gasket between the thermostat body and engine. Appears to be something that is triggered by the thermostat opening, so whatever the leak, the thermostat is blocking it.
I've changed the gasket, cleaned the mounting surface as good as I could. Tried re-torquing the bolts, but on that score - what is the torque specs for the 2000 3.0 liter Ranger?
But ultimately, what the heck is wrong here? This should be a pretty brainless operation really. Am I tightening the connection too much and cracking the gasket? I guess that has just occurred to me, although the gasket is not as stiff as a typical fiber gasket is.
Passat (B5) :: Steering Rack Failure At 130,000 Miles?
Is that unusual?
View 9 RepliesFord - Explorer :: 2005 XLT 4.0L - System Charging Failure
I had my alternator and battery die on me in Dec 2015 and replaced both. Vehicle ran perfectly fine until this Sept 2016. First thing to happen was the battery light came on and then the System Charging Failure message and the tone came on and off intermittently. I took it to my garage and they tested and said the alternator was defective that they replaced in Dec 2015. It was showing 9V.
So they replaced it again free of charge with another rebuilt alternator. Within 30 min leaving the garage the system charging failure light was back on and again i lost charge to the point where everything was shutting down to the point i even lost the gauge cluster. Took it back to the garage and they checked the plug at the alternator and said it was fine. Then they said the belt was loose.
So they replaced the belt, the belt tentioner, and a pulley. Within 20 min the lights were all back on again and I was losing charge and all the things started to shutdown again. Where I picked up the car at 5PM on a Friday they had left and wont be back till Monday. So I am asking here....what is going on??? What else is there to look at or replace to fix this charging error???
Ford - Explorer :: Code U0101 - Failure To Communicate With TCM
2007 Ford explorer 4x4 V8, U0101 Failure to communicate with the TCM
Vehicle shifts very hard when under load then and when the Traction control light and the "wrench" light come on it seems to be stuck in high gear, if I stop it takes off like in high gear and never shifts, when I do an ignition cycle then the lights go off and it takes off in first gear and shifts as normal unless it's under load it will bang in and out of gear. Where is the TCM located? On a side note I do hear air like vacuum behind the center console when I press the pedal. Not sure if it has always done this or not.
Ford - Explorer :: 2002 XLT - Front Wiper Failure
My 2002 Explorer XLT recently experienced a front wiper failure. Initial indications started a few months ago. When trying to turn the wipers on to the intermittent position, nothing would happen. Turning the switch to low or hi then back to intermittent would allow the intermittent to work OK. Issue seemed to be occasional (trying not to overuse intermittent).
A couple days ago, daughter takes off to meet pals, comes back saying wipers died completely, won't move, won't park, no response to any switch position. I checked it out and researched some of the relevant threads here. My findings thus far:
Front wiper int/lo/hi positions do not work
Front washer pump works fine
Rear wiper switch positions all work fine
High beam, low beam and flash-to-pass work fine
Left and right turn signals work fine.
I am figuring the MFS is probably not the problem.
Looking in the owners manual it seems that fuse #8 protects front and rear wash pump relays and front wiper motor relay. Since front and rear wash pumps actuate fine, I figure fuse #8 is OK and the pump relays (#4 & #6) are OK.
Fuse #20 protects the GEM and Memory Module. Since I am not experiencing any issues with dash lights, idiot lights, chimes, locks or other GEM associated items, I am guessing fuse #20 is OK and the GEM is OK.
This leads me to relays 54 (run/park) and 59 (hi/lo). Since the wipers will not run or park, I am guessing that the run/park relay is having an issue. I presume that the intermittent function is cotrolled by the GEM based on the Intermittent switch position
Am I missing anything or overlooking some complexity that should change my logic? Is it likely for the MFS to fail only the front wiper portion of the controls?
Ford - Explorer :: A/C Won't Cool After 30 Miles?
When I get up in the mornings and make my 10 mile commute to work my AC is icebox cold, I could hang meat in there. But after a long long day (about 9 - 10 hours) when I get back in my 96 Explorer to head out -- driving about 30 miles -- the AC never gets cool. It feels like it's just a vent siphoning in the hot air from the outside. This has been going on for about the past week. What could be causing this issue?
View 13 RepliesGolf/GTI VI :: 2010 - Water Pump Failure At 13,600 Miles?
2010 GTI. Surely this must be just one heck of a freak occurance - never heard of a water pump failing so soon (actually, I've never had one fail personally). Anyway, I now get to experience the joys of the VW parts delivery system.
View 17 RepliesCamry 2012+ :: 2015 - Transmission Failure Only At 574 Miles
My brand new 2015 Camry LE suffered total transmission failure only at 574 miles. [URL] ..... , uploaded youtube video. It failed due to coolant leaking into transmission housing and contaminated trans fluid.
View 14 RepliesPassat (B6) :: 2006 Died - Engine Failure At 12k Miles?
I have had my 2006 B6 for 4 months now and it has been running perfect, and I have been loving it. I brought the car to the dealer to get PA state inspection and have the wiper recall taken care of. I then get a call from the dealer telling me the oil light came on during the test drive and they are looking into the cause.
Later that day the dealer calls me telling me that we have serious problems and that I will probably need a new engine, I was like WHAT!!! Now before I brought the car in it was running perfect I had no previous problems or anything. After talking to the dealer again, he said they found gas in the oil and a "ton" of metal parts in the oil filter compartment. They are now sending the VW Engineer and a local Rep to figure out what to do.
Engine failure at 12k miles? It seems weird and a major lemon if you ask me. I'm not sure what they're going to do at this point, but all I know is I drive 40k miles a year and need a care that can last, I am not paying $580 a month to drive a car with a replaced engine at 12k miles. This is very frustrating, I hope they either replace the car or pay off the remainder of the loan.
Ford - Explorer :: 2004 SOHC - Timing Chain Failure
Replacing the timing chains and tensioners on an SOHC Explorer, only to have the tensioners fail again after only a few thousand miles? I'm a pretty experienced back yard mechanic and have rebuilt several engines over the years with great results, but this one has me stumped. The only part of the instructions I did not do was to remove the valve springs, but everything was lined up as it should have been using the special tools required to set the timing. I really like the truck, but don't know if it's worth fixing if this is just going to happen again.
View 3 RepliesTouareg :: Electrical Failure While Driving On Freeways About 70-75 Miles An Hour
I bought my Treg a on 1/16/05 only 46 days ago and have had now twice electrical failures both at while driving on freeways about 70-75 miles an hour. Every light on my treg went off for a few seconds including the MFI Radio and even the headlights. when everything went back on the xenons did their little wink. Possible 04 problem? Going to take it to my dealership on monday.
View 3 RepliesLexus ES 2007-12 :: ES350 / 60K Miles - Engine Head Failure
Have a lexus es350 (2007). While driving to work, engine light came on. after reaching work tighted the gas cap and while driving back , light was not on for sometime and then came on. Didnt drive to work car after that. Next day evening drove to dealership and they diagnosed as waterpump replacement requird. Overheating indicator never went high while we were driving. After water pump replacement, dealer said engine wont start and compression test failed. Need new heads and gasket at a cost of $7184 additional. Dealer and I spoke to customer service case manager and they refused with such a high expense. Tried to tell them that we have owned 4 Toyota/Lexus cars , have been loytal Toyota customers (last one bought in 2012) etc. , but, nothing seems to make a difference to them. The decision was already made before they talked to me. Car has only 60K miles. Last maintenance was done at 56K (oil change, fluid levels etc). I owned 3 Toyotas for 100K before I sold and 2 Hondas. None had such a high expense at 60K.
View 7 Replies