Ford - Explorer :: 2005 - Intermittent Check Charging System Message
Check Charging System message, battery-shaped idiot light, and audible beep has happened a few times over the past month or so. Yesterday it happened while my wife was driving so I had to bring it to the dealer, not to mention I drove it last night and there was constant beeping for about a minute which was pretty annoying.
But first I had the battery checked, which turned out to be OK. Also we got a new alternator 5 months ago, installed by the dealer.
Today they said they "updated the computer" whatever that means, and otherwise couldn't find anything wrong. $99.85 plus tax.
Needless to say I'm not confident that "updating the computer" has fixed it. What are the odds we get the warning again in a couple of weeks? Short of disconnecting the sensor, is there anything that can be done?
Ford - Explorer :: 2005 - Check Charging System Message When AC Turned On
Three weeks ago I replaced my battery and serpentine belt as general maintenance before heading out on a prolonged trip. The next day I started receiving 'check charging system' whenever I turned the a/c on and the truck is at idle. Power steering becomes very hard to turn and engine feels like it is going to quit.
This is not a problem at highway speeds. Looking at the engine when the a/c is engaged, a slow down of the belt/pulley is obvious. The alternator has been removed and checked, battery checked good, and the belt is the right size/length. What could be causing this? Again it started behaving like this after a belt and battery change. There is no issue if the a/c is off...
Ford - Mountaineer :: 2003 - Died Now Won't Start - Check Charging System Failure Warning Light On?
I have a 2003 mercury mountaineer 4.6L AWD. The other day it died at the grocery store and now won't start. All it has is the check charging system warning light on. Changed Alternator, battery and starter already and still nothing. It does start sometimes but i need to give it gas to keep it running.
View 7 RepliesFord - Explorer :: 2003 - No Charging System?
2003 explorer 4.0.. I have no charging from the alternator at all. battery dash light on all the time. exciter wire from PCM to alternator, green/white is right around 11.6-11.9v when running. when key on engine off its 0.the other wire for the regulator is battery voltage all the time. voltage drop from large post to + battery terminal is 0.4v. I tried 2 different new alternators so far from napa and same issue. belt is not slipping and tension is good. this vehicle sat for about 6 months and has been on the road for only a week or 2. maybe 100 miles so far until this. I might try a ford alternator, what to do.
View 2 RepliesPontiac - Grandprix :: 2004 - Charging System Failure / ABS And Traction Light Come On Frequently
Charging system failure light comes on about once a week, then the ABS & traction control lights are coming on and I can feel a vibration from the pedal and a humming noise! Replaced the sensors which fixed it or so I thought. It started doing it again. What is causing this & is this a common problem?
View 2 RepliesFord - Explorer :: 2004 - Getting Messages - Check Charging System / Low Tire Pressure?
I have a 2004 Explorer with 167,000 miles that has begun to display erractic messages such as, check charging system, low tire pressure, AvTrac off and about everything there is. Reset and everything looks good then messages start again. I am thinking computer module.
View 3 RepliesFord - Explorer :: 2008 XLT - Power Steering - Check Charging System Warning Comes On The Dash
My 2008 2wd 4.0l XLT is having a strange power steering issue. When I start the truck and back out of my driveway it feels like I have no power steering. Within about ten seconds of putting the truck in reverse the "check charging system" warning comes on the dash. As long as it is on I have no power steering. That warning stays on for about 15-20 seconds and then goes away. As soon as it goes away power steering is restored.
I have checked my battery and it is good, it is also pretty new. The power steering fluid level is good. Based on another thread that seemed to have a similar issue I replaced the serpentine belt, the idler pulley and the belt tensioner. No changes at all to the issue. My next step is to replace the power steering pump....
Avalon 2005-12 :: Check Charging System Message / Car Being In Accessory Mode
After clearing my 2013 Avalon today, which took about 2 hours to complete, I attempted to start the car and it would/will not turn over. I waited a bit and attempted again, same result. The battery appears to be fine, all the lights and the console are working, power windows, etc. The heads up display had this message: "Check Charging System" I have check the owners manual and read something about the car being in Accessory mode. Another item referred to the fuel system being disable. None of these examples make sense.
View 4 RepliesFord 6.0L Power Stroke Diesel :: 2005 - Fuel System Codes / Glow Plug Circuit Failure
So i just finished putting in new high pressure oil rail cup seals in and a new #2 injector. Truck was running great for about 5 miles and then just shut off. When I had it towed home I plugged in the super chips tuner "no tunes installed" and I have a p0460, p0463, p2290, p2291. I also have a #7 glow plug circuit failure Ive been a little neglectful in getting done.
View 6 RepliesFord - Explorer :: 2005 - Emission System Won't Working - HC At 102 Ppm?
I have a 2005 Explorer Sport Trac 4.0L V6 that fails emissions for high HC at idle. I have already replaced upstrem and downstream 02 sensors, air filter, gas cap, EGR module and PCV valve. OBD II reader shows no DTC's and green light shows indicating all emission systems are working. The initial test showed HC at 102 ppm, for which the Calif. standard is<100ppm. Also seems to have a smell of unburnt fuel. After all the repairs above HC actually went UP to 147.
View 7 RepliesFord - Explorer :: 2005 - Turning Off Tire Pressure Monitoring System
Just replaced the tires and wheels on my 2005 EB Explorer. Purchased a set of Better aluminum wheels and tires on Craigslist. Problem is old ones had TPMS and new ones don't. I will put the sensors on the new wheels when the tires wear out, but don't feel like the expense until I need new tires. Is there an easy way to turn the system off so I don't get the message every time I start the vehicle?
View 8 RepliesFord - Explorer :: Alternator Not Charging
Picked up a 2000 Explorer XLS for my 16 year old son to drive. It looks and runs great but it needed a new alternator. Long story short, 3 shiny new alternators from AutoZone later, it still acts like it needs a new one. If I check voltage at the alternator, while running, it's never over 12.5V. As I turn on accessories, the voltage drops down to 11.7 and doesn't come back up. When I turn it off, the battery slowly creeps back to 12.5V. The 30 amp fuse is good as is the 175amp fusible link. Shouldn't I have 14+ volts out of a brand alternator?
View 9 RepliesFord - Explorer :: 1997 - Alternator Charging Intermittent?
1997 Explorer belonging to a friend who will show up complaining that his battery is dying. Of course, the problem is intermittent.
So far, tried 2 new alternators, (rebuilds), 3 batteries and several diagnostic sessions which have been inconclusive. What I do know is that when the charging system is not working, I still have full battery voltage on the Y/W and LG/R wires on the small wire plug at the alternator. The path from the alternator output through the megafuse to battery + does seem to be intact. Measures full battery voltage and even tried a test by using a battery booster cable to connect the alternator output directly to battery + when the system was not charging.
No change with this test. Visual inspection of the engine to firewall ground strap and the battery - to rad cradle ground wire seem to be OK. Have not had the opportunity to try the jumper cable trick to verify the alternator case to battery - circuit, (darn intermittent!). There did seem to be something intermittent related to a wiggle test in and around the power distribution fuseblock, but once again, this was inconclusive. I also was able to make the charging system fail, (once) by turning on the headlights and blower motor.Any specific failures that may cause this? Not much left to change or check!
Ford Excursion :: No Power From Charging System
I have a 2001 ford excursion with the v10 . Yesterday it just died from no power from the charging system. I cleaned all my connection from the battery to the ground straps and my question is in the back of the alternator where the large wire connections with that disconnected. Should I not see current coming out of the bolt on the alternator.
I connected a test light to the body and the test side to the large electrical bolt on the back of the alternator and It would not light ? is the voltage regulator inside the alternator . I also found and a repair a worn fuse link that connected at the starter selonoid and i did make sure the wire from the back of the alternator to the starter selonoid has continuity.
Ford F-150 (2004-2008) :: Check Charging System Keeps Coming On?
New Interstate battery, new alternator (x2, 1st was Napa (DOA), 2nd Motor Craft) and 1 new Napa idler wheel. The battery test at 12.5 and when the truck idles it shoot to 15.14. It holds a charge fine, but the check charging system keeps popping up which concerns me, not only because its annoying. Also why such a spike when started...?
View 1 RepliesFord F-150 (2009-2014) :: 2011 - After Hitting Pothole CEL Came On - Charging System?
I drive a 2011 f-150 5.0. I hit a crater-sized pothole out on a dirt road and the check battery light came on. The truck hesitates slightly when i put on the gas. I already check the voltage on the battery 13v off 15 on and I took off the Postive cable and the truck still ran. What could be causing the issue.
View 1 RepliesPrius (2010-12) :: Hybrid System Failure After Cooling System Repair?
Two weeks ago a large, industrial truck dropped a piece of bent steel pipe on the interstate in front of my 2010, 50k miles, Prius and (sadly) I was forced to hit or swerve into rush hour traffic and cause an accident. It tore up a good part of the cooling system and did some body damage. Of course I didn't know this at the time, but it began to overheat, so I pulled off the freeway and had it towed to a body shop. After about ten days, I got my Prius back.
View 13 RepliesFord 7.3L Power Stroke (1999-2003) :: Charging System Light Goes On And Off Randomly
My charging system light in my 2000 F250 keeps coming on and off and very random times. Its been happening for quite sometime now and I finally joined FTE so I figured I would ask everyone what could be causing this. Ive disconnected all the electrical plugs from the alternator and made sure they were in there well.
It all started when I was cleaning my engine not too long after getting the alternator replaced. I don't remember getting any water anywhere near the alternator and cant understand anything causing this other than the connectors. It will cut on and then cut right off sometimes and then sometimes it comes on and stays on...
Ford F-150 (2004-2008) :: V8 - Check Charging System Message Appear 30 Seconds After Cranking The Engine?
I have an '04 F-150 4 x 4 Supercrew Lariat w/ the 5.4 V-8. It has 105,832 miles on it. No issues until a week ago. Battery light and "Check Charging System" message appear 30 seconds after cranking the engine. I have replaced the battery (Ford Motorcraft), belt and alternator (Motorcraft 130 Amp). Still getting battery light and error message. I've read some post that indicate it could be a short in the fuse box.
View 2 Replies