Ford 7.3L Power Stroke (1999-2003) :: 2001 - AC Blows Only Through Defrost Vents
My 01 ac has worked just fine up until today. I got in this morning to leave the house and the air was only coming out of the defrost vents. I tried playing with the controls to get it to switch but couldn't. I assume its a vacuum leak, but where do I need to start looking?
View 14 RepliesFord 7.3L Power Stroke (1999-2003) :: Floor And Defrost Work But Dash Vents Not Working
The floor and defrost vents work. It just stays on defrost when you try to use the dash vents. The actuator seems to be working fine. I can watch the arm move through all the motions. and I cant find ANY vacuum leaks. Yes I looked at the hubs and under the hood. May be moving to alaska and kind of need my heater to work properly. . . .
View 5 RepliesFord 7.3L Power Stroke (1999-2003) :: AC Not Blowing Through Front Vents
All vacuum lines are good, pump works, Canister isn't leaking, 4x4 activates and I can feel it, so Can't be vacuum leak. Replaced esof solenoid 6 months ago last time this happened, but this issue seems to be different. Watch this vid I made showing the issue.. after viewing video, do yall' agree I isolated the issue? If that one tug makes the air go through the front vents, that means everything else in the A/C mode selection works..
YouTube.....
Ford 7.3L Power Stroke (1999-2003) :: Dash Vents Take A Few Seconds To Begin Blowing
2002 - 7.3 lariat, my a/c stays on max because of the recirculating effect. When I get in the next morning during summer of course, my dash vents take a few seconds to begin, default defrost till that time passes. Sure I know about leaks and redone all that to make my vacuum hubs work correctly. It didn't begin till later not right after that overhaul.
View 11 RepliesFord F-150 - 1997-2003 :: 1998 - A/C Blowing Cold Via Floor Or Defrost Vents?
1998 F150 XLT 4.6l automatic,,,
Drove the truck on a trip the other day, about 650 miles with a loaded 5x8 trailer in tow. A/C started acting weird. When the truck was on level ground, or going down hill, the A/C was fine. Cold air coming out the correct dash vents. As soon as I started up hill, or put the truck under strain of acceleration, the A/C would stop blowing out the dash vents and would start coming out the floor or defrost vents, or just not come out anywhere.
When I turned the A/C off and just used the vent setting, it would do the same thing with the fresh air. I guessing this has something to do with my vacuum lines, somewhere. What I should be looking for and where?
Ford Super Duty (1999-2016) :: No Air Blowing Out Of Vents Or Defrost For AC Or Heat
I have a 2008 F350 and there is nothing blowing out of the vents or defrost for AC or heat. It doesn't matter what fan speed is set. Would this indicate a blower motor? Where exactly is it located and how to change?
View 8 RepliesFord Super Duty (1999-2016) :: AC Quits Blowing Out Of Forward Vents And Goes Into Defrost When Activate 4WD
02 F250 with 7.3. When I activate the 4WD, my light comes on, the A/C quits blowing out of the forward vents and goes into defrost and no 4WD. If I sit and wait a bit, the air again blows out the front vents and the 4WD engages. I figure I have a vacuum leak somewhere in the 4WD system. Is there a common place for this to happen or do I need to trace the whole system down? Also my manual hubs has never been turned and of course they won't. I know better than use a wrench so is there a easy way to free them up or just go ahead and disassemble and clean?
View 3 RepliesFord Excursion :: 2002 - A/C Blowing Air From Vents To Defrost?
My 02 V-10 Ex seems to be blowing Air from the front vents up to the Defrost unless it go through a series of events-- Hit Auto then forward Air then the fan has to be a 4 only. It will blow forward vents then go back and forth from theirr to the defrost. Also the Temp seems to be much hotter then it should.
Took a interstate trip this weekend though and it seems to blow much colder and do a little bit better staying in the front vents however still goes back and forth. Im in FL and its HOT!!!! The only thing I know is that its a vacuum system.. and that again its HOT in the truck as a daily driver.
Ford 6.7L Power Stroke Diesel :: Windshield Defrost And Floor Vents Won't Work
No matter what I do with the settings for my heater in my lariat air only blows out of the dash vents. Defrost and floor vents don't work it still blows hot air out of the dash vents. I'm not sure what the deal is maybe the vacuum system? I did a search and all I could find was people having trouble with air ONLY blowing out of the defroster and my case is just the opposite.
View 8 RepliesFord A/C :: 1997 F150 V6 - Cold Blowing Only Through Defrost Vents?
My A/C is blowing cold but only thru the defrost vents. First it was blowing normally from the dash but during acceleration or under load, the a/c would randomly blow from any vent, from the floor, dash, defrost. Now that stopped and it only blows from the defrost vents above the dash-board.
1997 F-150 XLT, 4.2 Liter, V6, manual transmission.
Ford 7.3L Power Stroke (1999-2003) :: A/C Keeps Switching To Defrost On Its Own?
I have a 2000 450, and the a/c keeps switching to defrost by itself. Any way to fix??
View 14 RepliesFord 6.0L Power Stroke Diesel :: AC Blowing Through The Defrost When Switch To 4x4
Replaced the vacuum solenoid.. Thought that would fix the ac blowing threw the defrost when I switch to 4x4, but didn't fix the issue, 4x4 works great. There is another little diaphragm that has a vacuum line to it that opens and closes, could this be causing the air to go defrost? I'm going to go to a buddies house and test for leaks this Saturday, just trying to get a jump on it...
View 1 RepliesFord 7.3L Power Stroke (1999-2003) :: A/C Blows Through Defrost Vent Only
My 99' started o blow air only through the defrost vent today, and won't go through any of the other vents. I think this happens when your vacuum pump goes bad or there is a leak, correct? If so, how can I test these to figure out the problem.
View 2 RepliesFord 6.0L Power Stroke Diesel :: 2006 - Heater Air Blowing Only On Defrost
Have 06 super duty . Heater air blowing only on defrost. 4wheel drive. Is this a vacuum problem or some type of sensor or control problem?
View 2 RepliesFord 7.3L Power Stroke (1999-2003) :: 2001 - When 4X4 Disengaged AC Went To Defrost Then AC Eventually Came Back
Proud new owner of a 2001 7.3....today. The previous owner installed Warn standard hubs. I assume they work same as OEM with the exception that I have to get out and lock them, right? Also, when I test drove it, and after locking them, I engaged to 4x4 button and the 4x4 engaged and worked. However, when I disengaged my AC went to defrost just like my old 7.3. The AC eventually came back. Is this normal? I think it also went to defrost when I engaged. The AC does come back after a couple minutes after disengaging.
View 14 RepliesFord Super Duty (1999-2016) :: 2003 Excursion - Dash Vents Not Working - Just Defrost
Air is only blowing through the defrost vents. No matter what I do - try to turn vents, A/C, heat, fresh air, recirculating, etc. Assume it's a switch or fuse issue somewhere. How to fix it?
View 11 RepliesFord 7.3L Power Stroke (1999-2003) :: A/C Goes To Defrost At First When Cranking But Then Runs Fine After A Couple Seconds
I have Warn hubs that I have to lock in. All works good. A/C goes to defrost at first when cranking but then runs fine after a couple seconds. So, I was thinking that maybe my pump is running all the time. Who knows. I'm sure all my vacuum lines are dry rotted. What exactly is the need for it exactly and what's the best way to cap? Hoping to do it at the unit itself if possible.
View 6 RepliesFord 7.3L Power Stroke (1999-2003) :: A/C Won't Blow Through Front Vents?
After some diag I got the A/C to blow out the front vents. There are million threads on this issue half of them are never figured out. This is the second time I have come across this problem so will make this really informative for those who have this problem. If you A/C blows to defrost, yes most of the time its going to be a vacuum leak issue.
Step 1) turnkey on engine off, stand by passenger fender and listen.. can you hear the pump running? If it is your pump isn’t dead.
Step 2) does the pump run for 30 seconds then shut off? You may not have a vacuum leak. If keep’s running for ever you have a leak. Inspect all lines, especially those going down to the hubs for cracks. Also inspect vacuum lines under passenger glovebox.
Step 3) can’t find a leak? Disconnect the line going to the ESOF solenoid and plug it, if you pump stops running then your ESOF solenoid has an internal leak. That was my problem 6 months ago, replaced ESOF, A/C blows normally.
Try This Second! So my AC isn't blowing through my front vents again.... (more diag)
AC not blowing through vents and can’t find a vacuum leak? Take off glove box door, turn AC control switch to floor/defrost/front vents, watch the metal arm connected to the side of the big black box move up and down into various positions. I noticed on mine the arm will go down in positions (floor or defrost) But it will not move up! Which needs to happen to switch to front vents. If I push the rod up by hand manually, the ac will blow through front vents, and stay blowing through front vents even after I let go. PIC of metal arm thing connected to diaphragm, which changes air flow by moving flap inside the big black box
I am guessing the Diaphragm is the issue? The truck will continue to blow from the front vents even when the truck is shut off and restarted, it will stop when I switch the ac to a different position, it will not return back to front vents.
Ford 7.3L Power Stroke (1999-2003) :: AC On / Vents Start Pushing Hot Air When Under A Load
I have an 03 F250 7.3litre. I have noticed the last few times driving while hauling that my vents start pushing hot air when under a load (example: driving up a long, steep pull) even if I have the AC on. It's starting make me a lot hot under the collar (pun intended) .....
View 14 Replies