Ford Super Duty (1999-2016) :: 2006 F250 - While Shifting Into 4x4 A/C Heat Blows From Defrost Vents?
2006 F250 with the dash controlled 4x4. I typically keep the front hubs locked on this truck. I have recently noticed that when shifting into 4x4 that the a/c or heat will switch from blowing out of the vents to blowing out of the defrosters. Any clues how to fix this?
View 1 RepliesFord Super Duty (1999-2016) :: AC Quits Blowing Out Of Forward Vents And Goes Into Defrost When Activate 4WD
02 F250 with 7.3. When I activate the 4WD, my light comes on, the A/C quits blowing out of the forward vents and goes into defrost and no 4WD. If I sit and wait a bit, the air again blows out the front vents and the 4WD engages. I figure I have a vacuum leak somewhere in the 4WD system. Is there a common place for this to happen or do I need to trace the whole system down? Also my manual hubs has never been turned and of course they won't. I know better than use a wrench so is there a easy way to free them up or just go ahead and disassemble and clean?
View 3 RepliesFord Super Duty (1999-2016) :: 2012 - No Air Getting To The Defrost Vents
I have a 2012 super duty with a 6.2 in it. I bought it last winter and noticed no air getting to the defrost vents. Now in the heat, sometimes when I turn the air on, all I get is super hot air like the heater. Sometimes playing a bit will work but not always.
View 7 RepliesFord Super Duty (1999-2016) :: AC And Heat Only Blows Out The Defrost
I bought a used 99 f250 v10, i went to turn on the a/c today, and it only blows where the defrost is toward the window. it gets cold after awhile, but nothing out the vents, the heat either.
View 9 RepliesFord Super Duty (1999-2016) :: 2001 - Vents Stuck On Defrost
My 01 SD won't blow air anywhere but through the defrost vents.
View 9 RepliesFord Super Duty (1999-2016) :: A/C Blowing Out Defrost Only
I have followed the vacuum lines but don't see any holes or cracked lines. I dont have the ESOF hubs so that is ruled out. Also checked the connector on the vacuum pump to make sure it still had power. Everybody says that when I turn the key to acc I should hear the vacuum pump running. I don't or do I feel it moving. Am I on the right track? I don't want to replace if not bad. Do all vacuum pumps run on keyed power? I honestly don't remember hearing it run before but that doesn't mean anything with my memory.
View 8 RepliesFord Super Duty (1999-2016) :: Heater / Defrost Circuit Does Not Heat Up
My 2006 F-250 SD with 6.0 diesel has some sort of cut-out for the heater circuit, and possibly for the A/C as well. This truck was probably a fleet vehicle for the Houston Port Authority. Didn't really notice this peculiarity until it got really cold outside. If I start the truck up and let it idle for 10-15 minutes the water and transmission temperature get up to the normal operating ranges but the heater/defrost circuit does not heat up. Cannot defrost the windshield.
If I drive to the end of my driveway, about 600 feet, the heater/defroster starts putting out good heat. When driving, if I have to stop at a stoplight, or any other pause, with the truck still in gear, the heater output starts to cool down. I suspect that this feature was incorporated in the circuitry at the factory to prevent the driver from sitting still to keep warm. The truck MUST BE MOVING to allow heat or defrost to operate. The blower motor operates and it doesn't matter if the truck is in gear or not.
Ford Super Duty (1999-2016) :: 2006 - All Climate Functions Come Out Of Defrost Vents
It's a 2006 F250 Super Duty, 4WD AT, no auto hubs, 5.4L. All climate functions come out through the defrost vents. That mean when I'm using A/C it works, but comes out the defrost vents, or if it's a cold day and I want to use the heater it comes out the defrost vents. (So does defrost! LOL) Once or twice things went back to normal, but then, once when I had some cargo on the passenger's floor, I heard a hissing sound and it all went back to the defrost vents. Been there for a while now. Dealer wants to charge an arm and leg to look at it and then all arms and legs to fix it, and wouldn't you know it's not covered on my service plan!? Remember, these 4WD front hubs are not auto. I get the idea that to do anything under the dash means I have to disassemble the entire truck down to every last bolt.
View 10 RepliesFord Super Duty (1999-2016) :: Air Blowing Through Defrost Not Vent?
My husband and I have 3 Excursions, V10, 6.0, 7.3 and I have a 6.0 250 crewcab. 3 of the 4 now blow air or heat from just the defroster unless your going at a slow speed.
View 2 RepliesFord Super Duty (1999-2016) :: F250 - AC Blowing Through Defrost
1999 F250 7.3 4x4 switch on dash with manual hubs. No visual vacuum hoses cracked.
Not sure what this component is but when I wiggle the wire at the orange cap a small motor kicks on.
Ford Super Duty (1999-2016) :: 2003 Excursion - Dash Vents Not Working - Just Defrost
Air is only blowing through the defrost vents. No matter what I do - try to turn vents, A/C, heat, fresh air, recirculating, etc. Assume it's a switch or fuse issue somewhere. How to fix it?
View 11 RepliesFord Super Duty (1999-2016) :: 2000 - A/C Blowing Through Defrost Vent?
I have a 2000 f250 4x4 7.3 diesel. I had problems with my a/c and controls for sometime now. my a/c was blowing threw the defrost vent. I was told my blend door was bad. I bought a new blend door installed it,still doing the same thing. I was told to check my vacuum lines. I check them, they were bad. I replace my vacuum lines and my vac pump as well. that fixed my problem blowing threw the defrost vent. I can control my air flow from floor,dash vents and defrost vent. the problem I have, I not able to control my temperature when I turn my center from red to blue. It blows hot air and the air that is coming out of the vents isn't very strong at all.
View 1 RepliesFord Super Duty (1999-2016) :: 2005 F250 - A/C Blowing Out Of Defrost
The A/C on my 05 F250 6.0 recently would not blow out through the vents. So, I replaced the vacuum pump and the reservoir tank. Once I replaced them the A/C still starts through the defrost vents but, after a minute or so starts to blow through the vents. I also noticed that the vacuum pump never stops running. Is this normal or is there something else I need to look for?
View 5 RepliesFord Super Duty (1999-2016) :: 2001 F350 - AC / Heat Stuck In Defrost Mode
Last Oct. I noticed that my ac/heater started to intermittently stop blowing from AC fresh air/recir/vent/etc. mode and stick to defrost only. Do I have a bad switch and or a vacuum issue here? It's a '01 F350 CC 7.3 .....
View 6 RepliesFord Super Duty (1999-2016) :: 2005 F250 Blowing AC Through Defrost Only All The Time
My 2005 F-250 6.0 liter Diesel FX4 Lariat is blowing AC through defrost only all the time. I have manual locking hubs and when I engage 4x4 it works perfectly through the ESOF switch. So I am assuming the vacuum pump and lines to the hubs are in good working order but there is possibly a cracked line or fuse blown? I've only had the truck for 2 days and it just happened after purchase. I'm a little unfamiliar with checking vacuum but have done reading and I believe I can do it. I am going to get a manual hand pump and pump to 20lbs and loss shouldn't exceed 1lb per minute. I just need to know which direction to look. Everyone else had their 4x4 not working and I seem to be the only one posting that has ESOF 4x4 capability when the defrost only issue is on.
View 11 RepliesFord Super Duty (1999-2016) :: 2006 F250 - Climate Control / AC Vents To Defrost And Blow Normal Air Through
I have a 2006 F-250 Super Cab with climate control. The last three years when the temp exceeds about 85 degrees outside it acts up. It will switch from the AC vents to defrost and blow normal air through, not ac cold. Then it will switch back, when doing so I can hear the internal deflector shudder. It will do this every few minutes. It is extremely annoying. All other times of the year it works fine. My local dealer had the truck last year, but could not find anything wrong. I have used the search and also Googled and while I find similar problems nothing exactly the same.
View 12 RepliesFord Super Duty (1999-2016) :: 2006 F350 - AC Switches To Defrost Then Takes 2 Min To Return To Vents When Shift Into 4X4
2006 f350 DRW King Ranch diesel with 94,000 miles on it. When I shift in to 4x4 the AC switches to defrost and then takes 2 min to return to the vents. I imagine this is a vacuum leak issue. Where to start hunting? I pulled the dash for another install and all lines were connected. I will say the vacuum pump stays on longer than normal when the ignition is first activated.
View 1 RepliesFord Super Duty (1999-2016) :: Water In Heat / AC Vents After Rain?
Don't get much rain here in SoCal except during the winter. After the last rain I noticed that there was water in the heating/ac vent system - or at least that's where I think it was.
When I made a right hand turn some water slopped out onto my foot and gave me quite a shock for a second till I figured out what had happened.
I suspect that there must be some kind of drain tube for the vent system that's become clogged, but before I start crawling around under the truck and dash I figured I would ask here first. Any useful tip on clearing the clog?
Ford Super Duty (1999-2016) :: 2005 - Vacuum Pump Out - A/C Being Reverted To Blowing Out The Defrost?
Haven't been on here for a while. My f250 AC vacuum pump is out. This means the AC being reverted to blowing out the defrost. I have found the defrost/vent vacuum solenoid and zip-tied it open for a vents-only experience. I just realized, without the vacuum pump, there is really no way of determining if it is on recirculate or fresh air. I wish for the recirculate so I don't get someone else's or my own exhaust in the cab. Does the system stay on recirculate without vacuum power? if not what actuator must I zip-tie next?
View 1 Replies