Ford 6.0L Power Stroke Diesel :: Excessive Blueish Smoke Coming From Exhaust At Idle Mostly While Warming Up
Lately I have noticed a lot of blueish smoke coming from my exhaust at idle mostly while warming in the morning though it would do it if the truck idled for a few minutes. I took it to the dealer because I have fords ESP but the tech couldn't get the truck to smoke and wasn't getting any codes so he sent it back with a clean bill of health. After getting it back I noticed it smoking again so I picked up the egr valve kit pulled the valve and cleaned it as best I could and replaced the seals, that was last night. This morning it was blowing more smoke than it has before and has continued all day whether cold or warm. I just changed the oil last week and it's still full so it isn't burning any. Head gaskets were done along with studs last month, egr is obviously intact, cat is gone. I'm really at a loss for this, It's an 07 f350 scsb 6.0...
View 6 RepliesFord 7.3L Power Stroke (1999-2003) :: Truck Act Like Going To Start And Black Smoke Coming Out From The Exhaust
I have a 2003 Superduty with 193k miles that is bone stock. I sold the truck to a friend and when he decided to not pay the remaining balance on the truck, I took back ownership. The truck was having heating issues and it set at a mechanic shop for nearly 2 years waiting for a diagnosis on the heating issue. Fast forward to the present and I now have the truck at my home. Heating issue was the radiator but this is no longer a concern. When I went to pick up the truck from the mechanic, the truck started fine. Every other day for the last 4-5 weeks I would start the truck with no problems.
I get the truck tagged and start driving it on a daily basis. I've put several hundred miles on it but the more I drive it, the less it wants to start. Now it's to a point where it only cranks but won't start. I can take a gas rag and hold it in the intake and eventually it will start. Once it's running, it runs great and has no issues starting. But once it sets for 3-4 hours, it won't start without some sort of assistance.
While trying to find the issue, I've found and repaired 2 fuel leaks and in the process I replaced fuel filter, air filter, replaced glow plug relay, replaced batteries, replaced CPS. Fuel pump is working fine. I've tried the ICP test and doesn't make a difference.
The glow plug light or WTS light works so don't think its the GP. The CES light was on. Had it scanned and it was the air bag sensor so no support from the CES.
While I was working on it yesterday and after cranking on it for 5-10 minutes, it would act like it was going to start and black smoke would be coming out from the exhaust. I let it set to cool the starter it fired up like it had no issues.
Ford 7.3L Power Stroke (1999-2003) :: F550 - Fuel In Exhaust / Gray Smoke Started Coming Out
Having trouble with motor, driving home one day heard a noise under the hood. Then a lot of grey smoke started coming out of exhaust. Got the truck hauled home notice fuel was coming out at the number 7 cylinder at exhaust port. Thought it might be the injector just put rebuilt ones in, thought I might have received a bad one. I switch the number 7 injector with the number 3 injector. Did not make a difference still have fuel leaking out of exhaust manifold at the number 7 cylinder and a lot of grey smoke coming out of exhaust. Not sure where to start looking next? Could it be the injector cup is the problem?
View 14 RepliesFord 7.3L Power Stroke (1999-2003) :: 2001 - White Exhaust Smoke When Letting Off Throttle
2001 SD F-250 SuperCrew 4WD, 7.3L (completely stock), 114K miles, automatic
We took Dad's SD for a 600-mile trip yesterday and today. The oil had 2000 miles on it, and we checked it before we left. The oil level was half-way down the hatch-mark, so we had added a little over a quart of oil to top it off, and I think that we may have added a little too much. Last night, when we got to the hotel and got out of the truck while it idled, a lot of white smoke that smelled like burning oil (like when you spill oil on an exhaust manifold) was fogging out of the exhaust.
It did this for a minute or two, then cleared up. All day today, on the way home (300 miles), about every time that I let off of the throttle either going down the interstate or stopping at a red light or stop sign, white smoke would pour out of the exhaust briefly, then stop when accelerating or in the throttle going down the road. What is causing this? Would too much oil (a little over a quart too full) make it smoke like this? The truck runs strong, starts and idles good, and no 'check engine' lights came on the dash.
Ford F-150 - 1997-2003 :: Excessive White Smoke Coming From Exhaust And Rough Idle
I'm losing coolant have, excessive white smoke coming from the exhaust, and rough idle. Doesn't over heat or even try to overheat. The oil fill cap looks brownish white. It drives fine other than extremely rough idle. I know how to check a blown head gasket with the combustion gas test.
From what I've read blown head gaskets on 4.6 fords are fairly uncommon but a blown intake gasket is fairly common. How can I tell the difference?
Ford 7.3L Power Stroke (1999-2003) :: 2001 F450 - SES Light Came On Followed By Loss Of Power Under Load And White Smoke From Exhaust
I have a 2001 F450 7.3 chassis cab with just over 100k. I have a new problem... So far on two different occasions the service engine came on followed by a loss of power under a load and white smoke from the exhaust. Took it to the shop the first time, they determined it to be a dirty air filter, which seemed odd since it just happened all of a sudden. They changed air & fuel filter, problem gone- for two weeks..
View 8 RepliesFord 7.3L Power Stroke (1999-2003) :: 2000 F350 - Whoosh Sound Coming From Exhaust When Warming Up
I hear a whoosh whoosh whoosh sound coming from the exhaust when its warming up in the morning. What is happening?
View 8 RepliesFord 7.3L Power Stroke (1999-2003) :: Excessive Blue Smoke Under Load?
Ok, I have owned my truck for almost a year and it has 151,000 miles. I have noticed on a few occasions puffs of blue smoke and especially at night in the headlights behind me I notice a lot of smoke when I'm getting into the throttle hard. Under normal driving conditions I don't usually see anything.
Today I noticed it when I was backing my camper(8000lbs) up a small hill onto the side of my garage. It was puffing blue pretty good going up the hill while it was under load.
I have no check engine light on, the truck seems to be running fine. My oil consumption is about 2 quarts every 3-4000 miles. I tried the blow by test with the oil cap but besides some smoke out the filler neck no problems... I don't know very much about diesels so for me to try and trouble shoot this is a problem.
Ford 6.0L Power Stroke Diesel :: 2005 E450 - Excessive Smoke Out Of Exhaust
I have an option to buy a e450 with a 6.0, 100k mi, with a utility body. I have the same thing but an 03 with a 7.3. this van has some known issues, biggest being it sat for a year and a half. it was parked due to excessive smoke out the exhaust. Ford shop diagnosed it as bad head gaskets, personally I am not believing it. There is no evidence of puking on the degas cap, and someone removed the band clamp from the down pipe and there is nothing but a little soot, so I don't really think a turbo seal either. The batteries were dead tonight so I am going to take a set of batteries down and see what happens. he is only asking 6000 as is. I am thinking probably egr cooler, egr valve or injector problem. If I buy it I am going to install a new oil cooler, blue spring, clean the turbo and delete the egr. Late 2004 engine btw.
View 14 RepliesFord 7.3L Power Stroke (1999-2003) :: 2001 - Oil Coming Out Of Exhaust
Recently I came across a guy parting out his F-250 with a 7.3 powerstroke. Said it had a blown engine, and didn't know what was wrong, but oil was coming out of the exhaust.
My question here is why that's happening. I don't have any experience with the powerstrokes, so I'd like to know what the culprit is before I even consider buying it.
Ford 7.3L Power Stroke (1999-2003) :: 2001 - No Power With Smoke Coming Out Tail Pipe
I would I have a 01 7.3 e350 with 111k miles. I drove the van a couple of days ago.it sat for 2 days and now it wont go past 30mph.the van shakes crazy and went when i hit the petal no power with smoke coming out the tail pipe sometimes. When I shut the van off and restart it to drive it,it sounds better. I changed the fuel filter with motorcraft and changed the oil. Here is the kicker. It ran good after I changed the fuel filter the whole day and now its 4th of july and I went to get some drinks and it happened again.
View 11 RepliesFord 7.3L Power Stroke (1999-2003) :: 2001 F350 - Low Grind Like Noise Coming From Right Front
Now down to the question in hand. I have a 2001 f350 4x4 with7.3 diesel...I have recently noticed a low grind like noise coming from the right front. I have troubled shot the issue and I am 100% sure it is the wheel hub assembly. Did I mention I am running 37x13.50 tires..and now it is the hubs...and they are the original hubs.. My question is every thing I look for shows ABS is on my truck... I look at the hub and don't see it.. so with the Dana 60 front does it have ABS or not? Also, should I go motorcraft, Timken or moog wheel hubs?
View 7 RepliesFord Aerostar :: 1996 - Excessive Amount Of Steam / Smoke Coming From Exhaust
I've owned this vehicle since new and never overheated or had any major mechanical issues. It just hit 130,000 miles and recently completed a 1500 mile uneventful road trip running great.
The other day I noticed an excessive amount of steam/smoke coming from the exhaust while sitting at a stop light after recently starting the vehicle. Once the van was up to temperature the exhaust steam/smoke cleared up.
I checked the radiator level and found it was about a qt low, and did not seem to have any exhaust bubbling or fumes in the radiator.
Then, I pulled the dipstick and the freshly changed oil looked a bit cloudy (I got really nervous), I really can't say its milky colored because I can still see though the oil and see the cross hatches on the stick. But it doesn't look like new oil.
The engine seems to be running fine, no loss of power or missing. Starts and idles fine.
Talked with a mechanic friend and he immediately said blown head gasket or intake manifold was allowing water from one of the four corners where the gasket seals the water jacket, into a cylinder.
Since that first episode of excessive steam/smoke it hasn't reproduced the problem to that degree. It does start to steam out the exhaust after about 5 minutes of starting cold, but seems to dissipate after the engine warms.
The amount of smoke / steam in that first episode, I couldn't see the car behind me in the mirror ... I looked like a mosquito fogger.
Ford 7.3L Power Stroke (1999-2003) :: Slight Miss At Idle - White And Blue Smoke From The Exhaust
Early 99 7.3. Runs ok has a slight miss at idle however every injector when unhooked makes a change. Has white and blue smoke From the exhaust. Has enough blow by to blow the oil cap off as your unscrewing it. My question is, I know engine restore is bad for these trucks but I can't afford to rebuild the engine. If I run the restore and then clean the IRP once the truck dies is this going to mess anything else up. Do you think it will by me a few months to save up for a rebuild
View 9 RepliesFord 6.0L Power Stroke Diesel :: 2007 F350 Backfires / Black Smoke From Exhaust
2007 F-350 6.0L, Wife phoned and said that the truck backfired a couple of times and there was black smoke from exhaust. When she stopped at idle there is now alot of white smoke but coolant level looks fine. She has about 200 km's to go before she is home pulling a 20 foot horse trailer with 1 horse.
View 14 RepliesFord 7.3L Power Stroke (1999-2003) :: F350 Blowing Black Smoke / Code P1211
I have a 2003 F250CC 7.3 with 200,000 miles on it. I just purchased this truck about a month ago. My question is it blows black smoke. A little at idle but mostly when you give it any pedal. I have replaced all of the injector o rings and that didn't make a difference. Then I had it tested and it failed a CCT test on #2 cylinder. I have an injector to put in it, but am curious to find out if 1 bad injector would be enough to make it smoke all the time. I keep getting P1211 ICP pressure above desired. I had a friend of mine who used to work at a ford garage take a look at it with his computer and he said that everything looks good other than the CCT test.
View 14 RepliesFord 7.3L Power Stroke (1999-2003) :: F350 Died - Cranks Great But No Smoke Or Fire
While driving my 99 F350 7.3 it died and I was lucky enough to coast home. No WTS light, no tach movement when cranking, no fuel pump, no CEL, Cranks great but no smoke or fire. New CPS & PCM still no lights or tach. Moved relays checked all fuses. WTF is wrong?
View 14 RepliesFord 7.3L Power Stroke (1999-2003) :: 2000 F350 - Noise Like Exhaust Rattle Or Vibration At Idle
I have a 2000 Ford F350 7.3 with the auto and 262,000 miles on it. As far as I know everything is stock on this truck. It has been a great truck but lately its been making a strange noise. It almost sounds like an exhaust rattle or vibration but it is intermittent. Its not really loud it can be heard best in the cab at idle. I've looked all over on the truck and haven't found anything. I can't pinpoint where it is coming from. I tried starting the truck with the serpentine belt off no change.
I took the inspection plate off the bell housing and couldn't see any cracks the torque converter bolts appear tight, and the starter is not engaged while running. I've read a few forums on the torque converter going bad. It looks to me like its more the 99 trucks that had trouble with that. Did the torque converter issue carry over to the 2000's? Would a torque converter/transmission problem be intermittent?
Ford 6.0L Power Stroke Diesel :: 2005 - White Smoke Coming From Exhaust
2005 6.0 & noticed on Friday there was white smoke coming from exhaust that started when I'd turn on truck then aster 1st light or stop sign it would be a cloud of white smoke. Once I start to drive it stopped & I didn't see it again that day. I noticed the same thing again on Saturday & Sunday but the smoke was thicker on these days but would stop like the day before.
I had a code come up a month ago which I believe was P404 but read something about EGR valve. So I replaced the EGR valve 3 weeks ago & light never came back.
Today I had a Dr's Appointment and had usual white smoke in morning but once I got to the Dr's appointment the truck sounded like the turbo got louder then usual and started to see cloud of white smoke again. While sitting in parking lot I check to see any codes but nothing came up but the cloud of smoke started.
When I left my appointment, the turbo sounded louder still and noticed white smoke every single time I stopped at a light or stop sign.. Then the coolant level was high with the engine giving me the warning of over heating coolant or something like that.