Ford 6.7L Power Stroke Diesel :: Very Strong Diesel Smell?
One of the great things I liked about the new 6.7L engine was the lack of any diesel smell. While the tips of the exhaust pipes remain clean at 64,000+ miles, no soot, my truck now has a strong smell of diesel after each use. The truck is running strong but I can't figure out why this is happening.
View 4 RepliesFord 7.3L Power Stroke (1999-2003) :: Fuel Smell On And Off / Strong Odor Of Diesel
I have been smelling fuel on and off for the last few weeks. I thought it was the fuel bowl drain valve so I ordered the kit for the whole fuel bowl from diesel o-rings. I did the rebuild this morning and I don't see any visual leaks. Still smell a strong odor of diesel though. The lower engine cradle is all wet and the valley is still a little wet too. Could I still have a leak and if so where to look? Could it be just wet still from draining the fuel bowl and needs time to go away?
View 14 RepliesFord Super Duty (1999-2016) :: Strong Diesel / Exhaust Smell?
Not at the exhaust, but from the engine compartment. Have to open the windows at a stoplight. Can also smell it when I walk past the parked truck. What's up?
View 8 RepliesFord 6.0L Power Stroke Diesel :: Strong Coolant Smell Happens When Accelerating Up To Freeway Speeds Or Passing Cars
Why I am smelling coolant? I have a 2004 6.0 SD.It generally happens when accelerating up to freeway speeds or passing cars, Medium to hard acceleration and the smell is strong and will go away after a few min. The obvious thing is to check for a leak but I haven’t seen any.
View 14 RepliesFord 6.7L Power Stroke Diesel :: Exhaust Smell In Cab - Fix?
I have an exhaust smell in the cab of the truck. It is pretty strong. Seems worse when it is really cold outside and goes away when outside temps warm up. I checked the tube (passenger side behind engine) and did not see any soot.
View 12 RepliesFord 6.7L Power Stroke Diesel :: Exhaust Smell In The Cab
Was cold this morning, -15c, and I remote started the truck and then left home about 5min later. I could smell exhaust in the cab. I read some of the other threads about this. How can I tell if it was doing a regen? I have an Edge Insight. Is the a parameter I can display to know the regen was active?
View 14 RepliesFord 6.7L Power Stroke Diesel :: Exhaust Smell So Bad When Truck Warming Up?
Got to thinking today while my truck was warming up, why does the exhaust smell so bad. I think it is kinda interesting that the exhaust pipe is so clean also, like new matter of fact.
So what make the exhaust smell? The exhaust filter traps the partials right but where did the diesel smell go? I can understand it when in regen but in normal operation I don't get it. I guess I just don't the mechanics behind it. All I do know is that, what is left just stinks especially when warming up.
Ford 6.7L Power Stroke Diesel :: Exhaust Leak / Smell In Cab While Idling And At Startup
Started smelling exhaust in the cab while idling, and at startup. After further investigating found out the EGR inlet tube is leaking at the flex joint. So my question is , is there anything that will jump at me while I'm doing this tube replacement.
View 3 RepliesFord 6.7L Power Stroke Diesel :: 2015 - Excessive Exhaust Smell In Cab During Extended Idle
2015 6.7 KR... when idling for long periods of time the cab starts to smell like exhaust. I've also noticed when standing outside the truck with it idling (not in regen), it freaking stinks, bad! My 2003 never had this problem and idled for days (literally). Possibly leaky gasket here or just the nature of the 6.7?
View 14 RepliesFord 6.7L Power Stroke Diesel :: 2012 - Exhaust Smell When Towing Hard - Normal?
I just took my new (to me) 2012 F350 out for it's first real tow job; pulled our 9,500lb travel trailer up and over the Sierra Nevada Mountains for a week long camping trip.
Under load, I started to smell a burning metal/paint smell in the cab, to the extent that I was wondering if something was wrong. All of the gauges were fine, and there was no unusual smell under the hood.
My wife discovered the floor on the passenger side was hot to touch (directly above the exhaust), and it actually started to melt a few plastic items in her purse.
I did just have the EGR valve replaced after it threw a code; not sure if there's some coating on the new one that could be burning off.
Isit normal for the floorboard to be that hot when working thes trucks?
Ford 6.0L Power Stroke Diesel :: Slight Exhaust Smell In The Cab - Bellow Joints Leaking?
I have been smelling a slight exhaust smell in the cab of the EX. I slide under the truck and looked at the up pipes and bellows. I saw a slight amount of soot on the outside of both bellows. So does that mean I have a leak? What is the most economical fix? Does the turbo need to be removed?
View 4 RepliesFord 6.0L Power Stroke Diesel :: 2003 - Exhaust Smell In Ventilation System When Romps On The Pedal
Usually in the OBS 7.3 but a buddy of mine with a 2003 6.0 is having some issues. When he romps on the pedal but when he does so he claims he can smell exhaust in the ventilation system. I rode with him and smelt it as well. So I inspected all exhaust clamps and piping as best I could and did not notice any soot or leaks while running. I don't know if it pertains to it or not but his heater only works on defrost.
View 4 RepliesFord 6.7L Power Stroke Diesel :: 2012 - Exhaust Smell Coming From Truck - White Smoke
Today I drove to dinner in my 2012 6.7 with no problems then on the way home my brother said he noticed my truck was white smoking quite a bit and he said there was a very strong exhaust smell coming from my truck ( he was in his car behind me) I ran a diagnostic test and what came up was code P0401 (I believe that's right). Need to figure out what is going on with my truck before I take it to the mechanics and get charged up. The truck still has DPFs in it just has a DPF back exhaust and has a AFE cold air intake running on a stock tune. However I do have the DPF deletes and EGR delete sitting in my garage just haven't gotten them on the truck yet.
View 2 RepliesFord 6.0L Power Stroke Diesel :: 2005 F550 Cranked Strong But No Start - P2285 Code
I have a 2005 F550 with a 6.0. Recently I have had issues with a long crank before starting at times but once it started there were no issues driving. Yesterday it started up in the morning, made a few stops then it wouldn't start at all. Cranked strong but no start. Had it towed back, sat for an hour or two now it starts again. Put a gauge on it and all readings are good. Did have a P2285 code which the ICP sensor. I do suspect there could be an issue with the egr cooler as it needs coolant occasionally. Could that have anything to do with the no start? Truck has started fine today. Why start sometimes then not?
View 11 RepliesFord Ranger / B-Series :: 1994 - Running Rich / Strong Exhaust Smell
1994 reg cab 4.ol 13ok.. my wife just got it, been doing some small things like replaced dome light, replaced cargo/third brake light, truck starts and seems to run ok. but i get a headache in it which i believe is carbon monoxide, has a leak or something? i text previous owner, he said he replaced 02 sensors, but didnt say if they were bosch or a good brand.. also trucks has a oil pressure and coolant temp gauge fitted on by the gear shift as the dash gauges for those functions are out. Does this mean the CTS may not be working and affecting fuel/air I do not know these trucks i only just found out what this strange silver looking thing was it is the IAC, I Believe, then there is this black plastic vacuum type cylinder by the passenger side firewall, what is that? and right against the drivers side fire wall is a small reservoir type thingy, is this something to do with ABS? i do have an ABS light on, was hoping it was the bulb out on the third brake light or something quirky like that no such luck its still on after starting engine. but i am concerned about this running rich/strong smell as we really cant take it far as is it, its dangerous, may have to get a smoke test? Just got the truck, trying to get caught up..
View 8 RepliesFord 6.0L Power Stroke Diesel :: 2000 - Antifreeze Smell / No Start / Starter Not Engaging
So about a week ago I noticed that my 2006 6.0 with 240k miles smelled like antifreeze. I popped the hood and noticed my dega tank was empty. I added coolant to halfway between max and min. A couple days later discovered coolant had dropped to just below min fill. Went to start it this morning and the starter won't engage the flywheel. I hear the relay click and the starter is making a whirling noise. I figure I will try to manually crank it to check if it's the fly wheel. If it's not that I guess I will take the starter to get tested. And if that's not it.. I guess a mechanic.
View 1 RepliesPassat (B5) :: Strong Exhaust Smell Around The Car And In The Cabin Except When A/C Is On
There is no noise that would indicate a hole in the muffler, just the exhaust smell. I'm wondering if the catalytic converter is going out? If it is the catalytic converter, will it strand me on the highway eventually?
View 2 RepliesFord 6.0L Power Stroke Diesel :: Won't Start On Cold?
Well.. my truck has been running great for the past few years. This morning I went to start it and all it does is cranks and cranks.. no start not even a sputter.. I use the torque app and noticed the HPOP was over 900 psi during cranking and ICP volts were .8 volts. FICM was 48.5 and around 47 during cranking. I even unplugged the ICP connector and got the same results.. just cranks and no start. i noticed while it cranks i don't get any white "smoke" coming out of the tail pipe I even sniffed in there and I don't smell any diesel at all.
I pulled the upper fuel filter and it is full of fuel, the fuel pump does its normal buzzing when the key is turned on. I even checked the emergency shut off switch for the fuel pump and it was fine. At the moment I am charging both batteries... they were draining because of all the cranking. I think I will check the FICM with a multi meter when the batteries are good and charged.. Seems weird to be running fine with no hints of issues then all of a sudden its dead.
Elantra MD (2010-15) :: Intermittent Strong Exhaust Smell
I'm going to take my Elantra in to get it checked. My Elantra is a 2013, got it in March. Over the last few weeks, I would say, on 4 days or so there has been a STRONG exhaust smell. No smoke, nothing else but a smell. If I'm pulling into the garage with no idling, just pull in and park, I get out and the smell in the garage is very strong. I have to leave the garage open for at least an hour if not more to air it out. The cab ends up having a light smell inside the next day still.
If I'm parking outside when I get out I can still smell it, but not quite as strong, because I'm not in an enclosed area. I don't think it's an exhaust manifold leak, because I don't hear the popping. My best guess is it would be in the tail pipe area pre-catalytic converter, or in the catalytic converter if it is in fact an exhaust leak.