Ford 6.0L Power Stroke Diesel :: 2007 - Antifreeze Smell With CEL On?
I have an 2007 6.0 turbo diesel with approximately 120,000 miles. I have not done any work on the truck other than change the oil and fuel filters the last 9 years. Lately the check engine light came on and every now and then I can smell antifreeze in the air vents coming out. What may be causing this? I am looking to upgrade for more power and do a few things to the engine to make it bulletproof. I have heard something about and EGR bypass or something that I need to do. Not sure I fully understand it and what does it fix or what it will cost me. I have also heard something about head gaskets and head bolts. I may do the work myself if its not too complicated. What all needs to be done on this engine to make sure it stays strong for years to come. What is the best engine tuner/chip for more power?
View 14 RepliesFord 6.0L Power Stroke Diesel :: Truck Overheats And Start Blowing White Smoke / Smells Like Antifreeze
2006 overheats and starts blowing white smoke, smells like antifreeze, added 2 gals of water to make it 1 mile home. Smokes on the way @195 temp and when I shut it off it smokes out tailpipe for another 3 min. Smells like the head gaskets just went, what should I check? The eot and ect have been 10 deg or less.
This has 225,000 miles on it ran great before this, so would it be stupid too not get a redone set of heads while I'm doing the gaskets and studs?
I was thinking of getting heads from here, UCF Machine Shop - Precision machining, engine rebuilding and more. Cummins + Ford Rebuild Specialist. And a Sinister Diesel Complete Solution For Ford Powerstroke 2003-2007 6.0L. Are these the right places to deal with or should I look elsewhere?
Ford 6.0L Power Stroke Diesel :: No Start - Replaced Starter And 2 New Batteries?
In the last 2 months I've replaced my starter and 2 new batteries. I've tested the alternator and it's fine. What more is there? I'm guessing the FICM is going to crap. If I attach a scangauge 2 to it now would it tell me if that's the problem?
View 14 RepliesFord 7.3L Power Stroke (1999-2003) :: Starter Sometimes Spins Free 2 - 3 Tries Before Engaging
I just bought a 99 F350 to replace my 01 F250 5.4 and I'm pretty stoked. There are several problem (some i knew about, some were surprises) 1 of which is the starter. The guy I bought it off said that every 100 starts or so (more like every 4-5) the starter sounds like it free-wheels but you just wait for it to stop, turn the key again (sometimes twice) and it engages and starts (although it takes a few seconds of turning over before it fires up).
I have a buddy with the same truck and he has had to replace his starter many times and I read in an old log book from the original owner that he had replaced the starter every 25,000kms (15,000miles). I am not the kind of guy who likes to fix things to have them break again.
SO my question is, WHY do the starters on these trucks keep breaking? What is the weak link? Is it possible to re-build one with better parts at home?
Is the problem partially because my batteries are only 650CCA and 750CCA and it takes more to turn this beast over? Could it be a bendix issue?
Ford 7.3L Power Stroke (1999-2003) :: 2000 - No Sound At Start Up - Flywheel Or Starter?
Four months when you tried to start the vehicle sometimes you will hear the starter. Drive in gauge but not meet the flywheel. Sometimes it would take three or four tries to turn over the engine. Yesterday went out to start the engine turn the key nothing happen no noise nothing but all the lights were working OK..
The repair shop said it was not the starter but flywheel missing teeth. But they said the main thing wrong is a need of new battery terminals. They change them in the truck started fine last night Today when my wife try to start it then come home saying thing happen nothing no sound, no nothing. Am I dealing with a bad starter solenoid perhaps or a combination of a bad flywheel??
Ford 6.0L Power Stroke Diesel :: 2004 F350 - Battery Light On - Won't Start - Starter?
am in possession of my fianc's F350. The battery light kept coming on, I changed both batteries... twice. I pulled the alt and took it to 2 different stores, asking them each to test it twice, and it checks out good. Drove it to a family function in Sept and it died (no lights, no dings, just completely dead), couldn't get it to jump so I had to have it towed. Tow truck driver said it was probably the starter solenoid, but I couldn't get any confirmation. Had a charger/jumper hooked up to it and got gage movement, dings and heard a clicking sound when I tried to start it.... still no jump. Is this a starter issue, or an electrical issue?
View 14 RepliesFord 7.3L Power Stroke (1999-2003) :: Starter Engaging Randomly / Sizzling Sound Under The Dash
So I just bought a E99 f350 lariat. I wrecked the truck on the test drive and felt like the right this to do was to buy it. Finally have everything fixed and replaced on the truck and have run into other issues now.
While flushing the coolant system I started noticing that the starter was engaging randomly. After doing some research I found out it could be the GEM under the dash. Looked under the dash and I could here a sizzling sound and seen "smoke" /water vapor something coming off the GEM. And there is water coming through from the window/cab lights.
So. All the post I seen where from like 6 - 10 years ago. Where is the best place to buy a GEM? Will having the window replaced take care of the leaking issues on the window? What's the best after market cab lights? Cause I think they are leaking too.
Ford 7.3L Power Stroke (1999-2003) :: 2000 - Diesel Smell At 158k Miles?
Diesel smell in cab. 2000 F350 7.3 158K on the clock. Just noticed it 3 days ago. Been meaning to address the passenger side fuel line clamp issue. Learned about that one here. Gonna tear the stuff out to get at that one Tuesday. Replacing the clamp. Hope the fuel line is not already compromised.
View 9 RepliesFord 6.7L Power Stroke Diesel :: Strong Exhaust Smell On Cold Start?
We've had a run of -20 to -40 weather here for the past few weeks.
A few weeks back I noticed that when I climbed into my truck after command-start warm up for 10 minutes, and I could smell strong exhaust.
I figured it was hopefully the wind, or an isolated event.
Over the past few weeks I've used my truck for 3-4 more around town runs and every time I warm it up I get the strong exhaust smell. It's that rich, eye watering, sickening exhaust smell. I also notice a small yellow frozen puddle under the exhaust tips that wasn't there before.
It's bad in the cab, but even walking around outside the truck and the smell is sickening. I actually just started the truck and I could actually smell the exhaust smell faintly, from inside my house! This has never before occurred. Prior to this, a person could hardly tell it was a diesel by the smell of the exhaust.
Once the truck is up to temperature the smell seems to disappear, or at least lessen.
Ford 6.7L Power Stroke Diesel :: Metal Particles In Antifreeze
I have a 2011 Ford F-350 with 6.7L I have had cooling issues when pulling a trailer up a grade it heats up where it hadn't in the past. I had it in the shop 4 times before it went out of warranty and they changed the oil cooler and thermostat. The last time it was in the shop was November which it was to cold out to duplicate problem. It's heating up on just about every grade and now it's out of warranty when it should have been fixed last year.
I'm guessing it's the water pump because when I changed the antifreeze there was metal shavings in it. I told my dealer about it and they said it was probably from manufacturing. I haven't called dealer yet because I think it should be covered under warranty since the problem was never fixed after being in the shop last year!
Ford 6.0L Power Stroke Diesel :: 2006 F250 Steaming After Antifreeze Filled Up
I have a 2006 250 ford, just put new head gasket with head studs, new oil cooler, deleted the egr by welding it, ran good for hundred miles but flushed it out and filled it with antifreeze and now it's steaming, sometimes it will do it and sometimes it won't and I can't figure it out.
View 14 RepliesFord 6.7L Power Stroke Diesel :: Antifreeze Spray On Windshield While Pulling And Going Up A Hill
2011 ford f350, 200,000 miles. I was getting an antifreeze spray on the windshield while pulling and going up a hill. It was from exhaust pressure going into the coolant system. It was building over 16 psi and blowing out the degas bottle.
View 14 RepliesFord 6.7L Power Stroke Diesel :: 2011 - Antifreeze Leak At 1300 Miles?
2011 Super Duty, SB, 6.7, Lariat, SuperCab, FX4 Undercover hard bed cover, Ford bed mat, and mud flaps.Traded a 2003 Expedition with 100k miles on it. It was time for a new tow vehicle, I tow a 30 foot travel trailer.(7000 to 8000lbs) The dealer offered me a deal at invoice plus all of Ford's incentives, so I couldn't refuse.
I have about 1300 miles on it and it runs fine. I have been noticing a wet spot under the right front of the truck, checking today it looks like anti freeze leaking from above the air condition pump. It makes about a 3 inch diameter wet spot, the fluid recovery bottles are still at the correct cold coolant level. I couldn't get my hand in that space to find where it is leaking from.
Ford 6.0L Power Stroke Diesel :: Trans Engaging Into Drive But Will Not Move
I have a 2004 6.0 with the 5L110 transfer and torqueshift transmission. While test driving after installing everything, I didn't get 7 ft down the road and the tires locked up and she came to a dead stop. Now I only have reverse but I can still feel the tranny engaging into drive but will not move.
View 2 RepliesFord 6.7L Power Stroke Diesel :: 2011 F350 - Lost One Gallon Antifreeze Coolant
Had my oil changed on my 2011 F350, and the tech said that I lost one gallon of antifreeze coolant. Where could the coolant have gone? We could not find a radiator or hose leak. I am afraid that the coolant somehow got into the engine oil, and may have damaged the engine. I have 46000 miles on the truck.
View 14 RepliesFord 6.0L Power Stroke Diesel :: Auto Transmission Won't Engaging - Torque Converter Broken?
Before taking to Ford or random trans shop just yet, looking for diagnosis recommendations (or an item or two to replace DIY). Torque converter bolts are broken or TC itself? Solenoid (but would expect a code)?
Issue: Doing 45MPH at the tail end of the 6hr drive, then engine simply revved and coasted to stop. No lurch, pop, noise felt like a manual transmission popped out of gear and into neutral. When the shift to R/D/L/4x4 hi/lo, can feel transmission engage. Engine revs and 'slips' are the best way to describe (no abnormal noise otherwise)I can feel it applying a very slight load (doesn't move, but can feel it try). No warnings/issues leading up to this in the 6yrs and 100k miles I have owned (has 174k miles now). No leaks/visible issues underneath.
Fluid is not burnt, the level is ok. Replaced (no flush) Mercon SP fluid at 125k when bulletproofing. No codes, including hard codes. Trans temp was 165 before/after, which is normal. All engine temps/values on Scanguage normal. SCT tune since bulletproof (though don't abuses it), set back to stock. Also disconnected pos/neg and touched both sets of cables together for several mins.
Ford 6.7L Power Stroke Diesel :: 2011 F350 - Transmission Temps Hot / Antifreeze Coming Out The Cap On Degas Bottle
Just bought a used 2011 ford f350 with the 6.7 diesel engine. Coming from a 7.3 1999 f350 with 330,000 miles, still going good. Took a 1000 mile trip on the 11 truck with out pulling anything did good. Hooked my enclosed trailer to it did a trip of 900 down and 900 back. Transmission temps were staying around the 250f, almost in yellow on gauge. Highest it went was 255f. Light never came on. Yesterday on trip without trailer was staying at 230f on trans temp. This is the first concern.
Second concern, had antifreeze coming out the cap on the degas bottle. Rolled over the hood and hit the drivers side windshield. Stopped un did the cap, it hissed. Put 2 quarts of antifreeze in drove on, this at 300 miles of trip. Primary water pump went out, half way there, at about 550 miles of trip. On trip back, about 1600 miles of trip, antifreeze was on windshield again. Undid cap, hissed, did not need to add any to it. Drove on no problems since. Have bought a new cap and installed.
Transmission doesn't want to shift right when its cold. First starting out. When it warms up shifts great. That's third problem.
Accent LC (2000-05) :: Starter Is Engaging But Engine Won't Catch
Driving home in my 04, and it just died, no caution lights, still have battery power, and starter is engaging but engine wont catch, like no fuel or spark. Found no burnt out fuses, and checked the fuel pump relay. Pulled out the back seat, turned key and heard the fuel pump, so that is working, replaced the crackshaft position sensor, still no engine start.
Over 130k miles, 1.6l
Ford 6.0L Power Stroke Diesel :: Starter RPM When Cranking?
I've been trying to figure out a slow start condition on my 06 F350. What should the starter rpms be when cranking? My scanguage reads 180. Does this sound low? Batteries are new.
View 9 Replies