Ford 6.0L Power Stroke Diesel :: Part Number For High Pressure Oil Rail Check Valves
What is the part number for the high pressure oil rail check valves for a 2003 6.0L? I'm referring to the ones that screw into the oil rail. I would like to avoid the local dealer if possible.
View 6 RepliesFord 6.0L Power Stroke Diesel :: Injector Spool Valves Blow Off Bodies - Broken Bolts
While diagnosing a low power and misfire condition on my 04.5, I was measuring coil resistance at the injector connectors. Found 1,3,7 had open circuits for one of the solenoids. 3 bad injector coils and no codes, no contribution codes... Why?
Anyway, pulled it apart to find the spool valves of 1 and 3 came out with the oil log the small bolts that hold them to the bodies had broken off. #7 only 1 bolt had broken off and the other was there but loose.
I got this truck with no history, and Had a variety of issues, like a bad fuse box that caused a no start, massive amounts of water in the fuel, and it had sat for 6 months untouched before I got it. I took care of the previous problems search for my previous posts if interested.
So what caused the spool valve to get blown off the bodies? I'm not sure if these have been rebuilt or ever removed, truck has 135 k. Could it be the water in the fuel that seized the intensifier piston?
Ford 6.7L Power Stroke Diesel :: Under Rear Seat Storage Area Access?
Crew cab, have easy access to the under rear seat storage area to grab a few quick measurement? I need to know the entire length (side to side) and width at the widest points as well as depth.
View 2 RepliesFord 6.7L Power Stroke Diesel :: Remote Access Installed - Error Code 00011000?
I've had the Ford Remote Access installed on my pickup for over a year now and it's worked great up until about a week ago when I changed cell phone providers from AT&T to Verizon. Now when trying to use the app I get the error code 00011000. I up-dated the app to reflect the new carrier but it still doesn't work. And yes, my subscription to the service is current. What I need to do to get this working again, with winter just around the corner I'd sure like to have this functional again. I figured I'd give the forum a shot before I resort going to the dealer.
View 14 RepliesFord 6.0L Power Stroke Diesel :: How Tough To Access / Replace Windshield Washer Pump
getting weak spray/dribble (yea, it could be a "personal problem " on the drivers side squirter. Left side great. I have replaced both squirters and blew out the line where it T's over to the drivers side.
Still weak.. I'm thinking its most likely low pressure coming off the pump and maybe it's time to replace I haven't crawled under there to inspect placement of pump. Thought while there I would also replace the reservoir.
Ford 6.0L Power Stroke Diesel :: Third Set Of Tire At 20,000 Miles?
Well so far I have had this truck for 5 years and I'm going for the third set of tires. So far I have run Nitto terra grapplers, and currently BFG at ko's. Both sets wore out around the 20,000-mile mark, they both wore very evenly, rotated every 6,000 miles, properly inflated, check the lineup at 2 different reputable shops.is it something about the 275-65-20s that make them wear faster? I really don't need an at tire as I don't go off road that much so I'm thinking of a good all season radial.
View 14 RepliesFord 6.7L Power Stroke Diesel :: Tire Sizes
hello, so yesterday at the local gas station I was talking to a guy who has a new, nice looking GMC 1 ton 4x4 nondually truck. we started talking about milage and he told me that going up 2 sizes and adjusting it in the onboard computer he was now getting 22mpg.
so I know this isnt an apples to apples kind of thing, and I do know that for example on my F250 it is geared to haul... but has anyone got real data on getting back down to a 3.55 gear adjusting tire size? has it made a difference ? especially if it is just a DD and not a work hauler. yes we all know if you go too far milage gets worse, but I always found for a non-work truck that the 3.2-3.5 rear gear ratio or equivalant eith by changing gears or tire size was a sweet spot for MPG.
right now at 13K I get about 17-17.5 mpg unless I am driving on the interstate and then I get a tad more.
thanks Fert
Ford 6.7L Power Stroke Diesel :: Right Rear Tire Is Cupped?
Truck started riding weird, checked and my right rear tire is cupped. So now I get to buy new tires! I guess 60K and change on the original Michelin's is pretty good - whatdy'all think?
View 9 RepliesFord 6.7L Power Stroke Diesel :: Tire Pressure Sensors Going Off
Why are my tire pressure sensors going off, I have 70#'s in the front and 62#s in the rear, which is more than enough air.
None of the tires have a leak in them, yet I keep getting the sensors to trigger, and why would it be so hard for the system to point out which tire is low??
Ford 6.7L Power Stroke Diesel :: TPMS - Low Tire Pressure Light Won't Go Away?
I had the low tire pressure message and light come on back when i was visiting california, about 3 weeks ago..i checked the tire pressure, and a couple tires were maybe 5 psi low at the most.. i aired them back up to the right pressure (as stated on the door pillar sticker) and the damned light/message is still coming on.. how do I reset the TPMS? it says in the manual to just drive the truck 20mph+ for about 2 mins after getting the tire pressure correct, and the light/message should turn off. i have done that...
View 14 RepliesFord 6.7L Power Stroke Diesel :: 2011 - No Tire Pressure Alarm?
One of the few disappointments I had with my 2011 F350 was it lacked a display of individual tire pressures like both Dodge & GM have. I figured the idiot light would have to do. Recently I found that an inner dual tire was flat. It made a subtle squeal when braking or turning sharply, and a quick inspection showed I picked up a nail.
I never got a tire pressure alarm. I read my manual and it describes the system, but the writeup only indicates setting up four tires. Am I missing something? Have you guys got a working tire pressure monitor on your duallies?
Ford 6.0L Power Stroke Diesel :: 2003 - Front Passenger Tire Leak With A/C On?
I just see a fluid by the front passenger tire leak when the diesel is running and ac is on.There was fluid up by both aluminum lines going into a plastic canister in the engine compartment on the passenger side.I couldn't find any cracks in the hoses or aluminum lines..The plastic canister I believe is (AC ACCUMULATOR ) did have a hiss of air when I shut the truck off. I can't see where the clear liquid is coming from. Just started to leak by the front passenger tire.
View 3 RepliesFord 6.7L Power Stroke Diesel :: Tire Pressure Monitor Fault On Display
Well, at a little over 10k I have my first issue. My monitor displayed a Tire Pressure Monitor Fault. All tires are OK. Light won't go out. Guess it just earned a trip to the dealer.
View 14 RepliesFord 6.7L Power Stroke Diesel :: Tire Pressure Is Correct - TPMS Light Will Not Go Off
2013 F350 SRW . Pressure is correct . Anything special you need to do to make the light go away ?
View 14 RepliesFord 6.7L Power Stroke Diesel :: Code P1635 - Tire / Axle Out Of Acceptable Range
I was updating the firmware on my mini max tuner today and decided to calibrate for the 37" tires. After calibration was done I got the code P1635, which is "Tire/Axle Out of Acceptable Range". Should I bring it back down to 34" where the FORD ECU stops calibrating? I mite have lost traction control with this calibration as well. Mite find out tomorrow if I get an itchy foot. Truck seemed to drive better and pull harder off the line....low rpm's.
View 14 RepliesFord 6.7L Power Stroke Diesel :: Tire Sensor Light Comes On After 20 Minutes Driving With New Tires
I just bought 4 new tires and since then the Tire Sensor light comes on after I drive about 20 minutes. The place I bought the tires from has used their tool twice now and it is still happening. Could they have done something to have made this happen because I had no problem before they changed the tires...
View 1 RepliesFord 6.0L Power Stroke Diesel :: 2004 - All Of A Sudden Rear Passenger Tire Is Locking Up
I have a 04 F250 6.0 and change transmission and transfer case. Now all of a sudden the rear passenger tire is locking up but the rear driver side still moves. I've dropped the carrier and the ring and pinion looks great and so does the spider gears ... Need on whole new rear....
View 14 RepliesFord 6.7L Power Stroke Diesel :: Traction Control Light On While Running Spare Tire
My right rear tire picked up a screw this evening heading back toward Seattle from Chelan. I put the spare on and continued on my way. I noticed for the first few miles the traction control warning light was on. It went off and stayed off until I stopped for fuel and again it came on for a few miles. I'm suspecting this is due to a slight diameter difference between the 20" wheels with the Michelins and the 18" spare. I really hope this didn't stress the differential (3.55 ELD). As I understand it, unless locked the ELD is open all the time..... I would assume Ford wouldn't equip the truck with an incompatibly sized spare......
View 5 RepliesFord 6.7L Power Stroke Diesel :: Constant Ticking After Regular Oil Change And Tire Rotation
I've got an 2016 F250 Diesel 6.7 PowerStroke, which I bought fresh off the lot, and just got my regular oil change and tire rotation today, thru a local Ford Dealership. I'm working out of town, so I didn't take it to my home dealership as I have been every 5,000 miles since I drive a lot for work. As of today, I'm currently at 47,000 miles. Just to stay on top of things, any time I'm asked to get any type of extra additives, or filters needing to be changed, I do so. I don't like bad surprises when it comes to vehicles. So after getting my truck serviced today, and back to work, I notice a constant "Ticking" but do not know why. Thought maybe after running it all day at work, not literally all day, that it would go away. I took it in at 7:00am, and here I am at 9:30pm, and it still ticking. What it could be?
View 7 Replies