Ford 6.0L Power Stroke Diesel :: 2004 F350 - Severe Shudder While Under Acceleration
I bought my f 350 new from the dealer and have had many of the problems associated with this truck. Now I have a severe shudder while under acceleration when i either let off the gas or increase speed the shudder goes away. My dealer thinks it is injectors but I have little faith. Shudder seems to be rpm consistent and seems to be in the front end. oh yea it idles great and runs great except at that specific range.
View 4 RepliesFord 6.0L Power Stroke Diesel :: 2004 F350 - No Throttle - Sometime It Occurs At Startup Or While Driving
I have a strange issue and it happens very sporadic. Sometime it occurs at startup, sometimes while driving. Not sure whether it is limp mode, but I have no throttle. It starts fine, idles, but no throttle. Like I said, sometimes it happens while driving and I have to pull over and shut it down and restart. Mods are few, it has an airaid air filter and I had the turbo rebuilt and egr delete both completed in May. FICM was rebuilt by ficmrepair.com a couple years ago. It does seem to happen more often when it is raining or with a heavy dew after sitting for many hours. 128k.
I adjusted the pedals all the way out and back in and it stopped for almost 5 weeks, but it has been pretty dry here in SW Ohio. then it got really foggy one day and rained the next and it has started again. Could it be that the EGR pigtail is getting moisture. It does not throw a CEL and my scan gauge II shows no codes. I did run a dose of hotshot's secret thru the fuel back in may, ran a couple tanks of fuel, then changed the filters with OEM. I have had this truck for almost 3 years, but still a newbie when it comes to diesels.
Ford 6.0L Power Stroke Diesel :: 2004 F350 - Light Blue Smoke At Cold Startup
2004 f350 4x4 sc dually 130K mi. Cranked truck this morning @ 18*F. Truck not plugged in but regular quick smooth startup. Noticed light blue smoke with normal condensation exhaust for about 5 seconds, then normal condensation exhaust for about 30 seconds. Drove truck at normal operating temps with 5* deltas. To my knowledge, truck has original turbo (Garrett), never been removed or cleaned by me. VGT at startup 70-72, running after warmup mid 50's. Is this a symptom of needing to replace turbo seal, and thorough cleaning while off?
View 1 RepliesFord 6.7L Power Stroke Diesel :: 2011 F350 Won't Go Over 83 MPH
I have a 2011 f350 that i bought with 30k miles on it and I now have 40 k miles. My truck will not go over 83mph it seems like its governed out there.. I have taken it to ford and they thought it was my key was set to max speed 80mph. but it was not and could not figure it out.. I have tried to disconnect the batteries to reset computer. I have not clue what is going on. I do have 35's (tires) on the truck with a leveling kit. But I have verified my speed only going 83 with ford and my own gps device..
View 14 RepliesFord 6.7L Power Stroke Diesel :: 2011 F350 - Loss Of Power And Stinks?
My uncle was pulling his fiver to the beach yesterday with his 2011 f-350 6.7. He lost power, the truck got very loud, and there is a very strong stale kerosene smell in the cab. Strong enough to require the windows be down for ventilation. He was able to limp on into the campground and has an appointment with the dealership Monday. The truck has 19,000 miles and is still covered under the extended warranty.
View 8 RepliesFord 6.7L Power Stroke Diesel :: 2011 F350 - Lost Power Intermittently?
Currently truck is in the shop after having multiple episodes where it lost power. It has 47,000 miles on it. When pushing down gas pedal, just does not want to go. Very slow to shift through the gears and get to highway speed. Turbo was not there, and there was also a hard shift/jerking from 2nd - 3rd. Did notice the traction control sensor kick on a couple of times....which was just replaced since a hole rubbed through the wiring. (took it to Ford twice before they found the problem)
They told me today that the code generator said to look at wiring but they did not find anything (heard that before) and that the fuel is possibly contaminated with DEF. If that is the case, someone is messing with my truck! What I don't understand that if the DEF does turn out to be in the fuel tank, wouldn't we have the problem continuously and not intermittently over a month after driving thousands of miles and going through numerous tanks of fuel? We drive and average of 60 miles per day just for work, half interstate/city.
Ford 6.7L Power Stroke Diesel :: 2011 F350 - Losing Power - Rough Noise - Vibrating?
2011 F350 diesel with 10,000 miles. I have been experiencing problems with the truck loosing power, making rough running noise (pinging like an older diesel), and vibrating. As though the motor is bogging down. It usually occurs on small inclines or hills with the truck in higher gears and low rpms. It will also occur running on flat ground 65-70 mph. Had it occur once while turning the truck around in 1st gear and low rpms. Depressing the accelerator will bring the truck out of it.
This problem occurs randomly sometimes a couple of times a week to not at all. Took to dealer and they found no codes and of couse it didn't do it on the hour long test drive I took the mechanic on. However they did say they had two other owners come in with the same complaints, but could not get trucks to repeat the issue. Problem usually occurs in the hotter part of the day, maybe just coincidence. I had seen similar posts with this problem but no conclusions.
Ford 6.7L Power Stroke Diesel :: 2011 F350 - Reduced Engine Power Code On Dashboard
I have a 2011 6.7 F-350 Diesel. I bought the truck new and I've never had any problems with it until now. I have a SCT Chip & Tuner. It needed an update so I returned the truck to stock and a code came up on my dashboard that said "reduced engine power" which obviously I thought was Normal because of the modifications done to my truck.
I updated my tuner and returned the truck to a performance tune but this dashboard code will not go away. My truck isn't reading any codes and there's no other indication lights on. The truck has Normal RPM readings but 0 throttle response. No power at all...
Ford 6.7L Power Stroke Diesel :: F350 2011 SRV Verses 2013 DRW
I have a 2011 f350 srw 6.7 with 3.55 I found a 2013 f350 drw. I tow a 5th wheel 2 times a year , and the other time use for work about 45 k per year . I am getting 18.0 mpg on highway now, if I trade this and get the 2013 drw what could I get mpg as a daily driver....
View 11 RepliesFord 6.7L Power Stroke Diesel :: 2011 F350 - Whistling Noise At 75 MPH
I've got a 2011 F350 Lariat crew cab and when i get up to 75 mph with a cross wind, there is a whistling noise. it sounds like a turbulent whistle as if its blowing across the ribbed portion down by the wipers. I tried to get audio but for some reason my phone wont pick up the noise, but its extremely loud at times. Sometimes it will wake up the kids if they're napping in the back seat.
View 14 RepliesFord 6.7L Power Stroke Diesel :: 2011 F350 - Trans Fluid Leaking?
Took my '11 F350 CC 6.7 Lariat with 31k miles on it into the dealer to have the tranny fluid leak looked at. I noticed this leak a few weeks ago as the bell housing was damp with fluid and the bolts heads on the underside of the poly engine oil pan were pooled with fluid. It is a very slow leak as I have parked it for 3 days and there were no drips of fluid on the ground, just collecting on the grid like pattern on the oil pan. Checked Fluid level and it is also full.
Anyway, the dealer put dye in the tranny fluid and told me to drive it for a few days. I took it back in on Monday and called this morning for an update. The mechanic informed that they ordered a new torque converter and some other parts to be "proactive" because he believes the TC is the issue. I asked if the cab would have to be pulled and they informed that all the work could be done from underneath. Glad I noticed this before the B2B warranty expired because this would have been expensive. I will be THOROUGHLY inspecting the entire vehicle from top to bottom before I hit 36k.
Ford 6.7L Power Stroke Diesel :: 2011 F350 - Squeak / Chirp From Front
2011 Ford F350, 69K miles... Just started, at about 30mph. I am hearing a Chirp from the front, speeds up when I speed up and goes away with brakes or slow below 30.
Friend thinks its the brake warning telling me its time for new. Bugging me. Just started. Never changed brakes.
Ford 6.7L Power Stroke Diesel :: 2011 F350 - Won't Start / Chugging Sound?
Just went out this morning to start my 2011 F350 diesel and the starter is doing a "chugging" sound. Not spinning the starter at all. Just turned 60,000 miles last week and this is the very first issue that I have had with the truck.
I have put a trickle charger on the battery on the drivers side, and plan to leave it on for an hour or so.
Ford 6.7L Power Stroke Diesel :: 2011 F350 - Oil Leak / Marks On Driveway
1st major problem on my 72,000 mile 2011 F350 is an oil leak that has gotten worse in a short time.. I've been putting it off as I can't be without my truck as I use it for my business but I have to take it in as its leaking pretty bad and leaving its mark on every driveway I pull into,going to take it in the morning to get diagnosed,going to have the exhaust smell in cab during regen looked at also as its been a problem for sometime time now but have just have delt with it till now. Here is a pic of the leak...
Where it may be coming from? Looks like its coming from the top side somewhere..
Ford 6.7L Power Stroke Diesel :: 2011 F350 - Air Water Intercooler Leak?
2011 6.7 F350 .... 120,000 miles ....I have been smelling anti-freeze for the last couple of months but have been unable to find a leak. Going through a minor amount of fluid but no indication on the ground ...
Searching deeper today I see the bottom of my intercooler is wet - remove the air hose and there is some fluid. I am assuming there is NOT supposed to be fluid in the air intake hose - correct?!?!
Any thoughts or history on these intercoolers letting-go and leaking internally?
Ford 6.7L Power Stroke Diesel :: 2011 F350 - Engine Code P0299
2011 Ford f350 6.7 diesel ... Is this a problem we need to have fixed?
View 2 RepliesFord 6.7L Power Stroke Diesel :: 2011 F350 - Engine Code C0034
2011 Ford f350 6.7 diesel .... Is this a problem we need to have fixed...
View 1 RepliesFord 6.7L Power Stroke Diesel :: 2011 F350 - Coolant Additive Check Message
Got the warning on the message center.. 2011 F350 38,000 miles. I am not original owner, has lifetime POWERTRAIN so thinking of letting dealer handle this,,,but..?
With the importance of these cooling systems.. and coolant being in there for approx. 60 months.. I am thinking why pay for test kit or pay dealer to test it and add additive...
I guess I could just buy the oem coolant and distilled water and drain & fill it myself... but can I use garden hose to flush? Or just better to let FORD handle it?
Ford 6.7L Power Stroke Diesel :: 2011 F350 - Black Smoke When Under Hard Acceleration
I recently purchased a 2011 F350 chassis cab with no bed installed. Have a few questions regarding the exhaust system. When I inspected and drove it noticed some black smoke when under hard acceleration, nothing major though. Other that that the truck drove great. Have not got the truck home yet, a friend is going to pick it up and deliver it in a few days. Based on the visible smoke I was suspicious of the exhaust system but I have no knowledge of what the system is suppose to look like. My experience with diesels and for that matter gas engines is mostly from the days of mechanical fuel injected diesels (70's era farm tractors mostly) and carberated gas engines.
My friend stopped by a local Ford dealer and crawled around under a new 2015 Chassis cab to look and compare to this 2011. It appears that the SCR and DPF are not installed on this truck. Where they would normally be is a section of pipe with a section about 2 feet long that is 6 or 8 inches in diameter. Looking at some threads on this site I'm guessing this is a muffler that has been added since the truck is not loud. There is no DEF tank and all the wiring for sensors that would be attached to the exhaust system appear to be tied off to the frame and not connected to anything. The dealer didn't know the history beyond he purchased it on an auto auction and he installed a new rear end in it. Car Fax shows nothing of concern.
My question is should I now be concerned since have determined much of the exhaust system has been removed? I've read some threads and it appears that the only way this can be done and have the engine run well without any codes etc is if the removal is done with some sort of tune. Is there any way to determine who has done the tune? Will it be an issue when take to a Ford dealer for service?
I know if wanted to put the system back to stock would be large dollars, as long as the system runs well and is reliable I will be happy. The anticipated use of the truck will be to pull gooseneck trailer and will probably not see more than 1000 miles a year towing and 5 to 10k total in a year. I drive with a very light foot seldom ever pressing any vehicle to its limits. If still have the truck in 10 years when retire or at least cut back on my work then it may see more miles.