Ford 6.7L Power Stroke Diesel :: 2013 F250 - Disintegrating Steering Wheel?
2013 F250 with 36K miles. Just in the past 2 months I've noticed my steering wheel is disintegrating at about the 12:30 position. No possibility of diesel/chemical transfer to the surface.
View 12 RepliesFord 6.7L Power Stroke Diesel :: 2011 F250 - Vibration / Change Driveshaft?
Truck has just over 5000 miles on it. Had the tires road forced, no luck! Took it to the dealer ford said replace the tires 2 at a time (r then f), picked it up yesterday no better and said that ford wants to put a new driveshaft in it!
View 14 RepliesFord 7.3L Power Stroke (1999-2003) :: F250 - Steering Wheel Really Loose
Just bought a 1999 F250 7.3 cab and a half standard 266k miles. The steering wheel is really loose. Not loose as in turning the wheel to turn the tires but like moment up and down and side to side. Are there bearings to replace?
View 4 RepliesFord 6.0L Power Stroke Diesel :: Steering Wheel Shaking?
Was on the way home today and was taking a long sweeping left-hand curve at 60 and got a horrible shake in the steering wheel. Kinda scared me a bit and let out of the throttle a bit. Didn't happen after and never has before. I'm under the impression it is more shocks maybe then steering, Reason I say that although I don't get a lot of bounce if the road isn't perfectly smooth I can really tell it. What do ya'll think?
View 14 RepliesFord 6.0L Power Stroke Diesel :: 2004 - Hard Start And Skipping
I bought my 04 6.0 from my parents a few years back and had it gone through as soon as I bought it. I got it studded, a new hpop, new oil cooler, 8 new Alliant injectors, and an sct livewire. A few months later my oil temp kept getting high and eventually it caused an injector to go out. Took it back to the guy who originally did the work and he warrantied it.
He said the oil cooler got clogged up on the coolant side. Replaced an injector and the oil cooler and it ran for another couple months before doing the same thing again. Had the oil cooler and injector replaced again and it ran fine until the number 7 injector went out and I had to replace it myself since the guy who was doing the work on my truck decided to pack up his shop and leave basically overnight.
When I got under the valve cover I noticed that the number 7 injector pigtail was different colors than the other injectors so I'm not sure what kind of work had been done to it after all, if he'd been mixing injectors or what, all I know is what he told me he had done. The truck currently has 157k on it. whenever I go to start it my injection oil pressure spikes to anywhere from 1600-1800 and the truck attempts to run but then the truck falls on it's face and the injection pressure will not get above 350-400 for about 10 to 20 seconds of cranking.
Then the oil pressure hand on my dash moves and the injection pressure goes up again and the truck cranks. After the truck is running it has a miss that most of the time goes away as the truck warms up. Im starting to believe that maybe the hoop is going out again but I'm unsure. I'm a heavy diesel mechanic so the huei injection system isn't my forte, but I do have access to just about any tool needed.
Ford 6.7L Power Stroke Diesel :: 2016 F250 - Wind Noise / Vibration At Highway Speeds
Since day one my 2016 F250 occasionally has a reed sounding vibration at highways speeds near the passenger side occupant handle on the windshield pillar. Talked to a service advisor at the dealer about it, what it could be, so this must not be a common problem . The issue is intermittent and can not be reproduced on demand. I tried blowing compressed air all around the area of the Windshield to see if I could reproduce the sound in a shop setting, but no luck. Only thing in common with this noise is 75+ MPH during a rather windy day. I'm a little reluctant to drop it off at the dealer since intermittent problems are hard to diagnose.
YouTube...
Ford 6.0L Power Stroke Diesel :: Float Feeling In Steering Wheel
I've got a 'new to me' 4" Lift 6.0L PSD Diesel, 2005. At 60 mph, especially 75 mph, there's some 'play' or float feeling in the steering wheel. Is that a normal thing for a 4" lift? and nothing to worry about? (the dealer that sold it said they put new ball joints in it. No cheap shock problem, right?)
View 4 RepliesFord 6.7L Power Stroke Diesel :: Turn On / Off Heated Steering Wheel?
I have a 2015 Platinum Superduty that came with a heated steering wheel but cannot figure how to turn it on and off. I have looked for a dash switch and in the climate portion of the touch screen with no luck. My wife's car has a simple dash mounted switch and also a temp sensor that cuts it on automatically when cold. No such luck with truck.
View 14 RepliesFord 6.0L Power Stroke Diesel :: 2005 F250 Will Not Turn Over?
I have a 2005 Ford f250 Diesel 4x4 with - unfortunately - the crappy 6.0 engine. Yesterday my Daughter parked in the yard and this morning the truck not only will not start but will not even turn over. I thought maybe the batteries were dead but that is not he case. When you turn the switch on you can hear the pump start up but it will not turn over? All the lights come on and the bell comes on when you open the door and the dashboard lights work but the thing will just not turn over. I am assuming this may be some type of electrical issue or something but whatever the problem is it just came out of the blue. Ford imo should have recalled this engine.
View 14 RepliesFord 6.0L Power Stroke Diesel :: 2005 F250 Sometimes Won't Start When Hot
I have an 05 f250 with 109k. Recently I turned off my truck, waited about 45 min or so and upon returning the truck would just crank and crank with no fire. After waiting about 4hrs the truck started right up like nothing was wrong.
Yesterday it did it to me again. This time I have it a small shot of starting fluid and it fired right up and ran like a champ all the way to the shop..... I got the call today from the mechanic saying I have 5 injectors that are bad, 2 glow plugs and harnesses. His quote was 2400 out the door.
Ford 6.0L Power Stroke Diesel :: 2005 F250 - No Power At All When Turned Off And On
I had this truck for two months no problems yesterday went on a small trip about 50 miles in on ,the hwy. I start seeing some smoke and then no power turned off & on engine several times a little hard starting no power at all I put the pedal to the floor It barely moves ran into another super d. guy he said fuel filters , I turned around and crawled back home and changed fuel filters still no power. no codes "don't no where to start".
View 8 RepliesFord 6.7L Power Stroke Diesel :: Steering Wheel Position Sensor Replacement?
Replacing Steering Wheel position sensor. How hard of job is it?
View 6 RepliesFord 6.7L Power Stroke Diesel :: Lariat Leather-wrapped Steering Wheel Fit In XLT?
Looking to swap out the vinyl wheel with a leather-wrapped one from a Lariat. I assume that this will be a direct swap but wanted to poll the audience to make sure I'm not overlooking anything.
View 6 RepliesFord 6.0L Power Stroke Diesel :: Slight Aggravating Shake In The Steering Wheel
I have been ignoring a slight aggravating shake in the steering wheel for quite some time. I just assumed tire out of balance or slightly warped front rotor or some ball joint work due to approaching 80,000 miles. Well the slightly warped rotor became much worse so i dove into the front brakes. Long story short it ended up being the rear brake rotor/caliper sticking transferring the vibration to the steering wheel. With two other vehicles to maintain i missed/neglected the rear hardware on the truck. So keep the rear brake hardware on your radar for a front end shimmy. Its gone now and a pleasure to drive again. I do have the crew cab and 8' bed which gives the rear end a long lever.
View 1 RepliesFord 6.0L Power Stroke Diesel :: 2005 F250 - New HPOP And No Start
I got a problem with my Ford F250 6.0 Diesel. The truck got a new HPOP but still wont start. ICP show everything between 15 und 75 PSI, it raises to 75 PSI max during cranking. The IPR shows 84,75% during cranking.
We get the code P0270 and P2285 in exchange but never together. We already checked the FICM but it looks good on the inside. I now ordered a new ICP sensor....
Ford 6.0L Power Stroke Diesel :: 2005 F250 - No Speedometer And ABS Light Is On
I have a 2005 F250 6.0l. I have no speedo and the ABS light is on. It was intermittent at first. It would go on and off if I hit a bump or braked quickly, but now for the last month the light has been on constantly.
I have tried the following to no avail:
1. check the harness to the VSS (rear ABS senor on the pumpkin)
2. replaced the VSS on the rear
3. check the lines from the vss for resistance and open short (and short to ground)
4. checked the HS-can network (pins 14 and 6 in the DLC to the respective HS-can + and - on the module) both have less than 5 ohms (about 3 ohms found) and no short.
5. checked the resistance of the network itself across pin 4-16 and found 60 ohms.
6. ran scans with OBD fusion for ABS (no abs found)
7. ran scans with forscan with laptop, does not detect ABS unit neither new or old module. note the TBC and IC both throw codes about not detecting the ABS.
8. check HS-can on the PCM as well as VSS wire from abs to pcm, no shorts or resistance.
9. check the number 11 fuse, (good) checked ALL fuses, only bad fuse found was trailer light number 20 engine bay. issue was a wire at the tailer connector was t-taped and not sealed leading to a short to frame.
10. checked the connector to the ABS module for power on both constant power pins, for open ground on both grounds, and power on run, all with in spec.
I've been diagnosing this for the last week, I am running out of things I can think of to check.
Ford 6.0L Power Stroke Diesel :: 2005 F250 - 4wd Controls On The Floor
This is my first winter with my 05 F250 that has the 4wd controls on the floor. I'm just trying to figure out the proper way to put in in and out of 4wd. I did some reading and everyone talks about engaging the hubs, but my truck seems to have automatic hubs because the selector Is not on the outside of the hubs. Am I missing something obvious or am I just reading the wrong things. When I bought it at the end of summer, we tried 4wd out but only for a second and it would grind and be generally unhappy when we were doing it (while driving slow, and complete stop to go to low).
View 14 RepliesFord 6.0L Power Stroke Diesel :: 2005 F250 Just Stopped Going When Put In Gear
2005 F250 4X4 6.0 .. Why my truck just stopped going when put in gear and the TOW/HAUL light just kept coming on, without pushing it 2 days prior? Now it will not go anywhere, starts great, gas pedal works because RPM's go up when pushing! Just will not go when put in drive or reverse! What else I can do? I replaced cylinoid B in the transmission, speed sensor, and brake switch.
View 14 RepliesFord 6.0L Power Stroke Diesel :: 2005 F250 - Slow Oil Leak?
My 6.0 has been leaking oil for a couple weeks now, possibly longer judging by the staining underneath. Very slow leak. 1 drop hits the ground when I get off work and go to get in the next morning. It never really reads off the dipstick a drop in the level. I had to top up the oil yesterday but that is from about a 2-week span. But I want to get it fixed. I've attached pictures of where it's coming from and was hoping to get pointed in the right direction. Also its a 05 f250 and coming from the driver side.
View 14 Replies