Ford 7.3L Power Stroke (1999-2003) :: Noise Started While Pulling A Hill At 65 MPH
99.5 7.3. 201,450 miles, Just developed a new noise. Was on interstate, in cruise, 65 mph, started while pulling a hill. Kicked it out of cruise and noise went away. I have found it will repeat just pulling a hill at highway speed.
Now for the noise....it almost sounds like lightly opening the secondaries on a gasser 4 barrel. I don't see anything unusual under the hood.
Ford 7.3L Power Stroke (1999-2003) :: Truck Will Hit About 22 Psi Then Drop Off Slowly When Pulling A Hill Hard
I just got my new up pipes put on as well as a 38R and pulling a hill hard my truck will hit about 22 psi then drop off slowly I have an electronic boost fooler wich has been on the truck since new pretty much but I don't get a CEL at all is this what I should be getting and I was on the 80hp tune? I ordered new boots and plenum inserts they just haven't got here yet. I know I had a leak before on my old up pipes because they rattled every now and then and I could see exhaust coming out of them when it was cold out but I could hit about the same 22 boost with my old setup. So pretty much nothing changed boost wise except it gets up to boost faster now. I would say it's defueling but I was always told the CEL would come on if that was the case.
View 13 RepliesFord 6.7L Power Stroke Diesel :: Leaking - Oil Spray Going Down The Center Of Truck
So I just changed the oil on my truck I had a ford motorcraft filter on there and replaced it with a Fram filter ( only because that's what was on the shelf at the big W store ) I drove it to town and back once ( 35 miles round trip ) ...
I was going to add a trickle charger to my truck as It will be sitting for a while and I was laying under the front of the truck trying to fish the power cord down and I looked back and see I had Oil spray going down the center of my truck . So I thought dam my filters not tight as when I looked at it , had oil streaks coming down it. So I checked it was tight , would not move.
So I wiped if off with a rag and it looks to me as if the filter is leaking at the top seam . were the filter is crimped . There's not way I can take it off and take it back to the store. a filter that is oil soaked . I am going to replace it but before I do I am going to see if I can get the leak on video
Ford 6.0L Power Stroke Diesel :: White Spray Coming Out From Under The Hood When Driving Under Load
Okay so 2007 F350 DWR here, I have a driver who hauls loads using the truck and a 25' gooseneck trailer. She's gone through the bullet proofing process at 80K miles, she now has 128K miles. I have a programmer to monitor temps, and do all required maintenance.
With that said, my driver reported last week that when under load and going up hills he got the white spray coming out from under the hood. See pics below, this is never really good of course but I want to believe its not catastrophic. Two weeks prior I changed out the thermostat and upper radiator hose and of course flushed and filled coolant, all was good - no hoses were loose, etc. Driver reports the truck did not overheat at any time.
Both ECT and EOT are within 10-12 degrees of each other, and did not go over 190 for me while driving around town the other day. There are no codes present, I cleaned the engine bay and drove and re-inspected but can't tell where the coolant is coming from as none appears to be leaking. Last note, I have to admit after driving for a day or two I had to fill the degas bottle up about 3/4 gallon of water. My questions is, what is the next step for me in the diagnostic process?
Diesel - Ford - F350 :: 1997 - Grinding Sound Coming From Turbo When Pulling Up A Long Hill
I have a '97 F-350 with a 7.3L Powerstroke Turbo Diesel, I frequently haul a 27ft bumper tow trailer weighing upwards of 6,000 lbs, which by the way it tows beautifully, but if i am pulling up a long hill or have been on the pedal for a while and let off, then there is a grinding sound that sounds like it is coming from the turbo. My dad and i think it may be some sort of exhaust overflow valve from the quick decrease in rpm or maybe an overspeed on the turbo. No noticeable decrease in power.
View 2 RepliesFord 6.0L Power Stroke Diesel :: Half Throttle Only Going Up A Hill / No Power
Yesterday it was running fine today only half throttle, going up a hill no power throttle push 12 down let off the throttle engine smooths out and starts picking up speed ....
EGR stuck????
CAC boots look good do not hear any leaks on the tubes
no smoke
ICP 675 at idle full temp, cold 1200
OEM filters with OEM caps
ficm 48.5 to 47.5
Can hear the turbo spool up
Oil temp less than 10 dec difference with water temp
No code showing up
141,000 2003 F-350 dually
Ford 6.0L Power Stroke Diesel :: Lack Of Power When Going Up A Hill On The Interstate At 2800 RPMs
While I'm cursing at highway speed everything is fine. But when u punch it it pass someone it's like I actually slow down, same from a red light. I've got a livewire programmer in it and this problem is somewhat new. It just seems to keep getting worse, I was going up a hill on the interstate this morning and at 2800 rpms I was actually slowing down. I'm not sure if the fuel pump is going out or if the transmission is slipping or what.
View 7 RepliesFord 6.7L Power Stroke Diesel :: Metal Particles In Antifreeze
I have a 2011 Ford F-350 with 6.7L I have had cooling issues when pulling a trailer up a grade it heats up where it hadn't in the past. I had it in the shop 4 times before it went out of warranty and they changed the oil cooler and thermostat. The last time it was in the shop was November which it was to cold out to duplicate problem. It's heating up on just about every grade and now it's out of warranty when it should have been fixed last year.
I'm guessing it's the water pump because when I changed the antifreeze there was metal shavings in it. I told my dealer about it and they said it was probably from manufacturing. I haven't called dealer yet because I think it should be covered under warranty since the problem was never fixed after being in the shop last year!
Ford 6.0L Power Stroke Diesel :: 2007 - Antifreeze Smell With CEL On?
I have an 2007 6.0 turbo diesel with approximately 120,000 miles. I have not done any work on the truck other than change the oil and fuel filters the last 9 years. Lately the check engine light came on and every now and then I can smell antifreeze in the air vents coming out. What may be causing this? I am looking to upgrade for more power and do a few things to the engine to make it bulletproof. I have heard something about and EGR bypass or something that I need to do. Not sure I fully understand it and what does it fix or what it will cost me. I have also heard something about head gaskets and head bolts. I may do the work myself if its not too complicated. What all needs to be done on this engine to make sure it stays strong for years to come. What is the best engine tuner/chip for more power?
View 14 RepliesFord 6.7L Power Stroke Diesel :: Turbo Shuddering While Lugging Up The Hill At Low Rpm In 6th Gear
Just bought my 2013 Platinum 350 DRW 2 weeks ago. 9,000 miles on it. I was cruising along yesterday at around 45 mph in 6th gear going up a slight incline. Truck was fairly low rpm don't remember what exactly. As I'm going up this hill it begins to shudder quite a bit almost seemed like the turbo shuddering while lugging up the hill at a low rpm in 6th. I stepped into the throttle to get it to downshift into 5th and it stopped. I never experienced anything remotely like this in my 2011 6.7.
View 6 RepliesFord 6.7L Power Stroke Diesel :: Making Grinding Noise While Turning On Hill
a few times when making a tight turn on hilly terrain or a hill on a road, I've noticed a grinding sound in the front of the truck and a vibration in the steering wheel. I've so far chalked this up to the hill assist feature, but today I was on relatively flat ground in a parking lot with a dip in it. While crossing the dip in a tight turn, I noticed the same thing again.
I've checked the tires/wheel wells and there is no rubbing, etc.
Ford 6.7L Power Stroke Diesel :: Turbo Noise In Tow / Haul While Descending A Hill
In addition to significantly louder noise from the Turbo on start-up, we've started to hear a pretty concerning noise while descending a hill in Tow-Haul. Not sure that the T/H has anything to do with it other than getting the engine in a RPM range that causes the noise. We've taken it in and tech says "That's just normal noise"... What ever that is.
Here is a link to an example : Tow haul making a lot of noise in my F350 diesel. Pulling a very heavy horse trailer. - YouTube
Best next steps for a 64,000 mile 2012?
Ford 6.7L Power Stroke Diesel :: Parked On Hill And Truck Started Sliding Down
Today I visited a buddy who lives on a pretty steep hill. I always set my E-brake while in Neutral to make sure it's holding the truck before sliding it into park. So I got out and unloaded a few things and was in his garage. I heard a skidding sound outside, I was about 40 feet away from it when I looked out my truck was skidding down the hill!
I ran out and to the drivers door, opened it and pressed on the brakes with left hand right when it hit the bottom of the hill and it barely stopped from hitting the blue car parked on bottom of the hill. Next time if I stop on this hill I'll make sure it''s nose up hill and make sure I have 4X4 engaged to have all wheels locked up. I know this probably happened because the lack of weight on the rear wheels but this was a pretty crazy scare with only 7800 miles on her!
You can see the skid marks from my rear wheels, my friend lives in the middle of the block.
Ford 6.0L Power Stroke Diesel :: Cannot Get Over 40 MPH When Pulling Out Of A Stop Sign
A couple months back I blew an EGR cooler. My mechanic replaced it and oil cooler, when I got the truck back it was using coolant and on cold days below 35 degrees it wont start without a little shot of ether. I took it back and mechanic found a pinched o ring.T he coolant problem is ok but cold starts not. Now today truck was running fine then as I was pulling out of a stop sign I couldnt get over 40 mph, I pulled over and then tried to go but no throttle response,then died and wouldn't restart .I have no way of scanning, no dash lights came on. I am wondering if this is related another o ring or gasket,hpop ,fuel problem??? just replaced all the injectors and ficm a little over a year ago.where should I start?
View 14 RepliesFord 6.0L Power Stroke Diesel :: Overheating When Pulling Load?
After replacing both heads with remanufactured heads from ford along with new egr and oil cooler a month ago, she still overheats when pulling a load. While normal driving and not towing, no problems. In the last 5,000 miles since work was done and while towing approx. 15,000 lbs (load and trailer weight) she got hot once, slowed down, temp retreated got home - she has not overheated since then pulling 4-5 loads over the next 2,500 miles. Today at about 75 degrees only 4 blocks after picking up a load at about 12,000 lbs she started getting hot again. After I let her cool down and got on the Freeway the temp went down, appears she's not staying cool in the city with a load on. With all the work and new parts I had installed, what the problem might be?
View 12 RepliesFord 6.0L Power Stroke Diesel :: 2006 F250 Steaming After Antifreeze Filled Up
I have a 2006 250 ford, just put new head gasket with head studs, new oil cooler, deleted the egr by welding it, ran good for hundred miles but flushed it out and filled it with antifreeze and now it's steaming, sometimes it will do it and sometimes it won't and I can't figure it out.
View 14 RepliesFord 6.7L Power Stroke Diesel :: 2011 - Antifreeze Leak At 1300 Miles?
2011 Super Duty, SB, 6.7, Lariat, SuperCab, FX4 Undercover hard bed cover, Ford bed mat, and mud flaps.Traded a 2003 Expedition with 100k miles on it. It was time for a new tow vehicle, I tow a 30 foot travel trailer.(7000 to 8000lbs) The dealer offered me a deal at invoice plus all of Ford's incentives, so I couldn't refuse.
I have about 1300 miles on it and it runs fine. I have been noticing a wet spot under the right front of the truck, checking today it looks like anti freeze leaking from above the air condition pump. It makes about a 3 inch diameter wet spot, the fluid recovery bottles are still at the correct cold coolant level. I couldn't get my hand in that space to find where it is leaking from.
Ford 6.0L Power Stroke Diesel :: Torque Pro Isn't Pulling Any Codes - Cam Sensor?
Was trying to give back to FTE, all have been useful. So I figure I would post a problem solver. Had a nice oil leak traced to cam sensor o ring. All back together now crank no start.
Truck is half in and out of the garage, torque pro isn't pulling any codes. I did accidentally pull my alternator cable out of the connector, luckily had one to replace.
Did I wreck the sensor taking it out? Will have to try and pull the beast out tonight.
Ford 6.0L Power Stroke Diesel :: 2000 - Antifreeze Smell / No Start / Starter Not Engaging
So about a week ago I noticed that my 2006 6.0 with 240k miles smelled like antifreeze. I popped the hood and noticed my dega tank was empty. I added coolant to halfway between max and min. A couple days later discovered coolant had dropped to just below min fill. Went to start it this morning and the starter won't engage the flywheel. I hear the relay click and the starter is making a whirling noise. I figure I will try to manually crank it to check if it's the fly wheel. If it's not that I guess I will take the starter to get tested. And if that's not it.. I guess a mechanic.
View 1 Replies