Elantra XD (2001-06) :: Relieving Pressure In Fuel Rail
I picked up a Haynes manual for the engine/head removal. It has the procedure for 2003 pressure release by unplugging the fuel pump and running until it dies. Unfortunately the car does not run. I do not know what to do now.
View 8 RepliesElantra XD (2001-06) :: 2002 - Fuel Line Leak?
I was just curious is there a fuel line replacement that's pre-molded? Or do I need to get a roll of a certain diameter line and mold it my self? It's leaking right under the drivers door and it used to be pretty small but has gotten bigger. I can take a picture of the location if needed?
View 13 RepliesElantra XD (2001-06) :: 2002 GT - Vacuum Leak At Fuel Injector
I have an '02 Elantra GT with ~175,000 miles.
CEL is on, gives code about evaporative emissions control system, P0441. Shop manual says a)Purge control solenoid valve or b) vacuum leak.
Symptoms are very rough idle, strong smell of gas at startup, erratic, racing idle when starting or cruising to a stop in neutral.
Replaced PCSV, didn't WORK. Went looking for vacuum leak. Seems to be at the fuel injector that's on the end, passenger side, on the manifold side. There's a noticeable hiss, and when I spray gumout at the injector it changes idle. Replaced the injector O-rings. Didn't make a difference. What next?
Elantra XD (2001-06) :: 2002 - Fuel Leak From A Black Vented Box
I came out of my house this morning and noticed a large wet spot under the back of my car. Upon investigation it appears to be a fuel leak from a black vented box that is immediately behind the driver side rear tire and connected directly beside the gas tank. there are 2 hoses that appear to be fuel hoses going into the forward end of this box.
I disconnected two mounting nuts and looked inside but it is an enclosed box mounted inside the casing. I can't find any info on the net or any illustrated parts lists. What this box is and why it might be leaking fuel? The box is rather large maybe 12 to 14 inches long by 8 to 10 inches wide by at least 6 inches deep.
I did fill up my tank last night and I "topped" it off to round the price. My car also parks on a fairly decent slope in my driveway rear end first.
Taurus :: P0193 - Can't Find Port On Fuel Rail To Get Fuel Pressure
I cant find the port on fuel rail to get a fuel pressure reading.it is nothing like my tarus.saw astem sticking up on front right of rail but it has some kind of covering over it. It is a 2005 freestar with the 3.9 motor.
View 5 RepliesVolvo :: Lost Metal Clip Connecting Fuel Line To Fuel Rail - What It Is Called
I have a 1994 volvo 850 turbo wagon. While replacing the pcv breather system, I dropped a little metal clip that attaches the fuel line to the fuel rail with a t25 torx screw. I can't find the clip. What the part is called or where it can be found?
View 1 RepliesJeep - Cherokee :: 1987 - Starts Immediately If Relieve Fuel Pressure At Fuel Rail
I have a 1987 jeep cherokee with inline 6 and multi port injection.
Sometimes this vehicle only starts when hot
Some times only when it cold
I have recently fixed the fuel leak.
When its hot or cold and not starting if i relieve the fuel pressure at the fuel rail, in most cases it will start immediately. However if fuel pressure relief does not work. I disconnect the vacuum line at the what looks to be the EGR valve or the pressure regulator at the front end of the rail, then usually starts right away.
I have not tested at this time to see if the fuel pump is failing nor have i tested fuel pressure. I am trying to narrow down the problem to one specific part. There is no problems with cranking. There is spark - coil, plug, dist cap have been replaced.
It seems the problem is with fuel delivery of sorts. It was mentioned that sometimes the heat from the engine could be heating the fuel rail to a point which turns the fuel into a gas not allowing it to atomize.
LeSabre :: 1987 - No Pressure At Fuel Rail
I am getting no pressure at the fuel rail. Relay seems to be ok, so I am assuming the pump just failed (in the driveway luckily). Before I drop the fuel tank, I would like to confirm I am getting voltage back to the pump. I cannot fine any wiring in or under the car going to that area! How to find that circuit as close to the pump as possible and still accessible without dropping the tank?
View 1 RepliesPassat (B5) :: Leaking Connector Going To The Fuel Rail
Several weeks ago I was smelling gasoline odor in the cabin, mainly when I came to a stop. Took the car to the dealership,and they found a leaking connector going to the fuel rail. They tightened it up, but this morning the odor is back.
View 5 RepliesCaravan/Voyager :: 1999 Cannot Get Started - No Pressure On Fuel Rail
A friend has a 1999 Caravan with the 3.0L engine. He couldn't get it to start and to make a long story short, I checked the fuel pump relay and fuse and they were good but there was no pressure on the fuel rail. Turning the key I couldn't here the fuel pump come on and determined the fuel pump was bad.
I changed the fuel pump and fuel filter put in 1/4 tank of gas and turned the key, and it turned over but wouldn't start. I can audibly hear the fuel pump come on for a second or so, and feel the vibration when I put my hand on it, but there is still no pressure at the fuel rail.
Santa Fe (DM - 2013+) :: CEL Code P0087 - Fuel Rail / System Pressure Too Low
I stopped and when I started the SF the engine light stayed on. I shut it off and checked oil. Oil good. When I started it again it didn't start as swiftly as it normally would. Since I still had 150km to go in the dark I decided to give it a whirl as the alternative, like waiting for a tow truck, would be many hours.
Max rpm, about 2000. Give more gas and it sputters. Eventually nursed it to maintain 80-100 kmh at the 2k rpm. Since it was mostly downhill I continued to at least get closer to civilization. Found sort of a sweet spot and was able to maintain 100kmh on level ground and lost some on grades. Engine was running smooth.
As it turned out I made it home. Total milage on SF: 58,250 km. Guess I'll see what the dealer says on Monday.
Golf IV / Jetta IV :: No Start After Replacing Fuel Lines To Rail In Engine Bay
Yesterday , my feed fuel line was dry rotting and leaking gas so I bought 516 fuel injection hose and replaced them. Pulled fuse 28 , started the car and let it die to release pressure , fixed the hoses and put the fuse back in and now it just cranks forever. I have spark , and I'm getting fuel just not sure if it's adequate pressure. When I open the door the pump did sound a little funny when it primed. I'm gonna pull it out and check it later but right now I'm completely stumped. I did this last night around 8pm and it's 4:30 am the next morning and still not start.
View 6 RepliesFord F-150 - 1997-2003 :: Truck Won't Start - Fluid At Fuel Rail?
I bought the truck now it won't start has to fuel at the fuel rail cranks but won't start when I spray starting fluid it starts but won't stay running....
View 1 RepliesFord Ranger / B-Series :: 1986 - No Fuel To Rail / Truck Quit On The Way
I have a 86 ranger 2.9 5 speed. A few days a go I replaced the front fuel filter and all seemed ok. Last night on my way home the truck quit and I had to have it towed home. Now I find both pumps don't seem to be working. What would make me loose both pumps??
View 11 RepliesFord - Mountaineer :: 2000 - Ticking Or Knocking Sound On Fuel Rail
I have used a wooded stick to locate a ticking or knocking noise on my fuel rail. I can't hear anywhere else on the motor. I took it to a mechanic and he told me it was the timing chains and guides. Sometimes it is very loud and other times it barely noticeable. 191k miles so I am not going to spend $ rebuilding the front of the motor. Just want to be sure it is what he says before I scrap it out.
View 5 RepliesCaravan/Voyager :: 993 Dodge Grand - Small Leak Found In Fuel Rail
I have a 1993 Dodge Grand Caravan. I found a small leak in my fuel rail. Can I buy a repair kit for this or do I need to find a new fuel rail? If so where to find a rail for a van this old?
View 2 RepliesGolf/GTI VI :: Error Code 000136 - Fuel Rail / System Pressure Too High
So I've gotten this error code a few times now but never a CEL nor does the car drive any diff.
1 Fault Found:
000136 - Fuel Rail/System Pressure: Too High
P0088 - 000 - - - Intermittent
Freeze Frame:
Fault Status: 00100000
Fault Priority: 0
Fault Frequency: 1
[Code] ....
Ford Super Duty (1999-2016) :: Turning Over Fine Just No Start / No Fuel At Rail
I have a 99 f350 super duty with a v10. I drove it Friday night, but it wouldn't start Saturday morning. It is turning over fine, just no start. I have no pressure at the fuel rail. The pump does its little key on run. I can hot wire the pump at the tank, and it pumps. It builds up pressure after the fuel filter. I found that out when I changed the fuel filter. Will the pressure regulator shut off the fuel to the rail?
View 9 RepliesFord 7.3L Power Stroke (1999-2003) :: Fuel Rail And High Pressure Oil Cross Over
Next mods are for the fuel rail cross over and the high pressure oil cross over. I see the unused ports will come in handy.
Fuel delivery? any specialty mods to run the fuel lines? I see it's a #4 ORB fitting. Anyone ever use a "T" or a splitter off the fuel bowl to have a quad line set up?
Saw the FRx from RiffRaff .... not sure how it eliminates air from the system 7.3L Diesel Fuel Rail Crossover? (FRx) 99-03 Powerstroke