Toyota - Pump - Corolla :: Service Engine Light Came On / Water Pump Replacement
My daughter has a 2004 Toyota Corolla and the "service engine" light came on. The diagnosis was that the water pump needed to be replaced.
View 1 RepliesSonata NF (2006-10) :: V6 Water Pump Replacement?
I am trying to replace a water pump on a 2006 Hyundai Sonata, 3.3L, V6. But I hit a snag. I have removed the drivebelt but I can't get the water pump pulley off due to clearance. The water pump pulley is hitting the engine mounting bracket. All the manuals said I could remove the water pump pulley and the water pump and made no mention of removing the engine mounting brackets. I was wondering if there was a way to remove the water pump pulley, and the water pump, without dropping the engine and removing the engine mounts? If I do have to remove the engine mounts, do I need to remove the mounting brackets on both sides?
View 13 RepliesCaravan/Voyager :: 1990 V6 - No Power To The Fuel Pump?
I have 1990 dodge caravan v6, i checked to see if i got power to the fuel pump and there no power going
View 4 RepliesCaravan/Voyager :: Idle (RPMs) Were Very High - Check Engine Light On
My check engine light came on today and while driving, the idle (RPM's) were very high. At about 80KMs, it was about 3500 and when I accelerated, the engine would race along with the RPMs. While stopped, idling seems fine. I couldn't get over 80KMs/Hr without the idle going too high.
What it could be? Haven't had time to check codes as it is long weekend and garages are now closed till tuesday.
Caravan/Voyager :: No Speedometer / Wouldn't Shift And Check Engine Light Came On
I was able to quickly diagnose the problem with our 99 T&C LXi w/3.8L.
Problem: No speedometer, wouldn't shift, check engine light came on.
Many posts suggested speed sensor. There are actually 2 of them. An input and an output. Both cost approx $20 each.
By removing the aircleaner box assembly, I had the best (relative word) access to the sensors. A 1" socket w/3" extension did the trick. I understand the access for 2000+ models is different.
Caravan/Voyager :: 2002 - Check Engine Light On / Intermittent Misfire
I have an 02 Dodge Caravan 3.3 L Flex . It had initially stalled and wouldn't start. Check engine light was on. Had it towed to a Cert Mech. He said it needed a "Major" tune-up. I let him do this. It included: New Coilpak, plugs, plug wires, cam-sensor, crank sensor. That's what was on 1st invoice.
It started, but was still running very rough. He then recommend a new PCM. After choking on his estimate, and paying the initial invoice, I decided to let someone else have at it. Mech # 2 installed a "Rebuilt" PCM, New Battery, and a PCV Valve.
It runs good now BUT, ...It has this weird idle Misfire. The only time it happens is at a stop light when at idle. And it doesnt do it all the time. This check engine light is not on... At this point, all I want to do is sell it.I have over 1K in repair costs and still can't get rid of this misfire.
Passat (B6) :: 2006 2.0t - Timing Belt And Water Pump Replacement?
How to change the timing belt and water pump on a 2006 2.0t passat?
View 3 RepliesCaravan/Voyager :: 2000 3.3L Won't Start After Transmission Replacement
I just replaced the transmission in my 2000 3.3L Grand Voyager and now it won't start. It started fine when I drove it into the shop. The battery is good, the cables are ok. The starter worked good up to this point. I checked all the connections to make sure they are tight. I replaced the transmission because reverse went out.
When I turn on the key, the shift letters (PND32) appear on the instrument panel, but the little circle that shows what gear it is in does not appear. When you turn the key to the run position, the circle should be around the P to show it is in park.
When I turn the key to start, nothing happens. No clicks or anything. The next thing I am going to do is see if there is power to the starter when the key is in the start position. Where to start looking?
Caravan/Voyager :: Check Engine Light Came On And Started Blinking - Random Misfire
I have a 96 Grand Voyager that had had sat for a year undriven or started due to being out of state. It ran like a champ when I parked it. Now I charged the battery and went for a drive on the freeway and my check engine light came on and started blinking. I had the code read it came back with 2 codes a P0306 and a P0300. I noticed that the cylinder 6 spark plug wire was arcing on the core support. So I replaced all the plug wires and spark plugs with Champion platinum spark plugs. I cleared the codes and took it on a test drive and the P0300 code came back. Is there anyway the old gas is causing the random misfire? or what else could it be?
View 1 RepliesCaravan/Voyager :: 1999 - Service Engine Soon Light On / Vehicle Stopped Shifting Into 3rd
Service Engine light came on couple days later turned off, came back on today & vehicle stopped shifting into 3rd. Later this evening was driving it and power steering went out, ABS light came on, temp gauge jumping from hot then cold. When Service Engine light came on originally took to autozone. these are the codes given:
P0700
P1776
P0420
I have read problem could be input or output sensor which are $17 bucks each. Going to try those...
Mileage is 145,000
Toyota - Camry :: 2006 - Water Pump And Serpentine Belt Replacement
Is it possible to change the water pump and serpentine belt in a 2006 Toyota Camry with 4 cyl. engine in less than an hour?
View 4 RepliesCaravan/Voyager :: 2003 - Water Leak On Drivers Side Footwell
I've fixed one source of water that was leaking into the passenger side footwell via the insulation surrounding the A/D drain line, but I still have a leak on the drivers side after a rain, and it's strange. Unlike the leak on the passenger side, this one is not coming along the firewall - the firewall is bone dry. The water seems to be coming vertically straight down, landing on the floor mat, but I can't tell where it's coming from. Not only is the firewall dry, but so is the carpet on all sides of the puddle that collects in the rubber floor mat.
Also, I haven't been able to create the leak by spraying water on the van - I washed it today, for example, and not a drop came in. But we had a light rain last night, and there was a puddle on the floor mat (good thing it's rubber) when I opened the door this morning. I've stuck my head up under the dash immediately after I had found water on the floor mat, but can't for the life of me see any sign of wetness above the location of the water on the floor mat.
And yes, I've cleaned out the drain lines under the cowl in front of the windshield. Where this mystery leak may be coming from?
Caravan/Voyager :: 2002 - Crankshaft Position Sensor Replacement
I need to replace the crankshaft position sensor. On my 2002 Grand Caravan Sport 3.3liter. Where it is in laymans terms.
Is it better to approach from the underside Or from the hood side? I will know it when I see it but I haven't seen it yet!!
Caravan/Voyager :: Power Steering Pump Not In Line 2000 Grand 3.3?
I had a VERY bad leak, to the point where I would fill it, an hour later it all leaked out. I had a mechanic work on it, and he rebuilt the PS pump, BUT the pulley was cracked, they DON'T make that size anymore. He put a bigger one on, only to find out, it was rubbing on my brake lines so I couldn't drive it! SO I had another grease monkey work on it, went through a few new pulley's FINALLY found one! BUT went through 4 Serpentine belts!!
After 3 months with NO VEHICLE, we finally got it all back together. BUT now it is not all lining up we couldn't tell until we had the belt on. it is about a 1/4 of an inch to much to the right.
I'm thinking maybe washers or spacers would work?
Caravan/Voyager :: 2006 / 3.8 Just Stalled At A Set Of Lights
I have a 2006 Grand Caravan 3.8 that just stalled at a set of lights yesterday and have had it towed back to the shop here. I turns over and starts briefly then will die and then just turn over strongly. I cleaned the throttle body and IAC but this did not work. I connected fuel pressure tester and have no pressure when turn key on or turn it over.
The fuse and relay check out ok, so I'm thinking bad or clogged fuel pump.
I have a 2004 Caravan out back that I have used for other small parts to interchange before and was wondering whether or not the fuel pumps between these two are compatible. Be a lot of work to pull the one off the one in the yard, only to find out its not going to fit.
Caravan/Voyager :: ABS Light Keep Coming On
On my 2005 3.3L Grand Caravan the ABS light keeping coming on. I inspected the sensors for the front and used my compressor to give them a quick puff of air to get rid of dust. The light went off for about 5 days. Now it is back on.
How does one read ABS codes? If I knew for sure that the problem is a speed sensor and which one I could clean or replace the faulty sensor.
If I clean to sensor are there any special precautions I need to take? As far as I could see they didn't look very dirty.
Caravan/Voyager :: 2006 Grand / Only Runs With Foot On Gas Pedal?
Have a 06 Grand Caravan 3.8L that suddenly quit and would start back up easily enough, but one had to keep foot on the gas to keep it going.
I pulled two codes:
P0123-throttle postion sensor 1 high
P0508-IAC valve sensor circuit low/undercurrent
So far I have removed the IAC and cleaned it with throttle body cleaner, cleaned throttle body out as well with the spray, installed new EGR since it got mangled trying to remove it for cleaning. Removed the TPS connector and with key on, took measurements and I am getting a reference voltage proper ( almost 5 volts). I then back probed the connector once it was plugged back in and again things checked out, the reference lead was varying between .7 and 4.7 volts as I manually moved the throttle plate.
I had switched out the IAC with a used one, from an engine that had been running before being parked, but it made no change.
Note: I have a new TPS but am holding off on changing it until I investigate whether or not it may have a clogged fuel filter causing it to stall at idle speed. Now if can just locate where it is..the sketchy diagrams in my Alldata program are useful.
Caravan/Voyager :: 2006 Dodge Heater Only Work For 2 - 3 Minutes
I have a 2006 Dodge Caravan, My AC unit works great. With the heater, it will work for 2-3 minutes, at which point it starts to blow cool air. I can leave it running, but it never gets warm again, if I turn the fan off for 3-5 minutes, when I turn it back on, I get a good amount of heat that goes for about 2-3 minutes before blowing cold air again.
View 1 RepliesCaravan/Voyager :: 2006 Dodge - Windshield Wiper Not Turning Off
I'm having electrical issues in my 2006 Dodge Caravan. It started with the radio not working (even though the lights around the nobs and buttons light up) and the lock button doesn't work until the van is started. Now, the windshield wiper won't turn off, even after the van has been turned off.
View 1 Replies