Caravan/Voyager :: 2002 - Crankshaft Position Sensor Replacement
I need to replace the crankshaft position sensor. On my 2002 Grand Caravan Sport 3.3liter. Where it is in laymans terms.
Is it better to approach from the underside Or from the hood side? I will know it when I see it but I haven't seen it yet!!
Caravan/Voyager :: 2006 - Engine Light Is On After Water Pump Replacement
I had to replace the water pump on my dodge Grand Caravan, which was challenging, but I got it done. But now the engine light is on.... why would that happen? I did take off the filter hose, and unplugged the cord to move the air filter housing, but I plugged it back in when i re-hooked everything up. So now I am nervous that i did something wrong. Why the engine light would come on and stay on? water pump works, put coolant in etc.... no leaks.... so now i just need to figure out the engine light.
View 9 RepliesCaravan/Voyager :: Change Transmission Filter On 2008 GC SXT
Since there is not dipstick for a 2008 GC with six speed transmission, how much transmission fluid goes back?
View 2 RepliesCaravan/Voyager :: 05 - Transmission Slipping When Engine Is Cold
My transmission is slipping when the engine is cold. Fluid levels seem fine. I do have a fluid leak that I monitor and add fluid when needed. It's an 05 touring with 167k miles.
View 1 RepliesCaravan/Voyager :: Loosing Transmission Fluid - No Puddles Anywhere
I have a 91 Grand voyager and it seems to be loosing transmission fluid somewhere but no puddles anywhere.It looses between 3/4 and 1 quart a month an shifts fine. Where could this be escaping at as I drive it? What do I need to look at since its not dripping anywhere an I snugged the pan an didn't see it there?
View 3 RepliesCaravan/Voyager :: 1995 Plymouth SE Transmission - Only Go In First Gear And Never Come Out
I have a 1995 Plymouth Voyager se about a year ago the transmission started acting up, for no reason, it would just go it to First and never come out I would stop turn it off turn it back on again and it would be fine..then days later it would go by, it would do it again. it did this for a while and the good days would turn in to a mile or two then it just decided not to come out of first ever, during this, i took it to a trany shop and rebuilt the transmission it worked for a bout a half hour.
Final a mechanic friend checked the computer again and changed it out with another and it fixed it beautifully!!! ok well about a week ago a very odd loud obnoxious squeal started that sounded like a bottle rocket but not all the time, more often than not though. Before I got a chance to take it to my mechanic friend i was driving along and the transmission slipped in to first and wont that's it. i have been doing emergency trips in first gear and also the horrid squeal is gone. the thing have to be linked what should I try and i don't think its the computer, I really don't want to lose my van
Caravan/Voyager :: 2002 LX V6 - Transmission Stopped Shifting From 3rd To 4th Gear
I have a 2002 Town and Country LX with the 3.3L V6. Recently the check engine light went on and later the transmission stopped shifting from 3rd to 4th gear. All the gears work properly except for 4th. It doesn't seem like anything is wrong with the transmission, would this be a sensor problem? If so which sensor would need to be replaced?
View 14 RepliesCaravan/Voyager :: Bump / Violent Shudder Between 1 To 2 Transmission Shift
I am experiencing a very frustrating shift anomaly. 2003 T and C . Under certain throttle conditions ( usually light ) from a dead start I am feeling a bump/violent shudder between the 1-2 transmission shift. If I let off the gas, I can get the shudder to quit and then by continuing to accelerate , successfully complete the 1-2 shift.
Does not happen all the time and never under straight ahead med-hard acceleration. By nature , happens most of the time under light acceleration when turning a corner from a dead stop. Sort of feels like a loss of traction or something funky happening with the torque convertor. Have serviced the trans with new fluid and filter, new TPS, new plugs, wires, and coil pack.
Caravan/Voyager :: 97 - Transmission Vibration (Passenger Side CV Axle)
I have a problem with our 97 Grand Caravan, (3.3L, 41TE tranny) Its a vibration that seems to be coming from the passenger side CV Axle.... the transmission side of the universal joint on the new axle.
We started having problems with this in December, I've done most of the work myself but still had the problem... Vibrations that seem to start and get worse at around 35 - 55 MPH. I've replaced rims, wheel bearings, both cv axles, tires, brake pads & rotors, sway bar links and bushings, tie rod ends, (inner & outer) and ball joints. (about $1,200. in new parts & tires)
In April, I finally took it to several transmission shops and talked to the operators.... The shop I chose because I could relate to the owner and felt I could trust him. The wife and I knew it was a vehicle we couldn't replace for the price of a transmission overhaul and when the shop called and told me all was fixed by replacing the new cv axle on the passenger side I was ecstatic that the problem would be fixed.... I go ahead and rebuild the transmission anyway, (now @ 289,000 miles!) .... The wife and I want to get as many miles out of this thing as we can at this point and our daughter will be driving it to high school next year.
Anyway, I get the car back late on a friday evening.... by the time I got it home I knew there was a big problem.... I put it up on jacks in the garage and saw the passenger side axle was "Slamming" in and out of the transmission!!! I test drove it on a few more short trips and took it back a week later.
About 1 1/2 weeks later I get a call and the shop owner says it is the CV axle thats bad.... AGAIIN??? Lets see, I replaced the original axles. Then "they" replaced both axles after I returned the ones I put in for warranty (Autozone) and now a 3rd axle is bad too? He insists on a different brand of axle (Napa). So when I get the car back, I again am feeling some vibrations.... not nearly as bad as it was before, and put the car up on jacks again.
This time, I don't see the axle slamming in and out of the tranny but I see the vibration comming from the trany side of the CV axle. (passenger side axle again) and I notice some grey goop on the housing fitting that wasn't there before on the trany.... This is when I started having my doubts about the shop and what they are telling me. They just replaced the axle, didn't do anything in the tranny. To beat all, theres now a fluid leak somewhere and its staining the garage floor.
Its been over two weeks now and the shop owner called me to tell me that its again the passenger side axle thats bad and that its a seal somewhere tha'ts leaking so he's gonna have to pull the tranny to get at it. I told him what I saw when I put it up on jacks in my garage.... the vibrating CV axle on the passenger side of the tranny.... He assures me that if it were a bearing it would be making some noises. He's even sent the car to a trusted tire shop and they turned the rim on the tire or something.... he's doing everything he can to make sure the problem is taken care of.
I know what I saw under the car. Just the "passenger side" axle as it is coming out of the transmission housing is moving up/down/around and that's where my vibration is coming from. The end of the axles (tire side) were running true. What's involved in repairing the differential side bearings in these tranny's? I'm going fully loaded to the Transmission shop when its ready and I'm going to insist we look at it while its on the rack. I just need to know how to check these differential side bearings.
Caravan/Voyager :: 1996 Dodge 3.8 V6 Transmission Making Horrible Shudder
So here I am with my 1996 Dodge grand caravan that I purchased new in 1995 for a whopping 30k. Yeah hind site is 20/20 skip forward to mile 102k transmission fails completely. Had to have it towed in to shop, rebuilt tranny put in... skip ahead another 4 years to mile 173k and transmission fails again. Again on a tow truck to the shop and ANOTHER tranny rebuild. So now I am at mile 182k and transmission is making a horrible shudder and I have moved across the country away from original shop that did last trans repair (who says they only warranty if I come back to them) and I am possibly looking at another repair or replacement. What is the deal with these vans?
View 4 RepliesCaravan/Voyager :: 2000 - RPMs Will Jump Up 400 And Go Back While Driving
My wife has a 2000 t&c with 150k on it its a fwd with 3.8 and about a month ago while driving we noticed the rpms will jump up 400 and go back, with cruise control on or off being held at a consistent speed. and about for days ago it started shifting late. Still has all gears fluid looks o.k. and is full no check engine light .
I am hearing transmission solenoid, tps sensor, input sensor, output sensor, tcm, iac, map, or egr are all possibilities or a rebuild . Or simple as a flush.. tonight i went out n started it it idles around 800 tried to hold it at 1200 and it would for a second and drop back to 800 with accelerator being slightly held. Not sure if related. Just observed it..
Caravan/Voyager :: 2000 - Shuddering While In Gear And Not Moving Especially In Reverse
My 2000 dodge caravan with the 3.3 is shuddering while in gear and not moving especially in reverse . As soon as you start going it stops . No slipping whatsoever. The van only has 130'000 miles on it .
View 2 RepliesCaravan/Voyager :: 2000 Van Jerks Hard And Speed Drops At Highway
My van just started to have this issue today with jerking real hard like its dropping a couple of gears while going between 50-60mph. It is a 2000 with the flex fuel 3.3L 4 speed auto.When this happens the spedo will go from 55mph to 40 instantly while keeping a steady speed and it feels like the tranny is going to rip right out. This will happen every 5 to 10 min but go back to normal driving after 3 sec and has not popped any codes. It runs like a top and all fluids are at the correct levels. I have to commute 50 miles a day to work so i really need to figure this out!!!
View 1 RepliesCaravan/Voyager :: 2000 - Overheating After Driving On The Interstate For Half Hour Or So
My GC is overheating. Started as occasionally but now increasing in frequency. I find it will being to overheat after driving on the interstate for half hour or so but I can "calm" it back down but turning on the heat. I've replaced the following:
1. coolant (no drips or leaks nor am I losing coolant over time)
2. thermostat (twice)
3. temperature sensor
4. serpentine belt and tensioner
5. radiator (last summer)
6. water pump (last winter)
I notice the fans run more often than they should. For example, after a 10 minute ride to work in the morning,. I notice the fans are running as I pull into my parking space.
Caravan/Voyager :: 2000 Dodge Grand - Driver Side Not Bowing Hot Air?
Drivers side not bowing hot air? We changed the blower motor and the resister on the passenger side. We hadn't tried to use the heat until last night when we needed the defrost and that's when we realized only heat on passenger side.
View 1 RepliesCaravan/Voyager :: 2000 / 3.0L - Engine Shuts Off When Drive Up To Traffic Lights
Dodge Grand Caravan 2000 3.0L
First, sometimes the engine began shuts off. When the drive up to the traffic lights. When sharply throw gas pedal. When the engine speed is less than 2000. If you release the gas pedal, you will see that the tachometer needle drops below 500 rpm and the engine stalls. This happened happened two or three days all right. And sometimes a day, 3-4 times shuts off. Then ringing under the hood.
Was the flywheel. I remove the transmission and replace the flywheel. More repair parking brake pedal. So it turns analyzed under the panel. I have a new problem. After repair. I driving my Dodge week. And once. After an overnight stay the machine, on morning the engine not start. I checked the spark. The spark is. I removed the fuel hose. and there is no pressure. Just a little bit of fuel.
I decided that this is the fuel pump. I took off his tank, bought a new fuel pump. The pump has not changed. Today I decided to apply voltage to the old pump, it still stands in the tank. It works. Buzzing. Then I decided to check the voltage on the connector. I turned on the ignition. The instrument appears briefly on 12 volts. They are only momentary. Now I think there should always be 12 volts? Fuel tank removed. All hoses are disconnected. Not really the problem in the fuel pump? How to troubleshoot? Where can I get the wiring diagram?
Caravan/Voyager :: 2000 Dodge 3.3 Engine Noise At Idle And Under Low RPM Load
I have an engine noise on my 2000 Dodge Caravan with the 3.3 engine. It sounds a lot like the grinding of a rotating part. It occurs at start up, momentarily, then goes away. If I drop it in gear and start doing low speed maneuvering in the driveway, it comes back. If I turn on the AC it comes back. In all cases, the noise goes away at around 1200 rpm.
The noise occurs again, when I shut the engine down.The engine performs and runs smooth and normal otherwise. No stalling, stumbling, or bad gas mileage to report.
I can "feel" the noise with my hand, when I put my hand on the ac compressor bracket, or the intake manifold, or the valve cover. I've tried the listening through the stick method, and it seems to be coming from the front area of the engine. But I can't be sure. It is something internal. Let me describe:
I thought it was my AC compressor or clutch going bad. The fact that my AC had stopped working well, and was making jet engine noises at high rpm supported me decide this. I replaced the compressor. The AC works great now, and the jet engine noises went away. But the grinding noise is still there. As described.
I wishfully thought it was the belt tensioner or idler pulley. I replaced both of those. Noise still was there. I pulled off the serpentine belt, and started the engine. It made the noise, very briefly as it started, then went away completely. It made the noise again briefly as I shut the motor off. So it's still there without any of the accessories turning.
The noise is loud and obnoxious at idle when under load. It just can't be good. I've read theories about similar sounding problems, saying they could be loose timing chain, bad oil pump, slapping pistons, crank journals, flexplate/flywheels cracked.
I'm going to try doing an oil system flush, and then I'll change it out with a little thicker oil. See if that makes any difference in the noise. Currently I'm running 5w-30 Mobile 1. I think. I'll let you know if it changes anything. I'm also thinking I want to make a short video of the car idling and making the noise for my video camera. I'll post that on youtube and link it here.
Caravan/Voyager :: Power Steering Pump Not In Line 2000 Grand 3.3?
I had a VERY bad leak, to the point where I would fill it, an hour later it all leaked out. I had a mechanic work on it, and he rebuilt the PS pump, BUT the pulley was cracked, they DON'T make that size anymore. He put a bigger one on, only to find out, it was rubbing on my brake lines so I couldn't drive it! SO I had another grease monkey work on it, went through a few new pulley's FINALLY found one! BUT went through 4 Serpentine belts!!
After 3 months with NO VEHICLE, we finally got it all back together. BUT now it is not all lining up we couldn't tell until we had the belt on. it is about a 1/4 of an inch to much to the right.
I'm thinking maybe washers or spacers would work?
Caravan/Voyager :: 2000 - Battery Died As Radiator Fans Staying On
So my radiator fans were staying on until my battery died and my car was completely cooled down and off. I was told it was a sticking relay so I replaced it and the fans still won't come on. I unplugged the coolant temp sensor and the fans came on so I know its not the motors or anything.
View 5 Replies